2016 Chevrolet Silverado 1500 engine problems

Filed Aug 28, 2026 · Engine, Transmission · CA

I had noticed that my a/c was not cooling due to refrigerant loss. went to dealer and was told that I needed a new condenser and that my original was out of warranty & no recall was in effect. I was charged $1600.00 after the replacement was installed. I asked to see my original condenser & was directed behind the shop & low & behold there was a pile of 30 condensers exactly identical to mine

Filed May 1, 2026 · Engine · CA

The AFM code p3400 was activated on the truck and the lifters went bad and caused damage to the cam shift. Lifter failure which caused fuel to shoot down exhaust and burned out the catalytic converters. Dealership wants 10k to fix not including the catalytic converters.

Filed Mar 18, 2026 · Engine · IL

The truck engine light came on and was not able to be driven very far without stalling. Took it for repair and 2 valve lifters were bad. We had to pay for replacement ourselves. This happened at 41,786 miles. This happened again at 46,000 miles because of faulty GM parts and they needed to be replaced again. The parts were under warranty so there was no charge. This happened again at 59,000 miles and now both side lifters are bad and mechanic suggested engine replacement since he is sure this will happen again. Now it’s costing us 15,300 to repair it and GM/Chevrolet is not helping or do they care! First incident was in April 2023, second in November 2023 and now in December 2025.

Filed Mar 15, 2026 · Acceleration, Engine · CA

I was driving south on interstate 15 freeway I was on the 3 lane in the middle of the road I was driving around 65-70 mph when my 1500 Silverado 2016 loose engine power and started to slow down I couldn’t get out fast enough and I almost got hit by three cars because I was driving so slow I pulled over emergency lines and the truck didn’t even start

Filed Mar 2, 2026 · Engine · KY

I am reporting a manufacturing defect involving General Motors’ Active Fuel Management (AFM) system. In October 2024, my 2016 Chevrolet Silverado 1500 LT, at 96,000 miles, experienced a lifter collapse which caused sufficient wear to the camshaft that the engine needed to be replaced, which was performed. The malfunction indicator lamp turned on and the truck was driven an additional 2 miles to a safe location and subsequently towed to the repair shop. Before then, there had been no indication that a lifter had collapsed or that there was damage to the engine sufficient to warrant a replacement. In November 2025, I experienced another lifter collapse (on the replaced engine). While the mechanic recommended an engine replacement, the warranty company only authorized a replacement of the affected side cylinder head and lifter, which was performed. In February 2026, I experienced another lifter collapse, and the truck is currently being evaluated by a repair shop. These failures have occurred without warning and aligns with thousands of consumer complaints regarding AFM-related oil consumption, lifter collapse, and engine damage in GM vehicles. This is a known design defect that GM has tried to address through Technical Service Bulletins and engine redesigns, yet many consumers continue to experience premature failures at low mileage. This defect presents a safety and reliability concern, including loss of power while driving and significant financial burden to vehicle owners. I respectfully request that the federal safety agency investigate this ongoing defect.

Filed Feb 6, 2026 · Engine · VA

I am reporting a manufacturing defect involving General Motors’ Active Fuel Management (AFM) system that caused catastrophic engine failure in my 2016 Chevrolet Silverado (VIN: [XXX] ). At approximately 78,000 miles, my vehicle experienced piston and lifter failure requiring full engine replacement. This failure occurred without warning and aligns with thousands of consumer complaints regarding AFM-related oil consumption, lifter collapse, and engine damage in GM vehicles. This is a known design defect that GM has addressed through Technical Service Bulletins and engine redesigns, yet many consumers continue to experience premature failures at low mileage. This defect presents a safety and reliability concern, including loss of power while driving and significant financial burden to vehicle owners. I respectfully request that the federal safety agency investigate this ongoing defect. Sincerely, [XXX] [XXX] [XXX] [XXX] VIN: [XXX] 2016 Chevrolet Silverado INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 7, 2026 · Engine · TX

I am writing about my recent engine failure on my 2016 Chevy Silverado High Country. This is a 4x4 with the 6.2L motor. My engine has failed at only 66,790 miles due to the lifter issue that seems to be common with these motors. I noticed a loud ticking from my motor that was getting worse. I took it into A1 Automotive Georgetown, TX. They advised me to contact a dealership for Warranty repair or replacement as they noted it was coming from the valves. I contacted Don Hewlett Chevrolet; they advised me due to the date of the truck being made in 2016 it is no longer covered in warranty and the advisor said they do not see engines with lifter issues. I did standard service with an oil and transmission change using the recommended 0W-20W oil. The next day the ticking was very bad and turned into what I would describe as ‘jack hammer’ noises. Then I lost power while driving and the dashboard lights came on. I got towed back to A1 Auto; they drained the oil and noticed a lot of metal fragments and advised me that theck engine will need to be replaced. The engine was removed and we found the pushrod on the passenger side was sticking out to the side of the rocker arm presumably due to a lifter issue. I now have a new engine with the ‘delete kit’ to remove the 4-cylinder shutoff that has been linked to lifter failures. This has been a very unnecessary expense for something that shouldn’t happen. The motor only having 66,790 miles and I am the only owner, I have always taken very good care of it, and even use only premium gas. I have gotten all the oil changes on time and most of them have been done by the dealership at Don Hewlett. Date of ticking inspection and oil change, A1 Auto – 12/16/2025 miles 66,766 Date of failure 12/17/2025 miles 66,790 Charges: •Towing $235 •Engine replacement $14,064.90 oEngine $8,375 oLabor $3,750 oInjectors $1042 oOil, Tax, misc. $897

Filed Dec 9, 2025 · Brakes, Engine · 139,000 miles · NE

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that while starting the vehicle, there was a loud rattling sound coming from the engine compartment, with the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the vehicle jerked unexpectedly, with the check engine warning light illuminated. Additionally, the contact stated that while driving at an undisclosed speed, the brake pedal became inoperable. The contact reported that the brake pedal was depressed and traveled to the floorboard, and the ABS system vibrated following the brake pedal failure. No warning lights were illuminated for the brake failure. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 139,000.

Filed Oct 3, 2025 · Electrical, Engine · GA

We have replaced the engine twice and the transmission once spending 18,000 dollars on a truck that was 54,000 plus dollars that we bought in 2019 and we still owe over 5 grand on currently. Currently now were having a stablittrack malfunction weve been told by numerous mechanics how awful this year for yjis particular vehicle is because its the first year GM decided to put in a smart engine .we definitely regret ever buying this GM product 🙄we truly need help with the repairs for tnis truck ! Its stranded us numerous times even shutting off trying to go thru a red light !

Filed Aug 20, 2025 · Electrical, Engine · IN

Stability track came on left me stuck a On train tracks and middle of an entersection