1996 Chrysler Town and Country brakes problems

Filed Jun 20, 2007 · Brakes · 75,000 miles · TX

Tl*the contact owns a 1996 chrysler town and country. The contact stated that the brakes failed while driving 15 MPH. When the brakes where applied, the contact heard a pop and the brake pedal went completely to the floor. The vehicle was towed. The dealer stated that the brake hoses were not standard parts due to the modification of the brakes for medical handicap purposes. There were two holes in the hoses because the parts were not standard, which caused the brake failure. The current and failure mileages were 75,000.

Filed Sep 16, 2005 · Brakes · 81,285 miles · MN

Failure of both rear brake hydraulic lines causing sudden loss of brake fluid making emergency brake only operable stopping device. Saved old lines. Both lines appear to have rusted through. Mechanic believes problem is with design in how lines are routed above gas tank approximately two feet ahead of left rear wheel. The position of the lines allows road salt and other corrosives to be collected on the steel surface of the hydraulic lines, thus leading to their eminent failure. Please note low mileage of vehicle. Mechanic repaired vehicle by installing new lines, but routed them in a position less susceptible to corrosion. Failure was preceded by noticeable leaking of brake fluid on garage floor. Ultimate failure occurred when vehicle was brought in for inspection/repair. Lines burst when mechanic tested brakes by pressing hard on brake pedal while it was parked. Brake fluid spilled out all over service floor. Actual repair cost: $289.02.*jb

Filed Dec 20, 2004 · Brakes · 114,000 miles · GA

Continually weak brakes, causing dangerously long stopping distances, intermittent pedal going to floor, outer front disc brake pad wears out between 10000 and 15000 miles inner pad always in excellent condition. Replaced calipers and attachment hardware, bleed brakes. Similar comments by other owners in web searches. Old parts installed problem not rectified.

Filed Jul 26, 2004 · Acceleration, Airbags · 131,000 miles · MN

While driving the transmission failed and the vehicle was unable to shift gears. Transmission was replaced twice, however the problem recurred. *ak the horn airbag and cruise control have been replaced. The vehicle had brake problems. The dealer determined that the front brakes were at 45% but the rear brakes were at 70%. The dealer cleaned and adjusted the brakes. The A/C failed, the dealer replaced the fan module. The power door locks failed. The cd player doesn't work. The low beam head lights do not provide enough light therefore the consumer has to leave the high beams on to see. This problem has been checked three times but the dealer said they seem correct. The passenger seat broke. The starter failed and as a result the vehicle would not start. The steering pump failed and as a result the steering wheel became tight when making turns. The rear heater lines were leaking. The water pump leaked.

Filed Jul 5, 2004 · Brakes · CA

Outside brake disc pads prematurely worn, inside pads virtually untouched. Replaced all pads, one disc, and turned other disc. The actual problem is caused by extremely poorly designed calipers. Outside pad in constant contact with disk. Releasing brake pedal does not remove pad away from disk. This specific problem is not caused by a malfunctioning part, as far as I can see. The entire caliper design appears to be flawed.

Filed Apr 29, 2004 · Brakes, Lights · KS

Windshield wipers activated usually after a turn was completed. This affected visibility of other vehicles. Also brakes and transmission failed. Dealer replaced four times the multi function switch/ brake pads/ rotors, and drums; transmission was replaced twice in the last two years, all at consumer's expense.

Filed Jan 14, 2004 · Brakes · FL

While applying the brakes ABS system activated and deactivated intermittently. Abs light flashed on the dashboard. Consumer took vehicle to the dealer for analysis, and mechanic replaced the sensor.

Filed Oct 6, 2003 · Brakes · FL

Consumer states brakes wear out prematurely. When brakes are replaced an odor is produced.

Filed Jul 28, 2003 · Brakes, Tires · AL · fire

While driving the rear brakes caught on fire which also caused the floor of the vehicle to catch on fire. The consumer was able to exit the roadway and the fire was extinguished. The insurance company recommended a shop to make repairs. The shop only replaced the brakes and fuel tank. The vehicle two rear tires were also burned in the fire. *ak *cb

Filed Apr 10, 2003 · Brakes · NY

When the vehicle accelerated, a loud noise came from underneath the van and then the wheels locked up, which prevented the van from moving. After the technician looked over the van, he identified the "parking mechanism" as the cause.