2021 Chevrolet Suburban transmission problems

Filed Oct 30, 2026 · Transmission · LA

Shuddering and vibration between 25-40mph during low acceleration. Seems to be getting worse. Have an appointment with a dealership to do a diagnostic and can upload that information later. Service advisor suggested that it is an extremely common problem in my vehicle and very expensive to fix.

Filed Oct 23, 2026 · Engine, Transmission · CA

I was driving 60 miles per hour on the 101 highway around 8:30AM and a couple error messages suddenly appeared on my dash - one regarding traction control and the other regarding ESC. My engine light continuously flashed. I took the car into the dealership and they requested 3K to take apart the engine to figure out the issue. They now state that the number four cylinder lifters and the camshaft are pitted and thus the cylinder walls of the engine are scratched and thus the cylinder block can not be reused and needs to be replaced. They are requesting an additional 17,000 to replace the engine entirely. There was a recall on this vehicle for March 2021-2024 vehicles. Mine is just outside that recall being manufactured in January or Feburary 2021. Clearly, my issue is suffering the same problem from this recall.

Filed Oct 23, 2026 · Transmission · CA

Car misfired and had ticking noise. Car began to consistently shake when I was on the highway. Known issue 2021 Chevrolet Suburban. V8 engine. Dynamic Fuel Management Lifter failure. Driving on the 101 highway and an error message for traction was relayed on dash, followed by ESC error, followed by blinking engine light. It happened in the span of seconds with no prior alerts. Dealership had to take apart the engine for 3,300 to find the reason and repair is an addition 4,000.

Filed Oct 6, 2026 · Engine, Transmission · MI

Cylinders were misfiring and lifters had to be completely replaced along with pushrod and camshaft. This cost me $7018.64 to fix out of my own pocket. Received the vehicle back, and there was a slight ticking sound that was new to me. Scheduled to bring the vehicle back in and 2 days before I was scheduled to go in and approximately 1000 miles later, the engine completely shut down while I was driving on the road. As I did not know what was going on and I had my newborn baby in the car, I was panicking as I was trying to figure out how to pull over to get out of traffic. Turns out there are now metal shavings in my engine according to the GM certified dealership that I had the work on the lifters done at in the first place. They are now quoting me an additional $13,000+ dollars to completely replace the engine with one that is not even brand new. Highly disappointed and concerned for my family's and I's safety while driving this vehicle. Also, not happy that I apparently need to spend $20K on a vehicle that I have only brought to certified GM dealerships for work on and I have kept in excellent condition.

Filed Sep 2, 2026 · Transmission · SC

The transmission shutter and hesitates while downshifting.

Filed Jul 15, 2026 · Transmission · ID

What component or system failed or malfunctioned, and is it available for inspection upon request? (On our 2021 gasoline suburgan, the rear wheels locked up at free-way speeds, which nearly caused a possibly fatal accident. The lock released but it appears the strain caused rear differential gear teeth to break and the rear differential now needs to be replaced for the vehicle to operate properly.) How was your safety or the safety of others put at risk? (The sudden rear wheel lockup at freeway speeds resulted in temporary loss of control of the vehicle and significant surprise to the driver, who, after swerving into the adjacent lane was able to gain control of the steering and stop the vehicle. Had there been another vehicle in the other lane the MVA could have been fatal for 9 people in the suburban and any other vehicle involved.) Has the problem been reproduced or confirmed by a dealer or independent service center? (The rear differential damage was confirmed by a dealer.) Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? (No.) Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? (No warning or messages. This has happened 3 times over 3 years, always on extended trips 9-12 hours in duration. The first two times nearly caused an accident but no differential damage. This third time, the differential was immediately damaged due to the incident. We have since learned that this is an issue with 2022 suburbans, for which a recall has been issued. A recall has also been issued for 2021 DIESEL suburbans. However, no recall has been issued to gasoline 2021 suburbans, but apparently needs to be.)

Filed Jul 13, 2026 · Transmission · TX

COMPONENT: The 10-speed automatic transmission failed on 6/29/26, locking the vehicle completely in neutral. The neutral override could not be disengaged even by dealership technicians. Vehicle is currently at [XXX] Chevrolet, [XXX] and is available for inspection. SAFETY RISK: I have 3 young children who are regular passengers. The failure occurred without warning. Had it happened at highway speed in oncoming traffic, I would have had no ability to move the car — creating a direct risk of a serious or fatal collision. CONFIRMED BY DEALER: Yes. Don Hewlett Chevrolet received the vehicle on 6/30/26 and confirmed the failure is directly related to two active federal recalls: the federal safety agency #24V‑797 (10-speed transmission valve body failure/wheel lockup) and the federal safety agency #22V‑036 (driveshaft assembly/loss of propulsion). Vehicle has been unrepaired for 13 days with no timeline provided. OTHER INSPECTIONS: Vehicle has been in possession of Don Hewlett Chevrolet since 6/30/26. No manufacturer representative, police, or insurance inspection has occurred. WARNING SIGNS: None. No warning lamps, messages, or symptoms appeared before the failure. The power train locked suddenly and completely without any prior indication on 6/29/26. Despite the dealer confirming this is recall-related, they have indicated I may owe partial repair costs. Under 49 U.S.C. § 30120, GM must remedy recalls at no charge regardless of mileage or warranty. I am requesting the federal safety agency investigate both the failure and GM's attempt to charge the owner for federally mandated recall repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 12, 2026 · Transmission · IL

2021 Chevy Suburban started to have harsh shifting particularly on acceleration and shuddering at higher rates of speed (feeling like you are driving over a rumble strip). I took it to the dealer, and they confirmed the torque converter was in the process of failing. It's currently in the shop getting a new torque converter. No warning messages/lights had yet appeared. Technician at dealer stated that this was a common failure with this model.

Filed Jun 4, 2026 · Transmission · TX

The failure involved the transmission valve body control valve within the automatic transmission system of the 2021 Chevrolet Suburban, a critical component responsible for regulating hydraulic pressure and controlling gear shifting. The malfunction caused erratic and unreliable shifting behavior, including hesitation, harsh engagement, and loss of proper acceleration; the failed component is in the custody of Northside Chevy in San Antonio, TX. This issue created a significant safety risk, as the unpredictable transmission response impacted the driver’s ability to accelerate when necessary (merging onto high traffic roads) and increased the likelihood of dangerous situations like rear-end collisions or loss of control. The problem was confirmed by an authorized Chevrolet dealer, where diagnostic testing identified faults in the transmission control system and verified the failure through performance testing and fault codes. The vehicle has been inspected by the dealership service department, though it has not been directly examined by the manufacturer, law enforcement, or insurance representatives; however, documentation of the diagnosis is being withheld by the dealership. Prior to the failure there were no warning signs present. Only after failure did the check engine light illuminate, transmission-related warning messages, and noticeable symptoms such as hard shifting, delayed engagement, and slipping, which appeared shortly before the complete failure and significantly worsened over the three-mile drive to the dealership.

Filed May 29, 2026 · Transmission · WA

transmission failed high speed jerking shifting ruined a set of tires yes has been confirmed by dealer but our vin is not covered under the recall no yes error codes appeared before we took the vehicle in for service 6-5-2025 we have had the vehicle in to 2 separate dealerships a total of 4 times for repair now that powertrain warranty is expired they are calling for a transmission replacement