2016 Chrysler 200 technical service bulletins
337 technical service bulletins and manufacturer communications cover the 2016 Chrysler 200.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- 948TE Transmission Reaction Shaft Service Bushing Kit Customers may experience a Malfunction Indicator...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Starter - engine
- Fuel vapor canister filter evap
- U90
- 2.4L Excessive Oil Consumption XB1 Warranty Extension The
- U90 Parts Ordering
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Lifter
- MIL/check engine lamp comes on after performing U90 recall PCM software update.
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- Suspected engine coolant leak.
- Emissions Recall U90
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- Water Quality When Mixed With Engine Coolant
- Emission Recall U90 Catalyst Efficiency
- WiTECH Small Leak Verification Test (SLVT)
- 2.4L Excessive Oil Consumption XB1 Warranty Extension The
- Adapter
- Adapter
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Warranty Bulletin D-23-01
- 2.4L Excessive Oil Consumption XB1 Warranty Extension The
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- 2.4L Engine Oil Consumption Test The
- Emissions Recall U90 Catalyst Efficiency
- Use thread repair tool for U90 or UA3 emissions recall repair
- Approved Use of Weld Through Primers
- Panasonic 8.4" CTP/FCTP Radio, Update Failure
- Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36...
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36...
- Customer Satisfaction Notification W20 Reprogram Powertrain Control Module
- Powertrain Control Module.
- Customer Satisfaction Notification W84 Powertrain Software Update
- No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Customer Complaint May Include Engine Oil Leak Or Consumption
- Wiring
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle,...
- Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
- Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- Battery Tester Warranty Code Procedures, Medtronic Update Process
- Steering System Inspection After a Collision
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- Adapter
- Customer complaint may include engine oil leak/consumption.
- (Rev. A) Power Inverter Load Ratings
- (Rev. A) Battery Tester Warranty Code Procedures, Medtronic Update Process
- Aluminum Body Panel Corrosion Repair
- Airbag Warning Lamp (AWL) Illuminated B0028-13 and B0020-13
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle
- Condenser
- 2.4L Engine Oil Consumption Test
- Blind Spot Or Park Assist Warnings, False Activation
- Throttle body
- Disinfectant Solution Recommended for COVID-19
- Charging System, Battery Diagnostic Tools and Warranty
- Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
- Hands On Steering Wheel Message In EVIC
- 2.4L Ignition Coil Boot Replacement
- 2.4L Ignition Coil Boot Replacement
- Key Programming, Security Pin Request, Pin Invalid
- Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the...
- RA3 and RA4 GPS Calibration Update
- Revised Customer Satisfaction Notification VB3 ? Navigation Flash
- Repair Parts Used For Structural Repairs
- Authentic Mopar® Glass Replacement
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- RRT 19-090 (Service Bulletin 08-111-19) 2013-2018 Multiple Vehicles RA3/RA4 Radio GPS Certification Error
- RA3 and RA4 GPS Radio Update
- Radio, multi
- Condenser
- Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio
- Radio [res]
- Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L...
- Res / rha / reb
- Valve Cover and Gasket, Left and Right Pertains to vehicles equipped with a 3.6L V6 V.V.T. Engine only:...
- RA3 and RA4 Radio Over The Air Software Updates
- Restraints Information Sheet (I-Sheet) has been added to Star Parts
- Rain light sensor Rain sense wipers do not operate: 1. Visual Inspection--> Check if the sensor is...
- Cover Kit Please note that if you are attempting to get the cover kit and it is not available the gasket...
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a...
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures...
- RA3 and RA4 Radio Enhancements
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Door Hinge Assembly Side door hinge noisy
- RA3 And RA4 Radio Over The Air Software Updates
- Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for...
- Restraints Remove I-Sheet from packaging
- Electronic Shift Module If DTC's U11C3, U0074 are present Stored or Active, please contact Pemi Sabageh at...
- Res / rha / reb
- Compressor, A/C lines, A/C Condenser This issue pertains to PF, UF, and KL only.~ During service of the AC...
- Water In Either Left Or Right Front Floor Footwells
- Replace Purge Control Valve Hose
- Flash: 2.4L Powertrain Diagnostic and System Improvements
- RA3 And RA4 Radio Enhancements
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- 948TE 9
- Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers,...
- Parts.
- Return: Wiring Assy
- Inspect and Return: Trim Cover Assy
- Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your...
- CBXDP361AA
- Warranty Operations Newsletter Updates from Warranty Operations
- Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers,...
- Return: Lamp Assy
- Inspect and Return: Solenoid Module
- 1NT30XDVAC
- P/n CBSZR068AA
- Multi-Air Actuator Assembly For 2.4 Tigershark Engine ONLY: When attempting to diagnose P Codes related to...
- Seat back panel loose or, has poor fit at top edge, side and bottom.
- Flash: 3.6L Powertrain Diagnostic and System Improvements
- A/C Compressor This applies to 2015 and 2016 KL, UF and PF. Before replacing the AC compressor for noise,...
- MY16 RA3 & RA4
- Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982
- Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable...
- Keyfob 2016 vehicle keyfobs with passive entry keyless go feature
- Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature
- Drivetrain control module (DTCM) this bulletin involves replacing and reconfiguring the drivetrain control...
- Drivetrain Control Module (DTCM)
- Active Grill Shutter (AGS): This GPOP applies to all 2014
- 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH...
- Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the...
- Flash: HVAC System Enhancement
- Rear trailing arm/link
- Rear trailing arm/link.
- RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free...
- RES / RHA / REB radio that supports Bluetooth and Hands-Free
- 3.0L V6
- Subject: RA3 RA4
- Symptom/condition
- SYMPTOM/CONDITION: A small number of customers may experience the following: Slow 5-4 downshift
- RA3 RA4
- Flash: Transmission Diagnostic And Shift Enhancements
- Powertrain Diagnostic And System Enhancements.
- Transmission Diagnostic And Shift Enhancements.
- SYMPTOM/CONDITION: A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar...
- Adaptive Cruise Control Sensor
- Radio Frequency Module RF_HUB
- 12 Volt Battery Return Process
- Bad cell" reading
- Rotor
- Flash: Electronic Parking Brake Module Enhancement
- This bulletin involves updating the Electronic Parking Brake (EPB) module software.
- Side Rearview Mirror Cover
- Pump
- Summary to be provided on a future date.
- Speed Transmission Quick Learn Procedure.
- Transmission, Oil Pump, Torque Convertor, and Flexplate
- 2016 JK WRANGLER wind noise or water leak coming from a void in the windshield sealer
- Urea tank shell
- Actuator Motor, Front Axle Locker
- A/C Compressor This applies to 2015 and 2016 UF models ONLY. Before replacing the AC compressor for noise...
- Active Grill Shutter (AGS) This GPOP applies to all 2014
- A/C Compressor
- Active Grill Shutter (AGS)
- Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture:
- Power Transfer Unit (PTU) Motor Position Enhancements.
- If vehicle DTC Code U114C-00 (Loss of Communication with PRNDL Display) is either stored or active, please...
- WIN Module
- Center Console USB Hubs
- Can/Am Warranty coverage
- Front Brake Moan Noise While Stopping In Reverse.
- Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture:
- This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for
- Load Floor Handle.
- This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with the latest
- NAG1 (5A580)
- Radio Software Enhancements
- Accelerator Pedal
- W5A580 (NAG1)
- Flash: Transmission Diagnostic And Shift Enhancements
- Radio Software Enhancements
- Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code
- Fuel Tank
- Part Description: MY16 RA3 & RA4 Replacement Radios Issue Description: Issue 1:~ All MY16 RA3 and RA4...
- Flash: Heated Steering Wheel Temperature Enhancement Depending on vehicle architecture:
- This bulletin involves updating the Comfort Seat and Wheel Module (CSWM) software for the KL/UF
- Flash: Transmission Diagnostic And Shift Enhancements
- : Transmission Diagnostic And Shift Enhancements.
- Flash: 3.6L Powertrain Diagnostic and System Improvements
- Powertrain Diagnostic and System Improvements.
- 2.4L Powertrain Diagnostic and System Improvements
- RL4 RK4 RM4
- 82212076, 82203694
- STAR Center News No. 78
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Chrysler 200?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history