2016 Chrysler Town and Country body problems

Filed Sep 24, 2025 · Body · FL

Issue 1) Side slide door on driver side won't open. I could not get my child out and had to crawl across. Won't unlock, won't open manually, won't open electronically, won't unlock with fab. Issue 2) driver window has failed 3 times now. Like clock work every 2 and a half to 3 years it goes out.

Filed Jun 15, 2025 · Body · PA

First incident. Driver side sliding door lock failed. Sliding door could not be unlocked and opened from inside or outside the vehicle. Had to use other sliding door to exit van. Door had to be dismantled and failed latch replaced. Approximately 7 years old and roughly 52,000 miles. This was around 9/2023. Second incident. Passenger side sliding door lock failed. Sliding door could not be unlocked and opened from inside or outside the vehicle. Had to use other sliding door to exit / enter van. Scheduled to go in for failed latch replacement at Chrysler dealer. Approximately 9 years old and roughly 63,000 miles. Either one of these unexpected failed door latch incidents could have led to injury or possibly death.

Filed Jan 21, 2025 · Body, Electrical · OH

I received a letter from Chrysler regarding TSB #23-017-20 regarding the rear sliding doors unable to be opened either electrically or manually a few years ago. Recently the cars left/rear door wouldn't work. Unable to open it at all. It's a 2016 Town and Country with 147,421 miles on it. Well within the TSB requirements. I called a local Chrysler dealer. They told me if they decided the cars problem wasn't part of the recall they would charge me $250.00 for diagnostics. It clearly is related since it has the same symptoms. Sounds like their way of avoiding the repairs since Chrysler will only reimburse the dealer for 1.2 hrs when actually repair time is past 3 hours. I then called 1‑800‑247‑9753 the number on Chrysler's service bulletin they mailed me. After a 30 minute conversation were they told me the car didn't qualify. I convinced them it did when I referred the letter they sent me. They said to contact a dealer which I told them I had. I explained their response and they said they would put a complaint regarding the dealer and there was nothing else they could do. I called another local dealer and they never bothered to call me back. I called a local car repair place since the letter says they would reimburse someone else if the repair is done somewhere else. They refused to sell the place the part to them. I entered my vin number on Chrysler's web site that they provide to reimburse customers. The vin number came back as not qualifying for the service bulletin. These are their ways to avoid servicing these cars under the Service Bulletin. I have proof the car is within the mileage limit and at this time it still is. I had to replace the part myself. My wife needed the car and couldn't wait for Chrysler. There are many places online were people with the same problem were denied the repair even though they did qualify. Thanks

Filed Jul 1, 2024 · Body · NJ

The sliding drivers side door is locked shut and will not open. I have seen a notice for this vehicle model but for some reason this VIN does not show it.

Filed Oct 20, 2023 · Body · FL

Defective door-latching system; in particular: the driver side, (left side), passengers sliding door; which resulted in occupant being trapped in vehicle until we were able to extricate through other door. There is a pending class action lawsuit regarding this defect: UNITED STATES DISTRICT COURT FOR THE EASTERN DISTRICT OF MICHIGAN Case 2:21-cv-11696-JEL-DRG; failure occurred with no warning and does not allow for manual operation of the door system. This defect poses an extreme safety hazard, as it is possible that both passenger doors could be affected, essentially trapping the occupants in the mid and rear seating compartments.

Filed Sep 1, 2023 · Body · 93,000 miles · MO

The contact owns a 2016 Chrysler Town and Country. The contact stated that after arriving at her destination, she became aware that both the driver's and passenger's side sliding doors were jammed. Upon applying great force, the contact was able to open the driver's side door, and after visual inspection, she observed the sliding door was off the track with electrical wires exposed. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The dealer was also unable to open the passenger’s side sliding door. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 93,000.

Filed Jul 12, 2023 · Body · AZ

Both Passenger rear doors will not open. It is available for inspection. My passengers had to crawl over the rear seat to exit the vehicle. If for instance there had been a fire or an accident they may or may not be able to get out safely. Yes I have taken it to two dealers who wanted $ 3,000.00 to repair them. No warning lamps. No messages. They actually began closing on my passengers while trying to enter the car. The back hatch door is also presenting issues as it opens randomly mostly after a rain storm. It will also begin to close on us while we are putting our groceries into the back.

Filed Feb 21, 2023 · Body · OR

The driver side sliding door stopped unlocking, manually or automatically, it also stopped opening manually or automatically by button. I contacted my dealer who referred me to TSB 23-036-21 REV. A. They said the repair would be 100% covered by the manufacturer, however, after repair, they tell me that certain parts required for repair we not covered by the extended warranty. They replaced the actuator as the repair required, as well as the latch. The actuators are specified in the TSB, the latches are not. But the dealer insisted that to repair this they followed manufacturer instructions and the latch was necessary to fix the door. They gave me the FCA Chrysler hotline, which I called and they tell me that the latches ARE required to be replaced for repair, but that the customer is required to pay for this part which is nearly $800. If latch repair is necessary to make the van doors operate safely, it should be included in the TSB. I need help with getting resolution here.

Filed Aug 22, 2022 · Body · OH

The passenger side sliding door will not open. The lock became stuck in the locked position and it will not unlock. It cannot be unlocked by hand, the unlock button inside the van, or with the key fob. This is dangerous because nobody can get out through that door in the case of an emergency.

Filed Aug 11, 2022 · Body · 160,000 miles · TN

The contact owns a 2016 Chrysler Town and Country. The contact stated that the passenger side sliding door emits a buzzing noise. The contact had not taken the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 160,000.