2022 Chevrolet Suburban: engine stalls while driving

Filed Sep 1, 2026 · Engine · 53,000 miles · WA

The contact owns a 2022 Chevrolet Suburban. The contact received an unknown recall. The contact stated that the vehicle was taken to the dealer, and while parked at the dealer, it was determined that there were metal shavings in the oil and that the engine needed to be replaced. The vehicle was repaired, but a failure occurred 4,000 miles, two months later. The contact stated that while driving 55 MPH, the vehicle lost power and then stalled. The vehicle stopped in the middle of the highway and was inspected. The vehicle was then towed to a different dealer where it was diagnosed and determined that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The vehicle was towed back to the dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 53,000.

Filed Aug 31, 2026 · Engine · 61,000 miles · CO

The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving at highway speeds, the vehicle shut off while displaying "Service Transmission Now Unable to Shift Soon" and "Engine Power is Reduced" warning messages. The vehicle was towed to a dealer where it was previously inspected under the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, no repairs were performed. After remaining at the dealer for nearly eight weeks, the engine was replaced under warranty. A few weeks after the replacement, the same warning messages were displayed on the instrument panel upon startup. The contact attempted to drive the vehicle; however, the vehicle failed to exceed 20 MPH and was towed back to the dealer. While attempting to drive the vehicle into the service bay, the technician experienced severe hesitation and engine stalling. During diagnostic testing, a large amount of metal shavings was discovered in the oil filter, and the vehicle was diagnosed with the same engine failure as before. The vehicle was repaired; however, the contact refused to take possession of the vehicle due to safety concerns. The manufacturer was notified of the failure, and a case was filed. The failure mileage was 61,000.

Filed Aug 28, 2026 · Engine · MN

Had the recall service done , where they change the oil weight, to the 6.2 L engine and just a few months later the engine died while driving on the highway . It just stopped running. The car is only 3.5 years old and the engine died. They took it apart and said it was a non effected part that failed but i find that crazy. No warning just complete shut down. I was luck and only going about 30 MPH on the highway due to heavy traffic. But then needed to sit on the highway for hours weighting for a tow. The kicker is the car would not go into neutral and made everything so much harder.

Filed Apr 21, 2026 · Engine · NJ

My 6.2L engine failed on 1/6/26 due to a OEM bearing issue. The vehicle was inspected and engine had to be replaced after the recall and service were done. The vehicle stalled while doing 30 mph on a local road. No warning lights or problems were observed or detected prior to the incident.

Filed Mar 5, 2026 · Electrical, Engine · FL

In several separate unreplicable instances, the vehicle has turned off while driving, once on the highway, once on my street, once turning across heavy traffic, and others. I've almost died a couple times and I've taken it to the dealership several times, they have Not been able to find anything wrong with it and have been unable to replicate the issue. The engine has been replaced, and it was happening before and since. My 2023 is also doing the same thing.

Filed Feb 16, 2026 · Engine · MI

My 2022 Chevrolet Suburban 6.2L, approximately 96,000 miles. Vehicle was taken to dealership for transmission warning message and returned as “repaired” with a software update. The following day, February 12th, while driving at highway speed on the expressway, the vehicle suddenly lost power without warning. A message appeared instructing me to press start, and the vehicle shifted into neutral and stalled. No warning lights were illuminated prior to the stall. This created a serious safety risk due to sudden loss of power at highway speed.

Filed Jan 26, 2026 · Fuel system · FL

On Saturday, 11/29/25 @ 3PM, while driving on I-75 from GA to MIA, our 2022 Suburban VIN: [XXX] sudden & unexpected had a mechanical failure. Without warning, vehicle stalled/ stop while traveling at highway speed, leaving us seconds to maneuver to the side. This failure created an extremely dangerous situation that could have resulted catastrophic or fatal accident for my family. Check engine light came on (code P102A). An officer stopped to assist & arranged car to be tow which we had to pay $135 to nearest Chevrolet dealership. Since the dealership was closed, I was forced to stay an additional night in a nearby hotel and paid $106.46. The vehicle was inspected by Countryside Chevrolet, who diagnosed the issue as a failure of the fuel pump control module however I was informed that this VIN was not covered under warranty or any special coverage, despite the fact that we experienced the exact same failure on our 2021 Chevrolet Tahoe, which was covered under warranty for this same defect. I was forced to pay $708.72 for the repair. This inconsistency is unacceptable—especially considering GMs extensive history of complaints, recalls, & class action litigation involving defective fuel pump & fuel system components, which present a well-documented safety risk. I filed a complaint with GM Customer Care (Case XXX). I submitted all required receipts for repairs, towing & hotel, however GM denied my claim without providing any explanation, only stating VIN was “not covered.” Also, GM refused to provide a written justification & my request for a manager callback was ignored. No consideration was given to the safety implications of this failure. This response is unacceptable & demonstrates a failure to take responsibility for a known safety defect. Demand: Given the seriousness of this incident, the documented defect, & GM’s prior knowledge of same failures, I demand full refund of $950.18 for expenses. This situation could have ended tragically. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA

Filed Nov 5, 2025 · Engine · NC

Engine failed while driving. Vehicle began making clicking noise less than one minute for engine shut off while driving. Check engine light came on after engine shut off. Car was stopped at a busy intersection and couldn’t move. Car is currently at Chevrolet dealership and is in need of a total engine replacement

Filed May 22, 2025 · Fuel system · NC

Engine lost power and stalled without warning while driving down the highway. Coasted to side of road and was unable to restart engine. After engine stopped, dash indicated low fuel, although tank was 3/4 full. After coming to a stop, was unable to shift out of Park (which could have been a major issue if I had not been able to clear the highway before coming to a stop). Towed vehicle to closest Chevrolet dealer, who replaced the fuel pump control module. Dealer indicated that this is a common failure item to the point that they stock the part and suspected what the failure was based on my description. When pressed, the dealer representative also noted that GM has not updated or redesigned the factory installed fuel pump control module ("the new module installed is exactly the same as the one that failed"). Fortunately, traffic was light and I was able to pull to the side of road. This would be extremely dangerous if it happened while driving on a multi-lane expressway and we were trapped at a stop in heavy, fast moving traffic.

Filed Apr 24, 2025 · Engine · 90,000 miles · NY

The contact owns a 2022 Chevrolet Suburban. The contact stated while driving at approximately 55 MPH, the accelerator pedal was depressed and there was an abnormal banging sound coming from the rear of the vehicle and the vehicle lost motive power. The contact depressed the accelerator pedal; however, the vehicle lost motive power and stalled. The contact stated there was no warning light illuminated. The contact had the vehicle towed to a dealer. The dealer determined that the engine had failed but was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was informed of the failure but informed the contact that the vehicle was no longer covered under warranty. The contact researched online and related the failure to the federal safety agency Action Number: PE25001 (Engine, Engine and Engine Cooling). The failure mileage was approximately 90,000.

Filed Apr 14, 2025 · Engine · NM

53,000 miles. While on highway, engine turned off completely. Coasted off the exit ramp into a parking lot. Engine started again with no issue. 2 days later: engine started knocking very loudly. Vehicle completely died while driving on street. No start, no crank, couldn't shift to neutral. Dash would turn on, but that was it.

Filed Mar 7, 2025 · Transmission · AL

While driving from work to the gym (03/04/25), I was stuck in traffic due to a wreck; when traffic started moving again, I didn't. It was like it was in neutral and was just sitting there revving the engine. It finally started moving but clearly not functioning properly. A few miles later the Check Engine light came on with a "Reduced Acceleration Drive with Care" message displayed on the dash. I limped it into the parking lot and as I tried to back into a parking space the vehicle stalled and put itself in park. Finally was able to get it into a parking space to wait for a tow truck to have it towed back to the dealership. Chevy dealership has informed us that it needs a torque converter and a valve body (03/06/25) and they will create a "SPAC case" with GM as it is still under power train warranty. No eta on parts. Supposed to hear from Hertz on a rental (no more than $45 coverage a day; so likely not going to get a similar vehicle as a rental); no further news as of today 03/07/25. We bought the vehicle less than a month ago and haven't even made the first payment (other than the down payment); looks like that will occur and we won't even have a car to show for it.