2012 Chrysler Town and Country fuel system problems

Filed Jul 23, 2026 · Electrical, Fuel system · ID

The TIPMs system has been recalled in multiple vehicles and has causes a fuel pump relay failure and numerous other electrical issues . Chryslers recall has yet to include this year make and model despite the fact the identical part is used in the recalled vehicles. Chrysler is picking and choosing which vehicles this recall applies to and it’s putting families at risk of the TIPM failing and leaving them stranded at any time. Chrysler has a packaged replacement part under “recall pricing” but refuses to cover labor to install the new part on certain vehicles.

Filed Dec 26, 2025 · Fuel system · MN

Fuel Relay System Failure When searching online apparently this is such an extremely common issue there is a special bypass part that was made, and part of a recall for durangos and jeeps but not the town and country, even though this part is failing all the time in this vehicle as well. Before it went completely dead, it did fail once when I was driving, which is a huge safety issue. I was lucky it started again and that I wasn’t going very fast. I didn’t know at the time that is was the fuel relay system failing until it finally stopped working and my car no longer started. Once bypassed with the bypass part it started immediately, however I had to buy the bypass part to confirm. This should be a recalled issue though, since it is an extremely hazardous issue if it causes failures while driving

Filed Jul 17, 2025 · Fuel system · MA

The TIPM is malfunctioning and causing the fuel pump to never turn of on the car. the only way to turn it off is to pull the fuse.

Filed Mar 4, 2025 · Electrical, Fuel system · UT

Has had some issues trying to turn on after sitting over night. It will just kill the battery but it just started to die while driving and the entire system shuts off. All the lights, the steering wheel locks up and gas goes out. All you can do is brake and hope that you can stop in a good spot before it dies fully. This has happened a few times with my kids in the car and now I just don’t dare to drive. The tipm needs to be recalled.

Filed Oct 16, 2023 · Fuel system · OH

The fuel pump relay has failed. The relay is part of the TIPM and the cost to repair at the dealer is well over one thousand dollars.

Filed Mar 19, 2023 · Fuel system · ND

Vehicle has repeatedly died while driving on the highway. After sitting approximately 1 hour it will start again.

Filed Mar 9, 2023 · Fuel system · IN

Fuel pump relay not working and caused van to stall while driving. Then van wouldn’t start due to not getting fuel. Vehicle is not safe to drive due to possibility of stalling while driving.

Filed Jan 18, 2023 · Driver assistance, Engine · MO

Confirmed cylinder number 2 misfire. Performed relative compression test and intake trace pull. Confirmed that number two has low compression and is directly affecting cylinder number fives intake pull. removed spark plug and did a compression test on cylinder 2 it had 90psi of compression and the rest of the cylinders were at 148psi of compression. used a bore scope and found cylinder damage in video attached vehicle needs a new engine to correct customers concern. When going up a small incline at 30-45mph engine would stall out. I have 3 little kids and I drive a lot for my job and want to be safe on the road! Also my blind spot detectors have constantly been on since about 75,000 miles. It’s kind of a distraction when you are driving at night.

Filed Aug 25, 2022 · Electrical, Fuel system · GA

The can has issue starting due to tipm malfunctions effecting the fuel pump. Also causes battery to die from fuel pump not shutting off when car sure off. The car has shut off on me. A few times. Most recently on the highway while being in the left lane. It was very dangerous. And hard for me to get it somewhere safe.

Filed Apr 23, 2022 · Electrical, Engine · PA

The External Fuel Pump Relay has failed causing stalling conditions while driving and starting problems. Along with that, it has drained the battery due to not turning the fuel pump off after the car is turn off. The part was recalled on the Jeep and Durango models with the same 3.6L engine. There have been many reports of this online with Town and Country and Dodge Caravan models with the 3.6L and 5.7L engines.