The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the transmission was slipping. Additionally, the contact stated that while driving 60-70 MPH, the vehicle stalled. No warning light was illuminated. The contact pulled over to the side of the road. Upon inspection, the contact became aware of a coolant leak underneath the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the turbo coolant inlet had fractured. The part was replaced. Additionally, the dealer determined that the transmission was in working order upon inspection; however, the failure persisted. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 83,000.
Chevrolet Silverado 2500 stalling problems
151 of the 4,101 owner complaints about the Chevrolet Silverado 2500 describe engine stalls while driving, most of them for the 2001 model year.
- owner complaints
- 151
- worst model year
- 2001
- typical repair cost reported
- $2,500
- typical mileage
- 77,900
By model year
Often reported together
Fuel pump 20Loss of power 15Power steering loss 13Check engine light 13Won't start 8Engine failure 5Misfire 3Jerking 3
Trouble codes mentioned
P0335 2
What owners say
Due to the Fuel Pump Power Control Module (Part number 13554821) failure, my vehicle stalled in the middle of a turn while pulling a 10,000 pound RV. This caused me to lose both power steering and braking capabilities. From what I gather, this part is part of a "phased" initiative recall (see N252516900 Fuel Pump Power Control Module). This part was seemingly installed in all or most of GM SUVs and Trucks since 2021. Unfortunately, only some 2021-2023 models are under recall due to the "phased" nature of this recall. Meanwhile, all Heavy Duty trucks are driving around on our roadways, highways, and interstates, just like I was, towing heavy machinery, equipment, and RVs because both you and GM are dragging your feet on demanding these flawed modules be removed from these vehicles. In summation, virtually every GM SUV and truck on the road produced since 2021 is a ticking time bomb that could stall at any moment and disable both power steering and braking capability. If thats not bad enough, concerned owners, such as myself, are stonewalled with the words "there is no active recall on your vehicle " both by GM and your very website. The "phased" nature of this recall is unacceptable and is putting lives at risk. Had I been traveling at highway speeds when this failure occurred, while towing a heavy load, with braking traffic in front of me or a sharp turn, I would not have been able to stop or turn. This is an urgent matter and should be addressed accordingly, not in a "phased" manner.
2 low pressure fuel pumps have failed. truck stalls in traffic. currently in show with extremely large bill for repair.
Tranmission isn't running right and gas and brakes are not working properly. Also fuel pump or relay gets hot shuts off while driving.
The contact owns a 2015 Chevrolet Silverado 2500. The contact stated while driving approximately 65 MPH, the vehicle stalled. The contact stated there was no warning illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the high-pressure diesel fuel pump had failed, and the entire fuel system needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 190,000.
The contact owned a 2024 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the vehicle stalled with several unknown warning lights illuminated. The vehicle was towed to a dealer, where it was diagnosed that the cam lifters and three cylinders had collapsed, and the engine needed to be repaired. The vehicle was repaired; however, the failure persisted. The vehicle was towed back to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 6,000.
The fuel tank vent got plugged, which collapsed the fuel tank, damaged the fuel pump causing the truck to stall at highway speeds on the highway in traffic. GM certified mechanic at the dealership confirmed and mentioned that he had already repaired 4 trucks with this issue in Rochester, MN. Prior to the failure, the fuel gauge was inaccurate and a few days later the check engine came in at which time we scheduled an appointment with the mechanic.
Vehicle stalled then would not start
The contact owns a 2021 Chevrolet Silverado 2500. The contact stated that while driving 70-75 MPH, there was an abnormally loud sound coming from the vehicle. The vehicle independently decelerated to approximately 50 MPH then down to 40 MPH before being able to pull off on a nearby exit. The contact stated that the vehicle then stalled and lost motive power. The vehicle was towed to the dealer who diagnosed that the fuel pump module had failed and needed to be replaced. The vehicle had not been repaired due to the part being on backorder. The manufacturer was made aware of the failure. The failure mileage was 83,000.
Engine shut off while driving on the freeway (70mph), lost steering and braking capacity. lucky to make it to shoulder, The failure is the Fuel pump control module, second time(first failure at 48k miles, second at 98k miles) this has failed (part # 13558813). once this fails part is impossible to find. repair technicians at dealer says this is a very common failure. To my knowledge part has not been inspected. Dealer is not an option for repair due to the length of time they will keep vehicle (in key west was going to ve 3 months before they could look at it,) this failure the local dealer in Athens Ga, did not have a diesel mechanic to repair (not sure why this needed a diesel mechanic), Warning lights/message is : Reduced engine power....but did not say why reduced, engine just slowed and shut down in very heavy traffic.
Related recalls
Engine
- What is wrong
- General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.
- Risk
- A short-circuit may damage the engine components and increase the risk of fire.
- Remedy
- GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1‑586‑596‑1733. GM's number for this recall is N182206310.
Recall number 19V328000 · Recall details
Questions about the Chevrolet Silverado 2500 stalling
Which Chevrolet Silverado 2500 years have engine stalls while driving problems?
The model years with the most reports are 2001 (61 complaints), 2002 (27 complaints) and 2003 (9 complaints).
How much does it cost to fix engine stalls while driving on the Chevrolet Silverado 2500?
Owners who mentioned a price put the repair at about $2,500 (median of 9 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Chevrolet Silverado 2500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history