2016 Chevrolet Silverado 1500: sudden loss of power

Filed Aug 12, 2026 · Steering · MO

For the past 2 years ive been having issues of losing power steering. Lots of parts and modules have been replaced out of pocket. Still not fixed. When it goes out it can be out for days to weeks and is extremely hard to steer. Its gone out or come back in during a turn which is very problematic and unsafe. I always get the same dash message, "service power steering drive with care". The dealership is aware and has seen the malfunctioning steering. So far the rack and pinion gear box has been replaced at $2700, then it was a terminal resistor that was replaced for $2,100, and several other trips in costing more money just to get the steering fixed but technicians have been unsuccessful so far despite their best efforts.

Filed Mar 2, 2026 · Engine · KY

I am reporting a manufacturing defect involving General Motors’ Active Fuel Management (AFM) system. In October 2024, my 2016 Chevrolet Silverado 1500 LT, at 96,000 miles, experienced a lifter collapse which caused sufficient wear to the camshaft that the engine needed to be replaced, which was performed. The malfunction indicator lamp turned on and the truck was driven an additional 2 miles to a safe location and subsequently towed to the repair shop. Before then, there had been no indication that a lifter had collapsed or that there was damage to the engine sufficient to warrant a replacement. In November 2025, I experienced another lifter collapse (on the replaced engine). While the mechanic recommended an engine replacement, the warranty company only authorized a replacement of the affected side cylinder head and lifter, which was performed. In February 2026, I experienced another lifter collapse, and the truck is currently being evaluated by a repair shop. These failures have occurred without warning and aligns with thousands of consumer complaints regarding AFM-related oil consumption, lifter collapse, and engine damage in GM vehicles. This is a known design defect that GM has tried to address through Technical Service Bulletins and engine redesigns, yet many consumers continue to experience premature failures at low mileage. This defect presents a safety and reliability concern, including loss of power while driving and significant financial burden to vehicle owners. I respectfully request that the federal safety agency investigate this ongoing defect.

Filed Feb 6, 2026 · Engine · VA

I am reporting a manufacturing defect involving General Motors’ Active Fuel Management (AFM) system that caused catastrophic engine failure in my 2016 Chevrolet Silverado (VIN: [XXX] ). At approximately 78,000 miles, my vehicle experienced piston and lifter failure requiring full engine replacement. This failure occurred without warning and aligns with thousands of consumer complaints regarding AFM-related oil consumption, lifter collapse, and engine damage in GM vehicles. This is a known design defect that GM has addressed through Technical Service Bulletins and engine redesigns, yet many consumers continue to experience premature failures at low mileage. This defect presents a safety and reliability concern, including loss of power while driving and significant financial burden to vehicle owners. I respectfully request that the federal safety agency investigate this ongoing defect. Sincerely, [XXX] [XXX] [XXX] [XXX] VIN: [XXX] 2016 Chevrolet Silverado INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 7, 2026 · Engine · TX

I am writing about my recent engine failure on my 2016 Chevy Silverado High Country. This is a 4x4 with the 6.2L motor. My engine has failed at only 66,790 miles due to the lifter issue that seems to be common with these motors. I noticed a loud ticking from my motor that was getting worse. I took it into A1 Automotive Georgetown, TX. They advised me to contact a dealership for Warranty repair or replacement as they noted it was coming from the valves. I contacted Don Hewlett Chevrolet; they advised me due to the date of the truck being made in 2016 it is no longer covered in warranty and the advisor said they do not see engines with lifter issues. I did standard service with an oil and transmission change using the recommended 0W-20W oil. The next day the ticking was very bad and turned into what I would describe as ‘jack hammer’ noises. Then I lost power while driving and the dashboard lights came on. I got towed back to A1 Auto; they drained the oil and noticed a lot of metal fragments and advised me that theck engine will need to be replaced. The engine was removed and we found the pushrod on the passenger side was sticking out to the side of the rocker arm presumably due to a lifter issue. I now have a new engine with the ‘delete kit’ to remove the 4-cylinder shutoff that has been linked to lifter failures. This has been a very unnecessary expense for something that shouldn’t happen. The motor only having 66,790 miles and I am the only owner, I have always taken very good care of it, and even use only premium gas. I have gotten all the oil changes on time and most of them have been done by the dealership at Don Hewlett. Date of ticking inspection and oil change, A1 Auto – 12/16/2025 miles 66,766 Date of failure 12/17/2025 miles 66,790 Charges: •Towing $235 •Engine replacement $14,064.90 oEngine $8,375 oLabor $3,750 oInjectors $1042 oOil, Tax, misc. $897

Filed Jul 28, 2025 · Brakes · GA

For the last month or so, occasionally when I am going anywhere around 30-60 and I press the brakes, the vehicle will lose power for a few seconds and Stabilitrak is activated. It has locked up the brakes twice in the last 2 weeks when I was parking and could have caused an accident and if it happens when I am driving, I worry that it will cause an accident. I did some research and saw that there is a recall on my year and model. The symptoms it describes are exactly what my truck is doing but when I put in my VIN, it does not show the recall on my truck.

Filed Jul 12, 2025 · Steering · KY

I own a 2016 Chevy Silverado 1500 with around 61,000 miles on it. I work from home at the moment so I do not put a lot of miles on the vehicle. I drove the vehicle last on July 5 2025 and it sat in our driveway until July 10 2025. I got into the truck and the dash read “service power steering drive with care” and the power steering would not work and it was very difficult to turn the wheel. I tried starting the truck again and the message still displayed and the loss of power steering became intermittent. The power steering would work briefly and then the steering would lock up become stiff again. I let the truck sit over night and came out the next day in the afternoon to see what it was doing. I started the truck and the message did not display I tried to drive it up and down the road to see if it would come back. I drove for about 5 minutes and parked it back in my driveway and the issue came right back. I’m afraid to drive it completely on any main roads for the fact it might come back while I’m driving and cause me to crash or worse.

Filed May 5, 2025 · Engine, Transmission · NC

2016 Chevrolet Silverado 1500 Z71 Crew Cab Transmission (6 speed automatic) 97,000 miles - At 70 mph in traffic, the transmission decided to stop working with no warning, stranded on highway 800 miles from home at 7:15 pm on Saturday, June 28, 2024. - Got it to a Chevy dealership, they had to replace the transmission. - 4 days and $7,100 later I had transportation again. - Do not have the blown transmission, dealership kept it. Engine (5.3L V8 EcoTec3) 103,000 miles - At 35 mph in traffic, the engine lost all power and had a very loud clunking sound. Had to have it towed. December 7, 2024 - Had to have it rebuilt, 3 lifters were broken along with other things. - 3 weeks and $5,600 later I had transportation again. - I have the box of parts that had to be replaced.

Filed Apr 26, 2025 · Transmission · VA

The transmission failed prematurely (just over 95,000 miles). Before i had it rebuilt, It was lurching forward as I was coming to a stop. It also had trouble switching gears (very rough) and a loss of power. I understand this transmission is part of a class action lawsuit. I wanted to make sure my experience was documented with the other cases. General Motors needs to correct this problem and reimburse owners for work already completed. I will dig up my transmission repair documentation and include it with this record. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 17, 2025 · Electrical, Lights · OK

Truck lost power and died while making a low speed right turn. Attempted to start vehicle but was unable to immediately after losing power, after trying again for about 30 seconds I was able to get it to start and pull it off the road. I lost control of the steering as the steering wheel locked up. When I turned it back on the truck required me to roll the driver window down and back up and radio stations went back to the default station, letting me know that the truck lost power. This typically happens at low speed, but I have had it lose power while driving on the highway at night and my headlights shut off, luckily it immediately came back on.

Filed May 6, 2024 · Steering · 82,000 miles · NJ

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated while driving 30 MPH, the vehicle made a beeping sound and then intermittently experienced a loss of power steering assist. The Power Steering message was displayed. The vehicle was taken to the dealer, where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact related the failure to the federal safety agency Campaign Number: 18V586000 (Steering); however, the VIN was not included in the recall. The failure mileage was approximately 82,000.

Filed May 24, 2023 · Acceleration, Electrical · OK

Son was driving truck in a straight line when it lost all power. Although we have experienced issues during turns that I have noted before here, this is the first incident while driving in a straight line.

Filed May 2, 2023 · Steering · NY

Driving down our road and the truck instantly lost power steering. Got home turned off the truck. Turned it backon and it worked. Each time I turn the vehicle off and turn it on the power steering works for a very brief time and then stops.