2002 Chevrolet Silverado 1500 HD problems

Filed Apr 6, 2018 · Brakes, Fuel system · 28,000 miles · VA

Tl* the contact owns a 2002 chevrolet silverado 1500 hd. While the vehicle was being serviced by an independent mechanic, the contact was informed that there was severe corrosion to the brake and fuel lines. The vehicle was repaired. A local dealer was not contacted. The manufacturer was notified of the failure. The approximate failure mileage was 28,000.

Filed Dec 1, 2016 · Brakes · 113,000 miles · MD

While driving down the interstate last week I went to brake for an exit only to find that I had no brakes. It turns out my brake line had rusted through and my brake fluid had been draining my whole trip down the interstate. I was lucky enough to manage to get off the road and park my vehicle and call aaa to have my vehicle towed. I am now finding out that this is a very common issue with gmc older trucks. This is not acceptable. Lives are at risk.

Filed Jan 29, 2015 · Engine · 132,000 miles · MI

3 exhaust manifold bolts broke off manifold.

Filed Jan 9, 2015 · Brakes · 112,000 miles · CT

The brake lines on my 02 silverado blew out while moving our camper trailer into our back yard for storage. My wife was driving and I was watching her backing up. She yelled out to me the "brakes feel funny", we were almost done and unhooked the trailer. I moved the truck to the street and noticed the pedal went to the floor and would not stop easily. I noticed a big wet spot under the cab, checked the brake master cylinder level, empty. Had it towed (aaa) to my mechanic, paid $1,600.00 to have the steel brake lines and flex hoses replaced. If driving on the highway with the camper when this occurred, could have been a big accident or more. I have over 32 years of fire/ ems experience - this was bad situation ! I love my 02 silverado, I also have a 1969 camaro ss/rs 427 big block I installed stainless steel ones, so I am not against chevrolets, just the cheap supplier on a vital safety part - brake lines. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Dec 19, 2014 · Brakes · 149,540 miles · MI

Applied brake, pedal to the floor, no brakes. Had to run into ditch to avoid accident. Found brake line rusted through. Had to replace brake line. No warning light. Inspect whole brake line. All are severely rusted., found seepage near front from brake line. Brake reservoir was over 1/2 empty with no warning light.

Filed Sep 27, 2014 · Electrical, Engine · 149,337 miles · TX

Started to hear engine exhaust getting loud, started to look for exhaust leak and found that # 8 and #7 piston leaking at exhaust manifold due to broken bolts and then engine error code o2 sensor bank 1 will not turn off, can not get truck to pass inspection have found out others truck owners have same problem.

Filed May 27, 2014 · Brakes · 110,000 miles · PA

Corroded brakeline pumped out fluid and lost brakes.

Filed Mar 28, 2014 · Brakes · 140,000 miles · MO

Tl* the contact owns a 2002 chevrolet silverado1500 hd. The contact stated that while driving 5 MPH, the ABS engaged independently and prevented the contact from stopping the vehicle. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure and refused to provide any assistance since the vehicle was not included in the federal safety agency campaign number: 05v379000 (service brakes, hydraulic). The vehicle was not repaired. The failure mileage was 140,000 and the current mileage was 145,000. Updated 08/19/14

Filed Jan 25, 2014 · Driver assistance, Engine · 121,138 miles · OH

At approximately 50 MPH coolant loss from a cracked cylinder head sent a signal to the ECM to shut down the engine which caused the loss of power steering and control. Weather conditions were snow and wind and I was following two dry tracks in the road, upon loss of power the truck drifted onto an area of road covered in snow which nearly carried me off into a ditch. On a dry day if this had occurred inertia would have taken me on to a soft shoulder so in this instance the cold weather and snow actually helped the truck from drifting too far off the road. Once disabled along side the road the weather began to deteriorate to near white out conditions, thankfully another driver pulled up behind me about 50 yards back and used his flashers to warn on coming drivers. After the truck cooled a bit it re-started and I took for service. A mechanic noticed a cracked cylinder head as the culprit. I have come to learn this is a common problem with these vehicles. My wife will occasionally drive this truck and it could have been a different situation if she could not have muscled the unassisted steering to the side of the road. It is my belief that any condition that will shut down an engine under full power should be the responsibility of the manufacturer to fix.

Filed Dec 4, 2013 · Brakes · 113,563 miles · MT

My vehicle was in 4 wheel drive as I was leaving a parking lot and entering a highway. The vehicle was only traveling about 5 MPH. I applied the brake but the vehicle did not stop. I then pressed the brake pedal with both feet and there was a noise and then the ABS brake system started to stop the vehicle. I was just able to stop before rolling out onto a very busy highway. I took the pick-up to the chevy dealership and had it checked out. After several people drove it, it was determined there are no problems. I have owned this pick-up since the fall of 2001 purchasing it new. This pick-up may have a problem with the ABS brakes. I have driven all 113,563 miles in this truck and I know the vehicle. There is definitely something wrong with the braking system.