2023 Chevrolet Tahoe: stuck in gear or won't shift

Filed Feb 18, 2026 · Brakes, Driver assistance · MD

To the federal safety agency, I am reporting a serious safety defect in my 2023 Chevrolet Tahoe purchased from Criswell Chevrolet (Gaithersburg, MD). Defects include a documented brake system failure while driving and repeated electrical/shift faults preventing shifting out of Park. The issue is ongoing even after the dealer/manufacturer stated it was fixed. Key events: Feb 3, ~12:45 pm: While traveling ~35–39 mph on a five‑lane road, brakes failed. I slowed by coasting uphill and using maximum pedal force to ~5–7 mph before stopping. I have video of the incident and two other times this has happened with pictures as the car was in park. Three prior start-up incidents: All dash lights illuminated (including brake failure and Forward Collison System Unavailable); vehicle stuck in Park. First required towing; dealer could not replicate despite reported stored codes. Subsequent event stranded my family. I have notified Chevrolet and the dealer; their offer does not address safety or recurrence. Please record this complaint, assess broader risk, and advise on related recalls/investigations. If there is a path forward to ensure the safety of my family, please respond with that guidance. My phone number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 19, 2025 · Transmission · NY

I was driving on an interstate when the vehicle check engine light came on and it went into limp mode causing the vehicle to go into low speed in the middle of traffic. Check engine light code P0747

Filed Oct 4, 2025 · Electrical, Engine · AL

The engine in my vehicle has experiences major failures in valve flap adjusters, multiple valve failures, valve cover issues, and over consumption of oil by over a quarter in a week and a half of average driving. My safety was put at risk because the engine failure resulted in traction control malfunctions while going 70 mph up hill on a major interstate. This led to extreme shaking which did not stop until slowing down to below 15 mph. Luckily I was a mile from an exit and was able to coast off the road quickly; it was decent enough weather, and I was less than 5 miles from my destination so I could creep between 15-30 mph to not exacerbate traction control alarms. That slow mph did back up traffic behind me. As far as I am aware the problem was likely reproduced by the dealership service tech, which led to their recommendation to replace the whole engine. They do not consider it to be covered by any warranty anymore. The engine may be in their possession still, but I am unsure. There were zero warning lights/prompts from the vehicle that anything was going wrong prior to the shaking and loss of traction control at high speed. The dealer service team suggested that my high miles led to the engine failure. I do highway driving with it and have followed all manufacturer recommendations for oil changes, and even more frequent changes with OEM oil since about 80k miles. I do not think this engine should have failed at this amount of mileage. I made note of oil consumption around 95k miles and measured oil loss regularly. It was a little less than a quart every 2K to 3k miles which manufacturer states is within spec so I would top off oil. A year ago it had a TCM wire replaced after burning in half. 3 weeks ago I also had to replace the entire turbo. The wire rendered my car unable to go in gear. The turbo failure put me into limp mode. I think the turbo failure was a sign of a deeper issue that went undiagnosed.

Filed Sep 18, 2025 · Transmission · NE

While traveling on [XXX] approximately 20 miles west of Rawlins WY the vehicle entered “limp mode” causing us to drive at an unsafe slow speed. The transmission caused a check engine light to activate which was confirmed by a service technician in Rawlins with a PO747 code show on his OBD2 scanner. The problem was confirmed by the servicing dealer in Lincoln NE. The transmission was inspected by the servicing dealer. They replaced the valve body and fasteners approximately 1 1/2 months later. The problem first occurred at the time of the incident and I had no prior warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 17, 2025 · Transmission · IL

Our 2023 3L diesel Tahoe had 63,000 miles on it and went into limp mode (CEL on) in late April 2025. We took it to the dealership and they diagnosed the valve body as the problem. We continued to drive it (as they mentioned it would be months before a replacement part would be in) while I did some research and discovered the magnitude of the problem. Just google it! Meanwhile, the rear wheels locked up on me after I had picked up our two children from daycare. It felt like we had a log chain hooked to our hitch that snapped us back - really hard! Felt like we had been rear-ended. This could have easily caused us to get in an accident, or worse, but thankfully we were not in heavy traffic. Our dealership was able to provide us a loaner truck. Approx. 50 days later, we were informed that we were approved for a new transmission - which was also on backorder! Almost 80 days later, our new transmission has arrived and been installed. We are very disappointed with how GM has handled the issue. We were lucky our dealer provided a loaner, as many have not. There are after-market providers who clearly state the upgrades they've made to the valves bodies, and while GM says they've upgraded the ones they make now, they won't share any details. I'm aware of this same limp mode/rear wheel lock up happening multiple times (on the same vehicle) to people in very low-mileage vehicles (less than 1000 miles). This isn't a small problem, and GM knows it. We will see how far we get with this "new" transmission, but as you could guess, I don't have high hopes! I just pray that no one gets killed.

Filed May 21, 2025 · Transmission · TX

My 2023 Tahoe with 76,000 miles went into limp mode and activated an engine light. The vehicle was taken to the dealership and had the code P0747 which is pressure control solenoid A is stuck on. The dealership technician is recommending a valve body replacement to repair this problem. This is a known problem by General Motors and has extended it to the 2022 models only. This is a safety concern that is causing rough irregular shifting, and a engine light to occur.

Filed Apr 17, 2025 · Transmission · TX

While driving and accelerating the transmission malfunctions and wont shift so as I try to accelerate the car stops accelerating and just goes very slow. This put us at risk as cars were coming fast behind us. The problem happened 3 times before taking it to the dealership where they knew exactly what the problem was because it has happened to so many others. The warning light that came on was the engine light and a message that read "Reduced Acceleration Drive with Care"

Filed Apr 2, 2025 · Engine · VA

We were driving on a busy interstate in Knoxville, TN on a Sunday. We were 2 hours from home and my 2023 Tahoe basically went into limp mode while I was in the fast lane and the check engine light came on. No warning in advance. The speed reduced, which backed traffic up, and put me and my 4 children in danger. We finally got off the interstate and the vehicle had to be towed in to the nearest dealership. I had a friend drive us to enterprise where they put us in a Jeep Grand Wagoneer. On Monday, I received a call from the dealership stating they had good and bad news. The good news was the repair is covered by warranty but the bad news was it will be 2-3 months before they can get the part. The part is on back order and several people are waiting ahead of me. The said part is a valve body for the engine/transmission. The dealership also informed me that warranty will not cover a non-GM vehicle and that they will only pay for a rental up to 44.00/day. It’s not my fault the part is on back order, nor that enterprise gave me a non-GM vehicle. Also, I have a family of 6, which is why I have a Tahoe and I cannot be put in a small sedan. My children play sports, we have upcoming vacation, and quite frankly, I didn't pay 90,000.00 for a vehicle to be placed in a vehicle that I don’t feel is safe for my family. If I had wanted a sedan, I would have bought one. GM should take better care of their customers, especially when something is like this is not the customers fault!!! I have contacted GM and have been told I will be called back by a supervisor each time I talk to someone. This is unacceptable!!

Filed Mar 17, 2025 · Engine, Transmission · MA

Traveling down the highway at 65 MPH the engine/transmission started bucking and you could hear the rear wheel lock up. The vehicle then would not shift and reduced the speed to 55MPH. Check engine light came on. Chevrolet is telling me the valve body needs to be replaced but keep driving it because it is on national backorder. After doing some research GM is hiding the issue and keeps installing faulty valve bodies. The GM fix is that they programmed the transmission to reduce speed when it notices excessive wear. GM is not standing behind the issue as it has been like pulling teeth to get a loaner vehicle.

Filed Mar 5, 2025 · Engine, Transmission · GA

I was driving my 2023 Tahoe on the interstate, in the far left lane. I had my wife and 2 kids in the car. Suddenly I noticed the air turned off and the dashboard screen went blank. I noticed that the car was now in neutral and the accelerator was not providing any response. I put on my hazards and started to merge across 7 lanes of highway without using brakes because we were going up a hill. We lost momentum in the second to last lane and could not move. The Tahoe then switched to park and the electrical system kept shutting off and rebooting. This also resulted in the hazard lights turning off for brief moments in time, so it was not effectively alerting other travelers of our dysfunction. (This repeated for the next 30 minutes until the battery died.) During that 30 minutes we were stuck in the lane with traffic buzzing around both sides of us honking and people screaming at us. My wife and 2 young children were upset and crying from the commotion. Poluce and emergency response team arrived, flagged traffic and drug the vehicle off the road.car was stuck in Park, with no ability to move to neutral. So tire rubber was smeared across the last 2 lanes and into the right shoulder. Later a tow truck arrived and hauled to dealership. The car had ~11,000 miles and bought the vehicle 2 months ago. This should not happen with new cars.

Filed Mar 4, 2025 · Engine · AZ

Engine, (6.2 liter V8), quit without warning at highway speed, nearly causing head-on collision. Engine wouldn't re-start and needed to be towed to dealership on flatbed truck. Vehicle also wouldn't shift into neutral requiring it to be dragged onto flatbed. Chevy dealer states new engines are on backorder with no expected repair date.