Tl* the contact owns a 2004 chevrolet tahoe. While driving approximately 30 MPH, the brakes failed to respond when the brake pedal was depressed. The brake service indicator illuminated. The contact discovered that the rear driver side brake line was corroded and leaking brake fluid. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 100,000.
2004 Chevrolet Tahoe brakes complaints
Page 3 of 4: complaints 41 to 70 of 86, newest first, as owners wrote them.
Rusted brake lines failed. Lost brakes at highway speed.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated that during an unrelated repair, it was advised that the brake line was entirely rusted and that the brake pad went to the floor. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 185,000.
I had to hit the brakes hard to avoid a person that ran a stop sign. I drove off, down a hill and upon reaching the stop sign at the bottom of the hill, I applied the brakes and the pedal went to the floor. I had very limited braking and stopped 3/4 of the way into the intersection. Thank goodness there wasn't any cross traffic. I had the car towed to my local chevy dealer and was told that one of the metal lines had ruptured and that all the lines would have to be replaced. Dealer wants $2,800.00 to replace these bio-degradable brake lines. One would wonder why the muffler is still original and in good shape, but the brake lines corroded to the point of catastrophic failure. Dealer is not willing to assist in the cost due to the age of the vehicle. The investigation that is on-going needs to include more model years than what is being investigated. It may then shed light on how wide spread this problem really is. I am under the understanding that metal brake lines should last a lot longer then a muffler. Gm is taking the stance that the problem only occurs in "salt states". If I am not mistaken, don't they sell these vehicles in "salt states?" there needs to be a recall, before someone gets killed. This is serious. Updated 09/24/14.
I was launching my boat on a boat ramp to a lake.when backing up to the water I pressed my brakes and the brake pedal went to the floor. I was able to put the truck in the forward gear to get out of the water. The break line was leaking. I looked under the vehicle and all the lines where rusted out. I was told that the brake line had failed because it was rusted out. This is extremely dangerous. There should be some type of warning to other tahoe owners and a recall.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated that while traveling at an unknown speed, the brakes failed and went to the floorboard abnormally. The contact had to pump the brake pedal to get the vehicle to stop. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was not included in the federal safety agency campaign id number: 04v045000 (service brakes, hydraulic). The manufacturer was notified of the failure. The approximate failure mileage was 124,000.
Got into parked truck and the brake pedal went to the floor. Can not even stop truck at idle speed. Brake line leak between proportioning valve and ABS module near bend above frame. Can't even take it in for repair without towing it. Rear brake lines in bad shape, but not leaking yet.
Brake line rupture causing complete brake failure. I was switching the cars around in my single wide drive way when the brakes failed on my vehicle. Pulling the vehicle back into the driveway from being stopped on the road so I barely accelerated and fortunately had very little speed when the brakes failed, the pedal going all the way to the floor, while failing to slow/stop the vehicle. I was able to stop by putting the transmission in park, no harm done though not a gentle stop. Identifying the problem was not difficult as the brake line hissed loudly where it ruptured when pressure was applied to the brake pedal. A great deal of corrosion was present on all of the lines as well as the fuel lines.
Approx. 6 months ago I was driving when a vehicle entered the intersection in front of me. I stepped on the brakes and the pedal went to the floor. Luckily there was no crash but my vehicle just barely came to a stop. Towed the vehicle to a dealership and found all the brake lines were rusted out and needed to be replaced. On 3/28/14 I began noticing strong gas fumes coming from my vehicle. I again took it it in and found the fuel pump assembly, all the fuel hoses, and the straps and bolts that hold the fuel tank were rusted out. I read that the federal safety agency was doing a study of this issue. I understand my vehicle is 10 years old and I live in the northeast but I observed a lot of rust under my vehicle. I am a police officer and a crash reconstructionist and these rust issues could cause serious issues with vehicles resulting in crashes. I feel this issue needs to be investigated because it effects crucial systems like the brakes and fuel systems. Please feel free to contact me for further information.
Lost brakes pedal went to floor. Brake lines rusted out. Had vehicle towed to dealership for repair. Stainless steel brake lines and fuel lines should never rust !!! General motors is liable for this problem and should make repair immediately.
I was leaving work and I was coming to a junction, applied my brakes and nothing happened, I was slowly going into the middle of the road and a car was coming towards me, I had to accelerate to get in front of him, to avoid him hitting me. I got to the main junction which is on a hill and I pressed very hard on the brakes and it finally stopped. I drove 2 miles an hour for about 100 ft and turned into a gas station. I called a tow truck and while waiting fluid was leaking from the front of the car. The tow truck man got under the car and said all my brake lines were rusted and leaking. I was lucky there was not a lot of traffic on the road. Why are the brake lines rusted. Is there a recall on these brake lines.
My mechanic informed me today that my brake lines were very corroded and in danger of a catastrophic failure.
A few weeks ago I was traveling down hwy 60 in southwest missouri and the "reduced engine power" light came on. The vehicle immediately slowed to about 4-5 miles per hour and I was unable to accelerate. I crawled to the next exit where I barely made it up the incline and into a gas station. We checked the gas, oil, battery, etc. I turned off the vehicle and when I started it up again, it seemed fine. I continued home. The next day I took it to a mechanic who said that it all checked out perfectly and there was nothing wrong. This has happened 12-15 times in the last month and every time I take it to the mechanic, he tells me that the computer is not "throwing codes" and there is nothing wrong. This is not a figment of my imagination. This keeps happening. The most recent "episode" was last night. We took the boat down to the river to go gigging at night. When I went to pull the trailer up the boat ramp and park the vehicle, the "reduced engine power" light again came on and I could not pull up the hill. Every time I attempted it, the light came on and I actually went backwards towards the river!! My children were in the vehicle and I was scared we would be trapped it something further malfunctioned and we rolled back into the deep cold water!!! From what I have now researched gm is aware of this problem and I do not understand why a problem this potentially deadly has not been dealt with! I am not the first owner of this vehicle and have never had a problem like this. I am a single mother of three beautiful boys and I am scared to drive my car because of this. I cannot put them in a potentially deadly situation. So our only vehicle sits and waits in our driveway leaving me stranded a lot until gm can come up with a solution on their dime. This isn't fair that a problem is know and no one at gm will fix it. Please help fix this before someone dies!
Tried to stop, brake pedal went to floor. Brake lines at the frame under driver's side rusted through. Truck had to be towed, and all brake lines replaced.
I bought a 2004 chevy tahoe august 2013- I maybe drove it twice a week for maybe 3 weeks.do to the screw up with the dealership and insurance company I was canceled in september up until october 22 the truck sat in my drive way. Finally was able to drive it. Drove it one day, I was driving back after filling my tank. I'm coming up to a red light with a motorcycle in front of me. I began applying the brakes and I'm approaching the motorcycle in front of me. When I try to apply the brakes, I'm pushing them all the way to the floor and I'm not stopping. I know at this point I don't have brakes. I swerve to avoid rear ending the motorcycle. I almost hit on coming cars. Then I'm able to apply what was left of the brakes to get the car to stop. When I put the tahoe it to park that's when the brake light comes on. I get out and I see nothing but brake fluid pouring out of the front driver side. I look underneath the truck(SUV) and the entire brake lines where rotted and the entire underneath the truck was rusted.
Abs light came on. While braking to enter an on-ramp, steering wheel jerked and passenger side front wheel almost broke off.
2004 chevy tahoe, z71. All brake and fuel lines are severely corroded. Appear to be seeping fluid.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated that while driving approximately 60 MPH and depressing the brakes, the brakes would not respond. The contact continued to depress the brake pedal until the brakes became responsive. The vehicle was taken to the dealer for diagnostic testing. Where the technician advised that the brake hydro boost exhibited a leak and would require replacement. The contact referenced the federal safety agency campaign id number: 04v045000 (service brakes, hydraulic) but was advised by the manufacturer that the failure and stated the VIN was not included. The vehicle was repaired. The approximate failure mileage was 114,000.
Service brake system light came on while driving 25-30 MPH checked for possible recalls and found (recall 04004) contact gm directly which stated that my vehicle was not included in this recall and refered to safcar.gov to file the incident gm stated that recalls are based on information from this website and not directly from the manufacturer.
As I applied my brakes to stop for traffic in front of me my brakes failed causing me to hit the vehicle in front of me. There had been no warning that the brake system had an issue but upon inspection of the brake lines that come out of the master cylinder it appears that one of these stainless steel lines has failed.
Brake pedal completely depressed and all brake fluid spilled out on driveway. I looked under vehicle and all brake line were visible highly corroded. I've been maintaining vehicles for 50 years and have never seen a failure like this. The brake lines had the appearance of cars 30 years old but were heavily pitted and corroded. I don't want to hear a gm excuse of road salt wear and tear ! This is inexcusable!
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated that while driving approximately 25 MPH, the brake pedal dropped to the floor board after being engaged. The contact was able to stop the vehicle. The vehicle was taken to the dealer who diagnose that the brake lines were corroded and needed to be replaced. There was an investigation the federal safety agency action number: ea11001 (service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings) that may be related to the failure. The vehicle was not repaired. The VIN was not available. The approximate failure mileage was 100,000.
My brake lines burst and began leaking brake fluid as I put my car in gear and began backing out of my driveway. I crawled under the car and the lines looked corroded. I live in delaware and purchased the car in northern new jersey.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated while driving 25 MPH the brakes were applied and she heard a fluttering noise. In addition, the vehicle would pull to the right. The contact had the brakes replaced. The vehicle was taken to a personal mechanic for diagnosis and the contact was told the wheel sensor needed to be replaced. The wheel sensor was replaced. The mechanic disconnected the ABS and the fluttering ceased. Afterward when the contact applied the brakes the steering would become tight but only when turning to the left. The manufacturer was notified and offered no assistance. The failure mileage was 120,000 and the current mileage was 136,000.
Applied brakes after another driver cut me off and the brakes failed. Check brake system appeared in the odometer along with the ABS light.
While coming to a slow stop of 5 to 10mph, the ABS kicks in.affected part is the front bearing and ABS sensor, caused by rust build up in the unit.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated that the brake pedal would depress to the floor whenever the brakes were engaged and it would take repeated heavy pressure to stop the vehicle. The vehicle was not taken to have the failure diagnosed or repaired. An authorized dealer informed the contact that the vehicle was not included in the recall associated with the federal safety agency campaign id number: 04v045000 (service brakes, hydraulic). The manufacturer was not made aware of the failure. The failure mileage was 55,000 and the current mileage was 70,000.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated while driving 35 MPH the vehicle stalled with out any warning. The vehicle was taken to the dealer who diagnosed that the hydraulic brake system was defective and needed to be replaced. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure and current mileage was 120,000.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated that when applying the brakes at low speeds, the anti lock braking system would engage and the vehicle would experience an increased stopping distance. An independent mechanic replaced the rotors and brakes, but the failure continued. The vehicle was then taken to an authorized dealer where they were in the process of diagnosing the failure. The approximate failure mileage was 85,000.
Tl* the contact owns a 2004 chevrolet tahoe. The contact stated that when the brake pedal was depressed, the contact noticed brake fluid leaking from the vehicle abnormally. The contact inspected the vehicle and discovered that the two bottom brake lines were worn and had split simultaneously. The vehicle was not taken to the dealer for diagnostics or repairs. The manufacturer was not made aware of the failure and the vehicle was not repaired. The approximate failure mileage was 113,000. Updated 06/17/11*lj updated 2/03/2012 *ln
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Chevrolet Tahoe?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history