Tl* the contact owns a 2006 chrysler 300. The contact stated that when the fuel tank was full, the vehicle stalled and turn turned off. The vehicle was able to restart after waiting. The failure recurred several times. The vehicle was taken to an independent mechanic who was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
2006 Chrysler 300 fuel system complaints
Page 3 of 7: complaints 41 to 70 of 172, newest first, as owners wrote them.
Every time you fill the tank the car will stall 3 or 4 times.
Whenever you put gas in the tank and fill it up the car we're all turn off as you are driving go a little bit and then turn off again. It does this every time you put gas in the car or fill it up.
Tl* the contact owns a 2006 chrysler 300. While driving 2 MPH, the vehicle stalled without warning. After filling up the fuel tank, the vehicle stalled on numerous occasions. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was 230,000.
Engine stalls after fuel fill up.
Tl* the contact owns a 2006 chrysler 300. Each time the fuel tank was filled with fuel, the vehicle would stall without warning after coming to a stop. The dealer could not find the cause of the failure. The manufacturer was not made aware of the failure. The approximate failure mileage was 101,000.
Mark chrysler 300 stalls when I fill it up with gas is there a warranty for a new gas tank it runs fine until I fill it up with gas it shuts off at low speed and in traffic.
While driving vehicle will suddenly stall and cut out making it really dangerous on the freeway the car will just shut down and you have to put it in neutral and started all over again now it stalls even in drive sitting at traffic light.
The engine shuts off while I'm driving and in reverse. I can restart it with no problem as long as I immediately step on the gas peddle. I have to shift into neutral to keep the engine running while at a stop light & back to drive. When I turn the key I do not hear the fuel pump like I used too! I've had repairs costing$509.96 and still have the same problem! I think my fuel pump is not working correctly or about to stop working! Is there a recall for the fuel pump?
Tl* the contact owns a 2006 chrysler 300. The contact stated that after refueling the vehicle, the vehicle stalled without warning. The vehicle was able to be restarted however, the failure recurred several times. The contact stated that the failure occurred when the fuel tank had less then a quarter of a tank. The vehicle was taken to a dealer where it was diagnosed that in the fuel tank, the o ring and the fastener package needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 63,000.
I have a chrysler 300 c 2006 I've had it for about a year now it's definitely been causing my a lot off issues and I've done research on this car a lot of others having same issues as such as me . Issue such ass car stopping while driving after filling up gas tank , and lower control arms falling off car while driving which is not safe and I have a small child which can be deadly driving in this car for both of us. I can't afford to fix these issues I really need to know what I can do about this
I purchased my vehicle used 2 weeks ago. Initially the vehicle was running fine until I filled it up with fuel. As soon as I pulled out of the gas station my vehicle started stalling as if I was losing power to my vehicle. After a few miles the stalling stopped. In the past few weeks the stalling has become worse every time I pump fuel. It shuts off if I'm idle at a light, it shuts off when I'm attempting to park, turn left, or in a drive thru. As soon as I would crank my vehicle up and go to accelerate the car won't move until after a few seconds and then it just jerks out before a smooth drive. Yesterday I took it to a chrysler dealership because after informing the used car sales lot where I purchased the vehicle they couldn't find the issue and wanted to keep my car for a week. After 10 hours of trying to find the issue they stated there had been a recall on the fuel tank for 2006 chrysler 300s. He said that should fix the problem and I should be on my way. So I was relieved to hear the great news coming from the chrysler dealership. Well after heading home and 20 miles out from the dealership there goes the stalling again last night. My vehicle shut off at the light and again as soon as I attempted to park my vehicle in the driveway. In addition to the fuel system issue is causing another issue that I truly fee wasn't investigated thoroughly. I noticed a recall on 2006 chrysler pacifica where the stalling was caused by the fuel system, TCM, and PCM module basically dealing with the power train and this is very highly the same issue going on with 2006 chrysler 300. There should've been a recall on both and there isn't. This is very dangerous as when I stalled onto the freeway I was almost hit by an 18 wheeler truck on last week. The TCM and PCM codes along with the fuel system code were showing in the diagnostic issue yesterday. Help please
Tl* the contact owns a 2006 chrysler 300. While driving 20 MPH, the vehicle jerked as if it would stall. The vehicle eventually stalled and was able to be restarted; however, the failure recurred several times. On february 2, 2016, the vehicle stalled again after the fuel tank was filled. The vehicle was towed to a local mechanic who diagnosed that the fuel pump needed to be replaced. The repairs were performed. The manufacturer was not made aware of the failure. The failure mileage was 68,700.
Stalls out while driving after I fill it up with gas. It has happened several times and twice while I was at an intersection on the take off...it has happened while riding down the road right after I filled it up with gas. I make sure the cap is tight and I do not overfill tank, when gas pumps stops, I do not add anymore. It happens only after fill up and after it shuts off, or jerks several times it seems to run ok. It is very scary and there is no warning when it happens.
Sending another log. Not sure my complaint went through. Since beginning of 2014 my 2006 chrysler 300c hemi intermittently stalls after refueling. It occurs immediately after a refuel and usually when you are at a low speed to stop at a traffic light, stop sign, or it can occur by just traveling at a slow speed. This can occur 'anywhere' after a refuel. It has occurred numerous times after pulling on interstates after a stop at a convenient refuel. I'm always frantic due to the traffic on interstates. I do not feel safe with myself and passengers in my vehicle with this situation. Sometimes after a refuel it will stall 3 - 4 times. I was going to take my car to a dealership, but wanted to read on the internet if any issues as this were logged. I was amazed. Chrysler should pay for the fix, since it is over $1000 to fix the issue, plus it is a known issue of 'numerous' recorded loggings. It stated on the internet that letters went out for a lifetime warranty for this issue, but I did not receive a letter. Please let me know how to go forward with this issue.
Tl* the contact owns a 2006 chrysler 300. The contact stated that while driving at 60 MPH and coming to a stop, the vehicle stalled and the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the vehicle needed a tune up and the fuel pump needed to be replaced. The vehicle was repaired however, the failure recurred. The contact referenced the federal safety agency action number: pe13016 (fuel system, gasoline). The manufacturer was made aware of the failure. The failure mileages 506,000.
Tl* the contact owns a 2006 chrysler 300. While driving 60 MPH, the fuel tank malfunctioned and caused the vehicle to shut off abruptly, which caused a crash. Three occupants sustained injuries that required medical attention. A police report was filed. The manufacturer was made aware of the issue. The VIN was unknown. The failure mileage was 104,000.
Tl* the contact owns a 2006 chrysler 300. While driving at a low speed after refueling, the vehicle stalled. The contact was able to restart the vehicle. All the warning lights on the instrument cluster illuminated. The vehicle was taken to a dealer who diagnosed that the fuel tank, fuel delivery pump, and pump injection pump needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 89,508.
I filled up my gas tank, drove approximately 2 miles and came to a stop sign. At the stop I experienced a erratic idle followed by my car shutting off. I stared it back up and for about 5 seconds it still and a very erratic idle. I was able to get out of the street but it could have been very dangerous.
Turned ignition, car starts right up, then stalls. After several attempts car becomes drive-able but stalls while driving, stopping and turning. At this point steering wheel locks and turning becomes difficult which is scary while in traffic. This problem occurs periodically, sometimes the car will drive okay and then starts stalling. Had this same problem in 2013, took to dealer and had to have gas tank replaced at a cost of $1300.00 dollars.
Tl* the contact owns a 2006 chrysler 300. While driving approximately 30 MPH, the engine stalled without warning. The vehicle was able to restart after two attempts. The failure recurred on numerous occasions. The vehicle was taken to a dealer where it was diagnosed that the fuel tank needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was not made aware of the failure. The approximate failure mileage was 70,000.
I first noticed surging at idle when in gear, this grew into stalling during stops and now is stalling/stumbling while driving. I've had multiple times where the car would completely stall while moving and had high potential for danger. I have no engine light and no engine codes. This car is an srt8 and driven very seldom, especially now. It's actually parked now due to this issue. The maintenance has always been meticulous and mechanics have come up dry with trying to figure this out.
I own a 2006 chrysler 300c and recently when I fill it with gas and drive away from the gas station it shuts of and I have problems keeping it running. I'm afraid to drive the car now because it can stop on me in the middle of a busy intersection and that could be very dangerous, in fact... Life threatening. I should not have to be afraid of driving my own car. That's ridiculous!
Started car the next day after fueling car the night before at gas station on the corner from my home it started riding real slow it making funny noise when it started riding better,but got in the car the next day no start car was taken to 2 mechanic shop 1st one you need a engine did not believe it 2nd shop broke it down need engine full of oil changed every 3 months only problem had was that plastic ring on when car would not get out of gear which I'm not the only one that this has happened too now I have no car only had for 4/ years and this has happen a lot wow wasted money and I always let this car run before I moved because years ago my grand father said chrysler were cold nature cars warm them up I was not even ready for my tune-up.
Tl* the contact owns a 2006 chrysler 300. While driving approximately 55 MPH on the highway, the vehicle stalled and shut off without warning. The contact pulled over to the side of the road, restarted the vehicle after a few minutes, and drove home. The manufacturer was notified of the failure and advised the contact to take the vehicle to an independent mechanic since there was no chrysler dealer at that location. The mechanic was unable to diagnose the failure, but recommended that the fuel and fuel cap be replaced. The failure recurred several times, but the engine could be restarted each time. The manufacture did not offer any assistance and stated that the vehicle was not included in any recalls. The failure mileage was 90,000.
I drive a 2006 300c hemi w/60k miles.I bought this car from a friend. This car has been in this city since 2006. Mid day temps 105'. I was running errands in town. I had stopped at 7 different locations, turned the vehicle off and a few minutes later returned to the car and continued with my errands. I was in the car sitting at a 4 lane intersection waiting for my turn and I looked down at the dash and the oil can light came on, then traffic started to move and I couldn't, my car had stalled. I turned off the A/C unit, the radio and put it in park. I tried 6 or so times to get the car to start but it wouldn't .I engaged my flashers while other drivers were honking and driving around me.I left it in traffic and got to the sidewalk out of danger. I was calling for help when a motorist pulled up behind my car and asked whats wrong. I told him it just died, sitting still waiting for our turn to go thru the intersection. He got in the car that had been sitting there for about 5 minutes and it started right up and he drove it to a safe parking lot. I parked the car in my garage and there it sits. I am afraid to get stranded in traffic again. I did some research on the web and found that chrysler announced on feb 13, 2014 chrysler extends lifetime warranty on 2006, 5.7 and 6.1 hemi fuel tanks. Apparently, no one has died yet so it does not quality for a recall but this is a known problem. I would like to know how I can qualify for this warranty?
I was driving my car then it went it just shut off, it was making funny sounds stopping and going then went dead the oil light came on it had oil I had just change the oil at a mechanic shop, some one helped me and the car start again I drove it home, every time I bought gas it start stopping and going on 95 highway I almost get killed it just shut down going 70 miles an hour then it just shut off, I need help I don't know what to do I am a lady don't have monies to spend on fixing car, I don't like to get gas because that is when it stop and go and stall in the road
Tl* the contact owns a 2006 chrysler 300. The contact stated that the vehicle exhibited a fuel odor. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 119,000.
Tl* the contact owns a 2006 chrysler 300. While driving approximately 25 MPH up a steep hill, the vehicle stalled without warning. The vehicle was parked for approximately 15 minutes while the engine cooled off and eventually restarted. The vehicle was taken to an independent mechanic. The technician diagnosed that fuel flooded the engine. The mechanic advised the contact that the fuel tank should never be filled to capacity. The vehicle was repaired; however, the failure recurred on several occasions. The manufacturer was not made aware of the failure. The approximate failure mileage was 70,000. Ma 10/8 updated 03/22/2016
Tl* the contact owns a 2006 chrysler 300. While driving approximately 55 MPH, the vehicle stalled and the power steering failed which caused the contact to lose control of the vehicle. The failure recurred multiple times after refueling the vehicle. The vehicle was taken to a dealer for diagnostic testing. The mechanic stated that the battery needed to be replaced. The vehicle was repaired but the failure recurred. The vehicle was taken to a dealer where it was diagnosed that the fuel tank needed to be replaced. The vehicle was not repaired. The contact also received notification of the federal safety agency campaign number: 15v313000 (air bags); however, the parts were unavailable to perform the repairs. The manufacturer was notified of the failure. The approximate failure mileage was 47,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Chrysler 300?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history