The contact owns a 2006 Chevrolet Malibu. The contact stated that while pulling out of a parking space, the vehicle lost power steering functionality, causing the steering wheel to become difficult to turn. The power steering warning light was illuminated. The vehicle was pushed back into the parking space. The contact stated that the failure was intermittent. The contact stated that the steering gear was previously replaced due to a similar failure. The contact associated the failure with the federal safety agency Campaign Number: 15V064000 (Steering); however, the VIN was not included. The manufacturer was contacted and informed the contact that the VIN was not associated with the recall. The vehicle was not repaired. The failure mileage was approximately 158,000.
2006 Chevrolet Malibu: loss of power steering
239 of the 1,119 complaints about the 2006 Chevrolet Malibu describe loss of power steering.
- owner complaints
- 239
- of this car's complaints
- 21%
- typical repair cost reported
- $700
- typical mileage
- 92,000
- recalls
- 2
Loss of power steering by model year
What owners say
The power steering went out on the car as I was driving down the highway going 65 mph
The contact owns a 2006 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. There were three audible dings with the message "Power Steering" displayed on the instrument panel. The contact reset the steering wheel and the battery, but the failure persisted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to the federal safety agency Campaign Number: 15V064000 (Steering); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was unknown.
The contact owns a 2006 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The power steering failure warning light was illuminated. The vehicle was driven to the independent mechanic, where it was diagnosed with STRG shaft torque failure. The contact was informed that the STRG shaft torque needed to be replaced. The vehicle was not repaired. The contact was advised to contact the dealer. The contact was made aware of the federal safety agency Campaign Number: 14V153000 (Steering). The dealer was made aware of the failure but provided no assistance. The contact was informed that the recall repair was performed in 2015. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000.
The contact owns a 2006 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, an alarm sounded, and the message "Power Steering Failure" was displayed. No warning light was illuminated. The contact pulled over to the shoulder of the road to restart the vehicle however, the failure persisted. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. Another local dealer was contacted and informed the contact that the vehicle was previously repaired under the federal safety agency Campaign Number: 14V153000 (Steering); however, the contact stated that the vehicle was never repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 118,000.
Steering got stiff and hard to turn and it shakes while idle
The contact's granddaughter owns a 2006 Chevrolet Malibu. The contact stated that while driving at various speeds, the power steering assist failed to operate as needed. The contact stated that the "Steering Assist Reduced - Drive with Care" message was displayed on the instrument panel. The contact replaced the electronic power steering fuse; however, the failure returned soon after the repair. The vehicle was taken to an independent mechanic and the contact was informed that the steering column needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and informed the contact that the vehicle was not included in the federal safety agency Campaign Number: 15V064000 (Steering). The manufacturer was not notified of the failure. The contact was referred to the federal safety agency Hotline to report the failure. The approximate failure mileage was 165,000.
in 2014 there was a GM safety recall #[XXX] to replace Torque sensor assembly on electric power steering. Recall was completed by GM. Now, the electric power steering has failed again with the same warning signals that GM originally advised would happen. Issue has been diagnosed as failure of the power steering assist motor. In two separate conversations with GM one with (Sam) & another with (Chasity), GM case #[XXX], one says repair should be covered by GM & the other says it will not be covered. the federal safety agency campaign ID # for this recall is [XXX]. Requesting that the federal safety agency help me get to the bottom of this situation. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving, the power steering stopped working and I couldn’t turn the wheel. This will be the 2nd time in 7 months that I will have had to replace the electrical power steering
While driving the power steering message came on screen. And all electrical power steering assist stopped working. Had to use all my strength just to turn the steering wheel.
The electric power steering went out while I was driving. I will not be able to send the part in for inspection until it gets replaced. My safety and others were at risk because it made it really difficult to change lanes which could've resulted in a crash. The problem hasn't been reproduced on my vehicle specifically, but has been produced on enough vehicles to have a recall issued. There weren't any warnings prior to the power steering going out. Just a beep and a warning on the radio display as it went out. My vehicle was manufactured in May of 2006 but want recalled, although the affected vehicles were made from April - June 2006. This is the second one that has gone out on me and there is still no recall for my vehicle. First one happened October of 2020, got it fixed then the second one went out November of 2023.
Sudden loss of power steering while accelerating
Service bulletins that may apply
- This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with...
- This technical bulletin provides a procedure to eliminate a power steering noise due to extremely low...
- Steering
- Steering
- Electric Power Steering Assist
- Summary to be provided on a future date.
- Buick/cadillac/chevrolet/gmc/pontiac/ saturn: there is fluid leaking from power steering system, along a...
- This technical bulletin provides a revision for 12-02-32-002 to add the 2013-2014 model years, add noise...
Related recalls
Steering: electric power assist system
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
- Risk
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or Pontiac customer service at 1‑800‑762‑2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V‑153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Recall number 15V064000 · Recall details
Steering: electric power assist system
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
- Risk
- If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1‑800‑630‑2438, Saturn at 1‑800‑553‑6000, and Pontiac at 1‑800‑620‑7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Recall number 14V153000 · Recall details
Questions about the 2006 Chevrolet Malibu power steering loss
Is loss of power steering a common problem on the 2006 Chevrolet Malibu?
239 of 1,119 owner complaints about the 2006 Chevrolet Malibu (21%) mention loss of power steering. The model year with the most reports is 2004.
How much does it cost to fix loss of power steering on the 2006 Chevrolet Malibu?
Owners who mentioned a price put the repair at about $700 (median of 15 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
Is there a recall or service bulletin for this on the 2006 Chevrolet Malibu?
There are 2 recalls and 16 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2006 Chevrolet Malibu
Steering lock-up 118Loss of power 81Engine failure 50Check engine light 49Fuel gauge 49Stalling 39Steering noise 34Jerking 28Won't start 26Fuel pump 21Harsh shifting 20Adaptive cruise 19Pulling 18Headlights 13Knocking 11Warning lights 11Airbag light 9No deployment 9Grinding brakes 8ABS 7Ball joint 7
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Chevrolet Malibu?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history