Chevrolet Monte Carlo recalls

What is wrong

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V‑118, 09V‑116, and 15V‑201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Risk

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy

The remedy applied under recalls 08V‑118, 09V‑116, and 15V‑201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V‑118, 09V‑116, or 15V‑201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1‑800‑222‑1020, Buick customer service at 1‑800‑521‑7300, Oldsmobile customer service at 1‑800‑442‑6537 and Pontiac customer service at 1‑800‑458‑8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Recall number 15V701000 · Recall details

What is wrong

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

Risk

The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

Remedy

GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1‑800‑521‑7300, Pontiac customer service at 1‑800‑762‑2737 or Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is 14574.

Recall number 15V201000 · Recall details

What is wrong

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Risk

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Recall number 14V400000 · Recall details

What is wrong

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Risk

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1‑800‑521‑7300 (Buick), 1‑800‑458‑8006 (Cadillac), and 1‑800‑222‑1020 (Chevrolet). GM's number for this recall is 14299.

Recall number 14V355000 · Recall details

What is wrong

General motors is recalling 1,497,516 my 1997-2003 buick regal, my 1998-2003 chevrolet lumina, monte carlo and impala, my 1998-1999 oldsmobile intrigue, my 1997-2003 pontiac grand prix vehicles equipped with a 3.8l v6 naturally aspirated engine. Some of these vehicles have a condition in which drops of engine oil may be deposited on the exhaust manifold through hard braking.

Risk

If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and may spread to the plastic spark plug wire channel and beyond increasing the risk of an engine compartment fire.

Remedy

Dealers will replace the engine’s front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engine’s plastic cover and plastic oil-fill-tube extension, free of charge. The recall is expected to begin during may 2016. Owners may contact chevrolet at 1‑800‑630‑2438, oldsmobile at 1‑800‑630‑6537, and pontiac at 1‑800‑620‑7668 or http://www.pontiac.com or http:www.gmownercenter.com.

Recall number 09V116000 · Recall details

What is wrong

Certain passenger vehicles were produced with lower than specified torque on both front brake caliper to steering knuckle attachment bolts. With improper torque, the clamp load at the joint may not be adequate to prevent movement between the caliper bracket and knuckle.

Risk

Depending on whether one or both bolts backs out or fractures, the result can be locking of the affected wheel during braking and an abrupt steering input in the direction of the locked wheel, reduced braking and noise from the affected wheel, or severing of a brake hose, increased brake pedal travel, and reduced steering control. Reduced braking or steering control could cause a crash.

Remedy

Dealers are to tighten both bolts to the specified torque. Owner notification began on june 28, 2004. Owners should contact chevrolet 1‑800‑630‑2438 or pontiac 1‑800‑620‑7668.

Recall number 04V287000 · Recall details

What is wrong

On certain passenger vehicles equipped with 3800 v6 (l36) engines and certain delphi fuel pressure regulators, the regulators have a much higher than usual rate of fuel leaks. A leak can allow fuel to enter the intake manifold through a vacuum line. If the engine does not start when cranked, the fuel from the leaking regulator and a mistimed spark can cause a backfire.

Risk

The backfire can rupture the intake manifold. The rupture of the intake manifold can displace a fuel line, pulling an injector out of place, and causing a fuel leak and possible fire.

Remedy

Dealers will install new fuel pressure regulators with improved diaphragms. The recall will be conducted in phased mailings. Phase 1 began on june 30, 2004, and phase 2 began on september 30, 2004. Owners should contact buick at 1‑866‑608‑8080, oldsmobile at 1‑800‑630‑6537, or pontiac at 1‑800‑620‑7668.

Recall number 04V090000 · Recall details

What is wrong

Certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. These retainers could fail and permit the ball bearings to escape.

Risk

If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. If the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. If the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. With the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. In any of these conditions, a crash could occur.

Remedy

Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. Owner notification began on february 5, 2004. Owners should contact buick at 1‑866‑608‑8080; chevrolet at 1‑800‑630‑2438; oldsmobile at 1‑800‑630‑6537; or pontiac at 1‑800‑620‑7668.

Recall number 03V527000 · Recall details

What is wrong

Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system.

Risk

This does not meet the requirements of the standard.

Remedy

Owners will be provided with a supplement for their owner's manual. This supplement describes and shows the location symbols for the child restraint anchors that are located in the vehicle and on the child restraint or booster cushion. Owner notification began august 18, 2003. Owners should contact buick at 1‑866‑608‑8080, cadillac at 1‑866‑982‑2339, chevrolet at 1‑800‑630‑2438, gmc at 1‑866‑996‑9463, pontiac at 1‑800‑620‑7668, or oldsmobile at 1‑800‑630‑6537.

Recall number 03V250000 · Recall details

What is wrong

On certain mini vans, passenger and sport utility vehicles, some of these vehicles have a driver's side air bag that may not deploy as designed. In addition, the air bag inflator could rupture.

Risk

This could result in reduced capability of the air bag to protect the driver. Also if the air bag inflator ruptured, pieces of the inflator could strike and injure the vehicle occupants.

Remedy

Dealers will inspect, and if necessary, install a new driver's air bag. Owner notification began on march 11, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1‑800‑521‑7300, cadillac at 1‑800‑458‑8006, chevrolet at 1‑800‑222‑1020, gmc at 1‑800‑462‑8782, or pontiac at 1‑800‑762‑2737.

Recall number 03V051000 · Recall details

What is wrong

On certain passenger, sport utility vehicles and mini vans, some of these vehicles have a passenger air bag that was manufactured without a check valve pin. An air bag without the check valve pin could produce increased pressure at the onset of the air bag deployment and reduced pressure afterward.

Risk

This could increase the severity of injury to a person who was not properly restrained and who was close to the passenger air bag at the time of deployment. It could also reduce the ab8ility of the air bag to protect a restrained front seat passenger.

Remedy

Dealers will inspect and, if necessary, replace the passenger air bag. Owner notification began december 16, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1‑800‑222‑1020, pontiac at 1‑800‑762‑2737, oldsmobile at 1‑800‑442‑6537, or saturn at 1‑800‑553‑6000, prompt #3.

Recall number 02V329000 · Recall details

What is wrong

Certain passenger, mini vans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment.

Risk

Pieces of the inflator could strike and injure vehicle occupants and the air bag cushion would not inflate fully, reducing the capability of the bag to protect the driver.

Remedy

Dealers will inspect, and replace, if necessary, the air bag module assembly on the driver's side. Owner notification began august 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1‑800‑521‑7300, cadillac at 1‑800‑458‑8006, chevrolet at 1‑800‑222‑1020, gmc at 1‑800‑462‑8782, oldsmobile at 1‑800‑442‑6537, or pontiac at 1‑800‑762‑2737.

Recall number 02V222000 · Recall details

What is wrong

Vehicle description: passenger vehicles. The air bag sensing and diagnostic modules (sdm) could experience a memory error resulting in the air bags not deploying in a crash situation.

Risk

In a crash, a front seat occupant may receive more serious injuries.

Remedy

Dealers will replace the sensing and diagnostic module.

Recall number 00V244000 · Recall details

What is wrong

Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."

Risk

In the event of a vehicle crash, the occupant may not be properly restrained.

Remedy

Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.

Recall number 00V228003 · Recall details

What is wrong

The center rear seat belt anchor plate exhibits stress cracks.

Risk

In the event of a vehicle crash, the seat belt system can fracture and injury to the seat occupant can occur.

Remedy

Dealers will replace the center rear seat belt system.

Recall number 97V065000 · Recall details

What is wrong

Vehicle description: passenger vehicles and mini vans originally sold or currently registered in the following states: connecticut, illinois, indiana, maine, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont and wisconsin. The rear cradle bolts pull through the retainers due to corrosion of the retainer. If both bolts pull through, the rear cradle would not longer be supported at these mounting locations and the steering intermediate shaft can separate from the steering gear.

Risk

If this were to occur while the vehicle was in motion, a vehicle crash could result.

Remedy

Dealers will replace the rear cradle bolts and retainers.

Recall number 97V058000 · Recall details

What is wrong

Some of these vehicles have a strained or separated washer/wiper switch power feed wire.

Risk

This can cause the windshield washer/wiper to work intermittently and could ultimately result in inoperative wipers. If this were to occur in a severe weather situation, driver visibility could be reduced, increasing the risk of a vehicle crash.

Remedy

Dealers will inspect and replace the old designed washer/wiper switches with a newly designed switch.

Recall number 97V017000 · Recall details

What is wrong

These vehicles were assembled with one of the four brake booster tabs not properly located in the front of dash reinforcement assembly.

Risk

If this condition were present in a situation where stopping distances were small, a vehicle crash could occur.

Remedy

Dealers will inspect for proper booster installation. Boosters found to be improperly located will be removed and reinstalled properly.

Recall number 96V122000 · Recall details

What is wrong

A right-hand lower control arm tapered ball joint mounting hole was incorrectly machined. Movement within this attachment can allow the ball joint stud to fatigue and fracture.

Risk

If the ball joint fractured while the vehicle was in motion, loss of steering control to the vehicle can occur.

Remedy

Dealers will replace the right-hand lower control arm and ball joint stud on all involved vehicles.

Recall number 94V230000 · Recall details