2023 Chevrolet Traverse: engine stalls while driving

Filed Oct 6, 2026 · Fuel system · MA

The high-pressure fuel pump/fuel delivery system failed on my 2023 Chevrolet Traverse at approximately 47,480 miles. The vehicle generated diagnostic trouble code P0091. An authorized Chevrolet dealership inspected the vehicle and documented that the high-pressure fuel pump was “internally faulty” and required replacement. The vehicle and/or failed component may be available for inspection upon request, depending on whether the dealership retains the component after replacement. This failure presents a significant safety concern because the high-pressure fuel pump is responsible for maintaining proper fuel delivery to the engine. Failure of this system can result in hesitation, reduced engine performance, loss of power, stalling, or failure to start. A sudden loss of engine power while traveling at highway speeds, entering an intersection, or merging into traffic could increase the risk of a crash and endanger vehicle occupants and other motorists. The malfunction was confirmed by an authorized Chevrolet dealership through diagnostic testing. The dealership identified code P0091 and specifically documented the high-pressure fuel pump as internally faulty. To my knowledge, the vehicle has not been separately inspected by General Motors, law enforcement, an insurance company, or another independent investigator. Warning lights appeared intermittently prior to the diagnosis. The lights would illuminate and later turn off, despite the underlying malfunction still being present. I am concerned that a critical fuel-system component experienced an internal failure at only approximately 47,480 miles. I am requesting that the federal safety agency document and evaluate this failure to determine whether similar high-pressure fuel pump failures are occurring in other 2023 Chevrolet Traverse vehicles and whether this condition represents a potential vehicle safety defect.

Filed Apr 23, 2026 · Electrical · LA

My dashboard gave an alert “battery saver active” then another alert stating to “service charging system, vehicle may stall”. Then the alerts cleared. After a few minutes both alerts were on my dashboard again. I was able to pull into an [XXX] ’s and had them check the battery, which was replaced a few months ago, employee stated that the battery was so low, only showing 11.4 that they couldn’t even test it, that she testing the alternator and the computer said it needed to be replaced. The employee stated that most GM replacement alternators for Chevy traverse 2023 are on back order due to so many having to be replaced right at the 3 year mark. We could only get a store brand replacement part due to the back order. Once I bought the part, my husband drove behind me for the 30 minute drive home, we had to pull over twice to jump off the battery and charge it due to the vehicle stalling. Once home we replaced the part and seems to work fine, it has only been 9 days. I have the original part for inspection and receipts of purchase for the new part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 17, 2025 · Electrical · CA

I was driving and the vehicle lost since power, I was unable to roll down the windows. And then the car just stalled. Luckily I was aware of it stalling so I pulled over in a residential area and came aaa. They sent out a battery service technician, he read the battery, the battery was ok but the alternator had low voltage. (Picture attached) so they recommend not to drive it and so I had to call for a tow truck to come. We bought a battery charger, it charges up to 12 but when we put it into drive it drops back down to 10 and that's when everything shuts off and the car dies.

Filed Jul 15, 2025 · Engine, Transmission · FL

The transmission. It is disengaging while driving down the road. It literally has basically stalled out in the middle of intersections, the highway, etc. There is a recall for this exact problem just not with my vin for some reason. I tried to get a dealership to look at it and see if they can fix it they say they will not. I am not safe nor are others with this malfunction.

Filed Aug 27, 2024 · Driver assistance · 30,000 miles · WV

The contact owns a 2023 Chevrolet Traverse. The contact stated while driving at approximately 70 MPH, the "ESC" message displayed, and the vehicle lost motive power and stalled. The contact stated that the vehicle failed to immediately restart. The contact stated that approximately one hour later the vehicle was restarted and driven to the local dealer. The dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 30,000.

Filed Aug 20, 2023 · Electrical · TX

On April 17, 2023 I was on my way home from work and got a message " Battery Saver Mode Activated." I checked the voltage and it was at 11.4. By the time I got home, the voltage had gone down to 10.3. I took the vehicle to the dealership on April 19, 2022 for repair. It was a bad alternator. On June 29, 2023, my family and I were on vacation and at a hotel in North Little Rock, Arkansas. I got up the next morning, 0330, and started the car and I got a message, " Battery Saver Mode Activated." I checked the voltage. It was at 11.3. I had to drive to the nearest truck stop so we would not be stranded on the side of a dark highway. The battery light came on and a message came up something like, "Charging system low. Vehicle could stall anytime." The battery light remained on. We made it to the truck stop, voltage was at 10.1, and I had to call a tow service to take my vehicle and my family to the nearest dealership in Stuttgart, Arkansas. It was another bad alternator and was repaired again and returned to me on August 4, 2023. Both instances, I was on busy highways with no gas stations for miles and not very good cell service. I live in Texas and the weather was hot and I had my son, my granddaughter, and 3 dogs with me. I couldn't get the windows down because the battery was dead. I contacted the manufacture. The vehicle is available for inspection upon request and has not been inspected by the manufacture as of yet.