Chevrolet Silverado 2500 power steering loss problems

Filed Oct 22, 2026 · Steering · 30,000 miles · NC

The contact owns a 2025 Chevrolet Silverado 2500. The contact stated that on several occasions, the electronic power steering failed to function as intended intermittently, and the steering wheel became very difficult to turn. The vehicle was taken to a dealer to be diagnosed, and the contact was advised that the battery needed to be replaced and a software update performed. The battery was replaced, and the software update was performed; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 30,000.

Filed Sep 20, 2026 · Steering, Suspension · WV

Description of Safety Defect: I purchased this 2018 Chevrolet Silverado 2500HD from Carvana. Within 14 days of vehicle delivery, an authorized, in-network warranty repair facility (Monro) diagnosed a critical safety defect in the steering linkage, identifying failed outer tie rod ends and a failed pitman arm. Carvana’s warranty administrator, SilverRock (Claim C102648992), acknowledged the structural steering failure by approving the pitman arm and idler arm replacement but explicitly denied the required tie rod ends, claiming "no failure." The vehicle has since been released back to me with the failed tie rod ends still installed. On this heavy-duty truck, the steering linkage has now deteriorated to a catastrophic failure point. With the truck parked on the ground, there is severe, excessive manual play allowing the front wheel to be physically shaken left-to-right by hand. The vehicle cannot be aligned, is structurally compromised, and is completely unsafe to operate on public roads due to the imminent risk of a total loss of steering control. Carvana and SilverRock delivered an unsafe vehicle that failed its structural inspection points, and subsequently refused to complete the safety-critical repair required under their mandatory 100-day limited warranty window, forcing a dangerous, heavy-duty vehicle back onto public roads.

Filed Jun 13, 2025 · Electrical, Engine · 42,000 miles · MI

The contact owns a 2025 Chevrolet Silverado 2500. The contact stated while her husband was hauling a trailer and driving 55 MPH in the snow, the vehicle lost power steering functionality. In addition, the contact stated the vehicle failed to accelerate as intended while depressing the accelerator pedal before slamming into gear. The RPM fluctuated up to 6,500 RPM. The contact stated that the check engine warning light was illuminated. The contact's husband was able to coast to the side of the road. The vehicle was turned off but failed to restart. The contact's husband stepped out of the vehicle, and the vehicle restarted automatically. The vehicle was towed to a dealer, where it was diagnosed that the wiring was for a diesel vehicle; however, the contact's vehicle was gasoline operated. The contact was informed that the wiring harness control arm had rubbed against the control arm, causing the electrical system to short-circuit. The vehicle was repaired. The failure had progressively gotten worse. Most recently, the contact stated that the vehicle vibrated abnormally while driving. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that a seal was placed on the transmission. The manufacturer was made aware of the failure but denied assistance. The failure mileage was approximately 42,000.

Filed Oct 14, 2024 · Fuel system, Transmission · DE

While hauling a trailer I received a warning tone and looked down to read the message, "reduced engine power", and the service engine light appeared all at the same time. The engine shutoff at the same time I received the warnings and didn't allow me to safely pull off the road.. I lost power steering, power braking, and controlling the vehicle and trailer while coasting to the sholder was difficult. Fortunately it was early in the morning and I was only traveling 35 mph on a straight road, and no other vehicles were on the road. If I was on an interstate traveling 55+ mph or on a curvy road it would have caused an accident or worse. I was very fortunate. This was the first time I experienced this problem and hadn't received prior warning messages or lights. The truck would not restart and the truck and trailer were towed to the dealership. The diagnosis was a failed "Fuel Pump Control Module." After waiting several weeks the replacement Fuel Pump Control Module did solved the problem. I kept the failed Fuel Pump Control Module and is available for inspection. Please investigate thoroughly! I was extremely fortunate the part failed when it did and I was able to walk away unharmed.

Filed Oct 9, 2024 · Brakes, Steering · CA

Chevy Duramax trucks, 2011-2016 use a CP4 fuel pump that will eventually fail. The engine shuts off and there is a loss of steering and brakes. This is a major safety issue. I called Chevy GM 1800 222 1020 and was told, " we are aware of the problem, have no remedy, no recall has been issued yet, call back in a month". My daughter has a 2015 that failed when she was hauling expensive horses, the dealer put the same type defective pump back in the truck. Every diesel repair shop, dealer, and GM is aware of this defect. There is a class action law suit C/O JND Seattle WA. 1 866 848 0815 that may reimburse owners that have had a failure, assuming they are still alive. GM needs to recall, and replace these CP4 pumps with a CP3 or whatever they did to correct the issue in 2017 and later engines, prior to failure. Let ne know if I can provide any more information or assistance.

Filed Sep 25, 2024 · Fuel system · GA

Engine shut off while driving on the freeway (70mph), lost steering and braking capacity. lucky to make it to shoulder, The failure is the Fuel pump control module, second time(first failure at 48k miles, second at 98k miles) this has failed (part # 13558813). once this fails part is impossible to find. repair technicians at dealer says this is a very common failure. To my knowledge part has not been inspected. Dealer is not an option for repair due to the length of time they will keep vehicle (in key west was going to ve 3 months before they could look at it,) this failure the local dealer in Athens Ga, did not have a diesel mechanic to repair (not sure why this needed a diesel mechanic), Warning lights/message is : Reduced engine power....but did not say why reduced, engine just slowed and shut down in very heavy traffic.

Filed Sep 24, 2024 · Electrical, Steering · WI

- Electronic power steering assist malfunctioning. Available for inspection - Vehicle jerks steering to the left or right at highway speeds, causing near miss accidents. - Dealer performed alignment and did not know how to fix. They were able to replicate the issue. - No other inspection - "Service Power Steering Drive With Care" message intermittently displays and almost immediately goes away. No check engine light or other warning lights.

Filed Jun 15, 2024 · OH

On [XXX], I was driving our 2017 Silverado 2500HD LT 6.6, with my family in Ohio when the trailer brake controller error started flashing on the dash and would not shut off, go silent nor correct itself. It almost caused an accident initially because it was distracting me by making me look down to READ the message. Then we were almost in a dozen accidents as we were traveling too slow for conditions, unable to get off the highway safely, and issues with steering and braking. In 10 minutes, the error sounded 50+ times. We were towing a 36’ 5th wheel trailer suddenly STABILITRAC also kicked on, REDUCED POWER (another message to look down and read), the engine started running so rough (another issues to look down at the gauges) that I thought the engine had blown. We were not in a safe place to pull over and power was cut dropping our speed from 70 to 45 in a 70 zone. Just after going up the hill, we had to continue down other side which we discovered that the trailer brakes were NOT operational. As we were burning our truck brakes going down the other side. The only reset is to shut off the key (which would lock the steering wheel, lose power steering and power brakes while driving). When STABILITRAC appears vital drivers data is BLOCKED. We removed the trailer brake fuse and the trailer battery charger fuse, but the TRAILER BRAKE CONTROLLER messages continued. Even with the trailer disconnected the the messages continued. The trailer brake wire under the truck had exposed wires. Did the exposed wire cause other systems to malfunction? 1.Are the defective wiring harness(es) causing other systems to fail too, and/or can cause electrical fires? 2.Defective trailer braking unit needs to give one warning and STOP. This defect poses a serious issue for anyone towing (or not). 3.STABILITRAC is going to KILL someone because I believe it already has killed. If STABILITRAC throughs the right code it WILL shut down the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

Filed Mar 6, 2023 · Engine, Fuel system · MS

Fuel pump failure while driving highway speed 70mph pulling a trailer. Engine light came on and engine went to limp mode for a few seconds then completely shut down without warning while still going at least 60. Lost power steering and power brakes. Service center confirmed the code for "low fuel rail pressure" and did the repair. I have retained the CP4 pump for analysis. I was very lucky to not crash my truck.

Filed Mar 24, 2022 · Steering · 42,000 miles · NY

The contact owns a 2016 Chevrolet Silverado 2500. The contact stated while driving 55 MPH, the vehicle lost power steering functionality. There were no warning lights illuminated on the instrument panel. The contact drove the vehicle safely home. The vehicle had not been repaired or diagnosed. The manufacturer was notified of the failure; however, no assistance was provided. The approximate failure mileage was 42,000. The VIN was not available.