The engine lifters have failed twice in our 2021 Chevy Tahoe. The first time was at 13k miles and the second time happened at 100k miles. Both times the failures put my family in an unsafe situation and almost led to a multicar accident. This is a known issue that multiple people report online in the 2021-2024 Chevy Tahoe. The first time the lifters went out, I had just purchased the car. I only had 13k miles on the vehicle when it began shaking and jumping while at a stop. As I drove further the car began violently shaking and making backfire noises. I had to stop the vehicle in the road, as there was no pull off. We had the vehicle towed to the dealership and they replaced them under warranty. They said the lifters had gone out and they resolved the issue. I asked at that time if this was normal and if it could happen again. I was told it was not normal and it was not something that should be happening on a new vehicle, but they had fixed the issue and felt comfortable that it was resolved. The second time happened just a couple days ago. There was no warning or lights that came on before the incident. My family was in the fast lanes on I-77, going about 70 mph, and the car began misfiring. It was making noises that grew loud and then the car began violently shaking. We were forced to pull off the interstate abruptly. This put us in an extremely unsafe situation. The car is only at about 100k miles and 5 years old. We had the car towed to a Chevy dealership and were told the lifters went out again. This time damaging the cam shaft as well. It is a $6,600 repair, as the car is out of warranty now. This issue should not be happening, especially not multiple times, on a car that is only 5 years old. I believe there is a defect. When there are no warning lights that alert you to a potential issue, this causes an extremely unsafe situation for drivers, passengers, and surrounding vehicles.
2021 Chevrolet Tahoe engine problems
188 complaints (40% of all complaints for this car). Typical mileage when it fails: 61,000. 2 crashes reported.
- owner complaints
- 188
- of this car's complaints
- 40%
- typical mileage
- 61,000
- crashes
- 2
- recalls
- 1
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
Chevrolet Tahoe engine problems in other years
Specific symptoms reported on the 2021 Chevrolet Tahoe engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Check engine light 88Engine failure 56Stalling 56Loss of power 49Knocking 39Won't start 26Misfire 24Oil consumption 6
Related recalls
Engine and engine cooling: engine: hard parts internal/mechanical
- What is wrong
- General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
- Risk
- Engine failure increases the risk of a crash.
- Remedy
- Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1‑800‑333‑4223, Chevrolet customer service at 1‑800‑222‑1020, or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is N252494000.
Recall number 25V274000 · Recall details
Related investigations
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V‑274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V‑274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GMâs recall remedy for Recall 25V‑274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V‑274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V‑274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
EA26005
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V‑274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V‑274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GMâs recall remedy for Recall 25V‑274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V‑274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V‑274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
RQ26001
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V‑274. These engines are installed in Model Years (MY) 2019â2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V‑274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V‑274, the federal safety agency has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V‑274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
EA25007
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GMâs full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engineâs bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V‑274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GMâs recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V‑274. Based on GMâs recall, ODI will close this PE. the federal safety agency will continue to investigate complaints of engine failure outside the scope of recall 25V‑274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
PE25001
What 2021 Chevrolet Tahoe owners say
Most recent owner complaints, unedited.
Engine failure at2000miles, then at 80000
Driving on the highway when all lights lit up on the dashboard. Car slowed down immediately following alert notifications. Towed to dealer. Was told I needed Camshaft and both banks of lifters all head bolts and head gaskets (W) [Other]: Camshaft actuator and bolt and chain tensioner
Vehicle is a 2021 Chevrolet Tahoe Premier with under 50,000 miles. The vehicle experienced a sudden and complete loss of reverse gear, accompanied by violent lurching, sputtering, and dangerous hesitation/stuttering while accelerating between gears at speed. A certified dealership inspection physically diagnosed the vehicle with multiple stuck valves inside the transmission control valve body, requiring a complete valve body replacement. This exact mechanical failure completely mirrors the known safety defects outlined in GM Special Coverage Program N242454441, which details transmission pressure losses causing gear engagement conflicts and potential rear-wheel lock-up hazards. The replacement transmission component installed by the certified dealer failed catastrophically within four miles of pickup, again causing severe transmission sputtering and shifting failures that render the vehicle entirely unroadworthy and a safety hazard on public roads. The dealership has been forced to order an entirely new replacement valve body assembly under warranty due to a consecutive failure. General Motors Corporate Customer Assistance acknowledged that the vehicle is physically experiencing this transmission valve defect, but refused a voluntary warranty override solely because the vehicle's automated database VIN block falls just outside their pre-programmed list for Special Coverage N242454441. The corporate case representative explicitly instructed the consumer to file this federal safety report with the federal safety agency due to the systemic component failure.
The vehicle suffered complete internal engine failure due to a snapped timing chain on startup. The vehicle turned over via the starter motor but failed to start. A professional diagnosis confirmed the broken timing chain caused extensive valve-to-piston damage, requiring a full engine replacement. This failure appears to be a direct consequence of the known 6.2L L87 V8 engine crankshaft and connecting rod manufacturing defects. Severe mechanical resistance or violent rotational harmonics at the crankshaft level place un-engineered stress on the timing drive system, causing the chain to snap under startup torque. All broken components are preserved and available for inspection. The defect creates a severe risk of sudden, total loss of propulsion while driving. Had the compromised timing chain snapped at highway speeds rather than on startup, it would cause immediate engine seizure, a sudden loss of power steering, and a loss of power brake vacuum assist. This leaves the driver unable to accelerate or safely steer out of active traffic, creating an extreme risk of a high-speed crash.The broken timing chain and total engine destruction were officially diagnosed and confirmed by professional automotive repair technicians.The damaged components have been inspected by independent repair representatives. The vehicle has not yet been inspected by General Motors because this specific VIN is excluded from the current recall scope. There were no warning lamps, check engine lights, or diagnostic trouble codes (DTCs) prior to parking the vehicle, and no outward symptoms of severe engine stress were present until the complete no-start failure.
On [XXX], while driving near Mammoth Mountain, California (Highway [XXX]), the vehicle suffered a sudden, severe engine malfunction. The engine began misfiring violently, accompanied by a loud, mechanical clacking noise, and experienced an immediate loss of propulsion power. This mechanical failure left my family—including young children—completely stranded on the side of a mountain highway in a secluded wilderness area with dropping temperatures (39°F) and active local wildlife Because the vehicle could not safely maintain highway speeds or generate sufficient power, it created an immediate and severe traffic safety hazard, forcing us to secure emergency transport for the vehicle. Which took 4hours for someone to come out to the secluded hwy on a holiday weekend. Dealership Diagnostic Findings A formal inspection conducted by a certified General Motors dealership (Michael Hohl Motor Company) confirmed the following: Symptoms: Gas engine diagnostic confirmed "Misfire, and clacking noises coming from passenger side of the motor." Diagnosis: Cylinder Head / Valve / Lifter / Lash Adjuster failure. The dealership documented a collapsed lifter and recommended a complete engine tear-down to inspect lifters and pushrods for wear or bending. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2021 Chevrolet Tahoe – Unexpected Shutdown/Restart While Stopped On two separate occasions, my 2021 Chevrolet Tahoe has unexpectedly appeared to shut down while I was stopped with my foot on the brake. The vehicle is equipped with Auto Stop/Start, and initially the event seems like a normal Auto Stop. However, instead of a normal engine Auto Stop/Start cycle, the vehicle appears to shut down or reset more completely. The event is jarring, and the power door locks lock/unlock as the vehicle shuts down and restarts. The vehicle subsequently restarts and I have been able to continue driving. This has now occurred twice while stopped. I am concerned that the vehicle may be experiencing an unintended stall, loss of electrical power, or another malfunction rather than normal Auto Stop/Start operation. I checked my VIN through the federal safety agency and it does not currently show an open recall. I am aware that certain 2021 Chevrolet Tahoes have previously been recalled for a condition that could result in an engine stall, although my VIN does not appear to be included in that recall population.
The number 7 DFM lifter failed and is suspected of failing due to the Active Fuel System. The vehicle is currently at the dealership where it was diagnosed and is awaiting replacement parts that are on GMC back order for a month or longer. The vehicle started shaking on 8/25/26 when idle and the following warning lights were visible: AVS, traction control, and ECU.
DFM (Dynamic Fuel Management) system failure causing collapsed lifters, oil consumption, and complete engine failure. To repair our vehicle it will require a complete engine replacement. This has been a known issue with GM and yet there has been no recall to fix the issue. Now our engine must be replaced.
Total engine failure. No warning lights shown and vehicle had been checked numerous times and reported as just fine.
Questions about the 2021 Chevrolet Tahoe engine
Does the 2021 Chevrolet Tahoe have engine problems?
Owners have filed 188 complaints about the engine of the 2021 Chevrolet Tahoe, 40% of all its complaints, more than any other problem.
At what mileage do 2021 Chevrolet Tahoe engine problems start?
The typical (median) mileage in owner complaints is 61,000 miles.
Was there a recall on the 2021 Chevrolet Tahoe engine?
Yes, 1 recall: 25V274000. Check your VIN to see if your car still needs the free repair.
What year does the Chevrolet Tahoe have bad engine?
The Chevrolet Tahoe model years with the most engine complaints are 2021 (188 complaints), 2023 (147 complaints) and 2022 (84 complaints).
Other 2021 Chevrolet Tahoe problems
Fuel system 122Transmission 90Electrical 58Airbags 27Driver assistance 27Brakes 22Lights 16Steering 15Seat belts 13Acceleration 10Suspension 8Seats 7Body 4Wheels 4Visibility 3Tires 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Chevrolet Tahoe?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history