Chevrolet S10 fuel pump problems

Filed Oct 8, 2014 · Body, Fuel system · 86,000 miles · NY

Tl* the contact owns a 2002 chevrolet s-10. While refueling the vehicle, the contact noticed that fuel was leaking. The dealer stated that the fuel pump needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was not notified. The approximate failure mileage was 86,000. Updated 11/26/14*cn the consumer stated the vehicle had two gas leaks. Updated 10/5/2015

Filed Oct 3, 2014 · Acceleration, Fuel system · 15,000 miles · CA

Tl* the contact owns a 2000 chevrolet s10. The contact stated while driving approximately 65 MPH with the cruise control activated, the engine stalled without warning. The contact was able to restart the vehicle but the failure recurred multiple times. The vehicle was towed to the dealer. The technician diagnosed that the electric fuel pump was defective and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 15,000. Updated 11/20/14*lj..updated 11/24/14 *bf updated 05/4/02015 *js updated 08/30/2017

Filed Jul 11, 2012 · Engine · 145,000 miles · OH

Tl* the contact owns a 2001 chevrolet s-10. The contact stated that while driving 35 MPH, the vehicle stalled. The vehicle was safely coasted to the shoulder and restarted as normal. The failure recurred several times later. The vehicle was not taken to the dealer for inspection. The contact stated that he performed a manual diagnostic, but was unable to determine the failure. The manufacturer was notified and stated that there were no known similar complaints. The vehicle was not repaired. The failure mileage was 145,000. ....updated 08-24-12 *bf the consumer stated all gauges shut down. The fuel pump was replaced. Updated 08/30/2012

Filed Dec 17, 2010 · Fuel system · WI

1999 chevrolet s10. Consumer states that he had a fuel pump replaced after the original failed. The replacement part failed after less than a year. *kb the consumer also stated the second fuel pump was defective. The consumer is requesting reimbursement for the second defective fuel pump.

Filed Aug 28, 2009 · Fuel system, Visibility · 70,400 miles · IA

Tl*the contact owns a 1997 chevrolet s10 pickup truck. The windshield wipers failed to operate normally. The mechanic stated that recall the federal safety agency campaign id number: 03v159000, windshield wiper motor is related to the failure. The manufacturer stated the VIN was not a part of the existing recall and that they would be liable for the repairs. The contact was concerned that if this were to occur when it was raining the driver's visibility would be reduced. The contact is also concerned of the safety risk which could result in a crash. The fuel pump also failed at 27,000 miles. The current and failure mileages were approximately 70,400.

Filed Apr 2, 2009 · Electrical, Fuel system · 28,000 miles · TN

I have a 2003 s-10 with 28,000 miles. I have had to replace both co2 sensors and now it won't start. It just started jerking and the fuel pump and filter work fine. Its getting gas and has a new battery. The check engine light is on. It wants to start but it doesn't. Also the radio comes on when I turn it off. What gives? This is my 3rd s-10....

Filed Feb 13, 2009 · Fuel system · 69,200 miles · OH

I have a 2000 chevy s-10, 4.3 liter with 69300 miles on it. The engine on this vehicle does not want to turn over and run. I 've had this happen on 5 occasions within the past month. I know it is a gas problem getting to the carburetor since I have splashed a little gas or starting fluid in the carburetor to see if the engine will fire up. The engine does start but shuts down because of a lack of fuel to keep it running. I have replace fuel filter 2 times, map sensor and have recently read that gm used a sock strainer on the fuel pump that tends to get clogged up. I also understand that gm has resolved this problem with a different style of strainer. I am very concerned about this since the last time my engine failed I was driving on a busy cleveland, ohio interstate (I-77 by pershing ave exit ramp). I was able to get the vehicle restarted after several attempts to turn the engine over. I have seen cars on the side of the interstate get hit and concerned for my own safety and health if this should occur again. I believe since gm has and has knowledge of this defect on their part that they should recall all vehicles that use or used this type of strainer on the fuel pump unit. It is just a matter of time before someone is killed because of this irresponsible action on gm to havethe vehicles that are on the road with the problem fuel pump stainer.

Filed Dec 17, 2008 · Fuel system · 88,900 miles · CA

2003 chevrolet s-10. Truck didn't start, dealer replace fuel pump (close to $400 ) for pump. Truck doesn't have 90,000. Last time I buy chevrolet.

Filed Mar 29, 2008 · Fuel system · 122,945 miles · PA

My 2000 s10 would not start last week. Had it towed to garage. Figured it was fuel pump. It was, but upon inspection, the fuel tank was rusted out along with the bands holding the tank on. Paid $1,000.74 to have it repaired.

Filed Jan 1, 2007 · Fuel system · KY

I have an 2001 s-10 extended cab 4x4 truck. I have had to have this truck towed 4 times & 4 or 5 fuel pumps put in also a wire that goes to fuel pump & a new gas cap also. I bought this truck in june of 06 & drove it 3 days before the first break down. It was down for 2 months. The place of purchase LED me to believe that the truck was in perfect condition with no problems or any wrecks. When the truck was towed to a chevy dealership for repair it cost over 500$ just in labor alone not to mention the cost of the fuel pumps & full diagnostics. I am still having problems with the gas tank. When I fill the truck up it runs out the top of the tank itself under the bed of my truck . Isn't this a danger to my safety ? The chevy dealership doesn't want to stand by their work now so I'm stuck with a deadly vehicle. I plan to file any complaint I can & if possible I will get it on the news as well. Within a few hours of my buying this junk the auto dealer where I bought it sold my contract to a finance company so now the dealer is not responsible for the things that were & are bad. The truck bed only had 1 bolt holding the whole bed on & the gas tank only had 1 strap on 1 side holding the gas tank up... The finance company won't help with this problem either. I have been researching this type of truck & have found that way to many people have the same problems as I do when it comes to the gas tank & fuel pump. Shouldn't someone be held liable for this problem ? Would the makers of the s-10 truck allow their kids or family to ride in a truck that could possibly one day cause their death ? When a gas tank leaks fuel from the tank under the truck what would happen if at a stop light someone throws a cigarette out & it hits the gas that's leaked out ? My opinion the truck would blow up. If there is anyone who can tell me where to complain I'd be ever so grateful for that info. Cathy in ky.