2005 Chevrolet Silverado 2500 brakes problems

Filed Feb 27, 2022 · Brakes, Fuel system · IN · crash

I got into an accident with my 2005 chevy silverado by rear ending some one at a stop sign. I pulled up behind the vehicle and stopped to wait for them to go the it was my turn she didn't look well enough and had to hit her breaks again and so then did I but my truck did not stop in time because the breaking system delayed

Filed Jan 25, 2021 · Brakes, Fuel system · 200,000 miles · IN · crash

October 29,2020 I was traveling down a highway when I noticed traffic was stopped and when I went to apply my brakes the pedal went all the way to the floor and I had nothing not even a light came on to notify my of an issue. I also tried to apply the emergency brake and it snapped and at that point I had to leave the road way to avoid hitting any cars or anyone, and in doing so iwent towards a ditch and ramped a driveway. We have ;looked into the recalls and its the same parts we are having trouble with on this truck and why it caused me to wreck. Hydro boost system, and the emergency brake system. The codes that I pulled from the federal safety agency. These all are whats has happened with my vehicle. 04v376000 05v161000 05v043000 if you need any additional info please let me know I have a video I tried to send from the homeowners security camera of the truck ramping his drive but it was too large to upload and I have to get another copy of the police report if you would like that.

Filed Apr 16, 2018 · Brakes · 133,606 miles · OH

My 2005 chevrolet silverado 2500 hd with 133,606 miles experienced total brake failure april 13,2018 at 9pm eastern standard time. Incident happened in greenville, ohio on gardenwood dr. Heading west. Stopped at a 4 way stop with no indication of any kind of mushy brakes etc. Took off from stop and accelerated to 25mph the posted speed limit. Went approximately 400 feet, when a rabbit darted in front of truck. Hit the brakes with moderate firm pressure, but not extreme and brake pedal went to the floor. Had zero braking force. Dumb founded, I immediately tried to find the parking brake pedal with my left boot in the dark. After 40 yards of coasting and applying the parking break was able to stop the truck. Thank god for the rabbit, cause the road dead ends into state route 118. The brake line failed under drivers side door near frame and runs to the master cylinder assembly. After removing lines, the lines that looked good were brittle in spots that are impossible to visually inspect without removing. Two other lines that didn't fail could be easily snapped in two with almost zero force. Entire brake system other than the steel lines had been replaced in the past 2yrs. Power washed under the truck at a minimum of every 6 months. Sprayed wd 40 on brake lines every 6 months past 4yrs, due to mechanic informing me that the lines could go bad along frame and that they are difficult to replace. Thought I had done a good job at preventing such an incident. Have extensive mechanical skills from experience, hence I'm replacing all the brake lines myself. Was a mac tool distributor in the past and raised on a farm. Lucky I had replaced the rear disks and parking brake shoes, because they are less than adequate to stop a full sized truck imo. I'm pissed off this happened. The lines need replaced on all these vehicles, before they fail and hurt or kill innocent people.

Filed Mar 29, 2018 · Brakes · NJ

2005 chevrolet silverado 2500. Consumer writes in regards to brake failure, lines had to replaced due to rust and corrosion. *ld

Filed Apr 15, 2017 · Brakes, Lights · 100,000 miles · MD

The entire instrument panel flickers and goes dark randomly I cant see my speed or what gear I am in. On my way to work and attempted to stop at a stop sign break pedal went to the floor. I had zero brakes.upon inspection I found a break line had corroded through and ruptured. The vehicle only has 100 thousand miles. It seems to be a common issue with this model vehicle. This is very dangerous

Filed Nov 30, 2016 · Brakes · 125,000 miles · MI

Tl* the contact owns a 2005 chevrolet silverado 2500. The contact stated that the brake lines were rusted out. The dealer stated that new brake lines needed to be installed on the vehicle. The vehicle was repaired in july of 2014. The manufacturer was notified. The failure mileage was 125,000.

Filed Aug 20, 2016 · Brakes · 132,429 miles · VA · crash

Had to make a sudden stop when a pedestrian walked out in front of the car in front of me. My brake pedal went to the floor and I rear ended the car in front of me. Upon on investigation it was found that one of the front brake lines ruptured due to the high pressure from the emergency stop and the rusted brake line. I have owned this truck since new and there have been no recalls or communications that the brake lines will prematurely corrode and fail. Brake lines are not a normal serviceable part. Apparently, this is typical of this year vehicle from gm. Please recall or notify the public because this is a time bomb waiting to kill people. Brakes are more important than your emphasis on air bags. The brake lines didn't last as long as the engine, transmission, ball joints, shocks, etc which are all serviceable items and expected to be replaced. Please step up to your responsibilities and get the vehicle owners notified and get the vehicles off the road until the brake lines are replaced. My 1941 chevrolet pickup has original brake lines in better condition than my 2005 chevrolet pickup. Please recall these vehicles.

Filed Aug 11, 2016 · Brakes · 118,000 miles · OH

Today at approximately 25mph I came to residential stop sign and the brakes went to the floor without and warning. The vehicle went into the cross road without stopping. I was forced to use emergency brake to get vehicle to fully stop. Upon inspection there was alot of brakes fluid in two spots. From drivers side frame rail and above fuel tank. When you look under the frame, the parts all look very clean and new looking. The only exception was that all the brake lines look heavily rusted. I was lucky it was not at high speeds, but from what mechanics tell me, this is getting extremely common. I believe at least owners should be notified to have them inspected. The dealer tells me all the lines need replaced at approximately $1300

Filed Jun 20, 2016 · Brakes, Fuel system · 128,200 miles · VA

Brake lines rusted out prematurely and burst, causing loss of braking ability. Had to replace every brake line on the entire truck, for they were all extremely rusty. 2 months later my fuel line also sprung a leak due to excessive rust, causing fuel to spill, check engine lights, and hard starting. Both of these issues present major safety concerns, and unfortunately are extremely common with these trucks.

Filed Mar 14, 2016 · Brakes · 44,500 miles · TN

My truck has been babied, only having less than 45,000 miles. Has never been off blacktop, and keep in garage. While towing my boat my breaks went out, come to find out my break line was rusted into and my master cylinder was also rusted where the break lines connect. I was told by chev dealer that all four break lines and master cylinder would have to be replaced. $1,400.00, this seems impossible for a truck with less than 45,000 miles that was not driven in the rain for the first two years and never been driven on salt treated road. I have another 4 wheel drive truck that I drive in bad weather. This is the only new vehicle I have ever purchased. Very disappointed in break service and chevy wellness to admit there I is a defect with the break system.