2002 Chevrolet Silverado suspension problems

Filed Sep 24, 2015 · Brakes, Suspension · 90,000 miles · ME

Tl* the contact owns a 2002 chevrolet silverado. While driving at a low speed, the contact applied the brake pedal and the ABS kicked in; however, there was a loss of brake function. The stopping distance of the vehicle was dramatically reduced. The vehicle was taken to a mechanic who stated that there was a wheel bearing sensor failure. The entire wheel bearing with the sensor was replaced, but the failure recurred multiple times. The contact researched and found the federal safety agency campaign number: 05v379000. The manufacturer was notified of the issue. The approximate failure mileage was 90,000.

Filed Dec 13, 2014 · Suspension · 105,731 miles · IL

Traveling on a gravel road @ about 45 MPH. Other than being gravel, the road is very smooth. Heard a loud bang and felt it in the vehicle and in the steering wheel. Found driver's side rear leaf spring rear mounting shackle had broken allowing leaf spring to slam against the bottom of the bed, putting an upward dent in it. Repair mechanic commented the vehicle is rusted far more than normal. Rails under doors have large 3 inch holes. Rear bumper is rusted through, the rear tailgate has holes in it. Vehicle only driven to work (2 miles which are gravel) and has very low miles. No one else except silverado owners are experiencing this issue. Very likely inferior design or materials or both.

Filed Aug 1, 2012 · Brakes, Suspension · 146,000 miles · CT

Slowing down to park, pushed brakes, pedal went to the floor. Barely stopped before pinning someone between my vehicle and another truck. Rear brake line burst below driver seat, brake fluid puddle under truck. Upon inspection, all 4 brake lines running along the frame totally rusted, about to burst. Need to replace all lines on whole truck. On the flatbed towtruck, noticed the driver rear leaf spring where it wraps around the bushing was missing the top half. This is where force is transmitted from axle to frame (back is a hanger / pivot). The whole rear axle could have torn off. Noticed where it had cracked and had rusted 1/2 through before falling off, likely sometime recently.

Filed Mar 21, 2006 · Suspension · 68,000 miles · NC

Dt*: the contact stated there is a popping noise in the steering and the steering is loose. The vehicle was taken to the dealership where they determined the intermediate steering shaft needed to be replaced. The manufacturer has not been contacted. There was a popping noise when vehicle was moving. Also felt excessive play in steering wheel. Dealer determined there was no problem.

Filed Feb 1, 2006 · Body, Brakes · CO

2002 silverado parking brake does not hold, rear axle seals were leaking. *ts ***no answer required*** the consumer received a recall regarding the parking brake after several attempts of trying to get it repaired. The ABS light illuminated, the dealer replaced the speed sensor. The cd player failed. The complained about a rattle when going over bumps. The dealer tightened the shocks. The tailgate latch was replaced.

Filed Sep 7, 2005 · Brakes, Suspension · 40,200 miles · MI

The ABS comes on at low speed when it shouldn't, resulting in extending stopping distance. Dealer miss diagnosed the problem as the left front hub. Replacing both front hubs and wheel speed sensors which fixed the problem.

Filed Aug 29, 2005 · Suspension · 45,034 miles · KY

Dt: a noise was coming from the driver's side front wheel area. The consumer noticed it when turning the vehicle at slow speeds. When the consumer took it to the dealer they did not hear the noise, and did nothing to solve the problem the consumer was unsure of the exact problem. It first started occurring on 7-14-05.

Filed Aug 25, 2005 · Suspension · NY · crash

Dt: the contact owns a 2002 chevrolet silverado. Contact's vehicle hit a wall at a department store last night because she could not stop the vehicle. The contact stated she had no previous problems with the vehicle. Could not press down on the brake pedal. There were no warning lights or warning signs to let the consumer know there was a problem within the brakes. The service dealer replaced r&r left front hub bearing.

Filed Jun 28, 2005 · Brakes, Suspension · 119,000 miles · MI

Dt: at low speeds the ABS kicks in and the vehicle is hard to stop. Usually occurs about 5-10 MPH. This problem occurs under all weather and driving conditions. It doesn't matter if the vehicle is turning or going straight. The vehicle has 4 wheel antilock. The owner has not called the dealer yet. Vehicle is regularly serviced but has not been tested yet. No warning light illuminated. A vibration could be felt and heard in the brake pedal.

Filed Jun 23, 2005 · Suspension, Visibility · 63,106 miles · NY

Defective electric window on drivers side. Window will not go up.