1991 dodge caravan. Consumer writes in regards to anti lock brake system recall and seeks reimbursement for repairs. *smd the consumer stated he paid for the repairs on april 20, 2006 and was charged $376.73, even though a recall had been issued. The consumer experienced ABS problems again in december 2013. The consumer stated the recall letter stated if the problem occurred again, chrysler would cover any repairs. The dealer informed the consumer, he had to pay $112 for a diagnostic test, to see if the problem would be covered, under the recall. The dealer then informed the consumer, they didn't have the equipment to test his vehicle, due to the age. However, a few days later, the dealer informed the consumer, they had the equipment, but it would cost $336. The consumer declined the test. Also, the transmission, starter, fuel pump, ignition coil blocks , serpentine belt, pulleys, power steering pump, and radiator were all replaced. *jb updated 04/16/14
1991 Dodge Caravan: ABS light or ABS activating
144 of the 616 complaints about the 1991 Dodge Caravan describe ABS light or ABS activating.
- owner complaints
- 144
- of this car's complaints
- 23%
- recalls
- 3
ABS light or ABS activating by model year
What owners say
1991 dodge caravan with ABS failure problems**cc a recall was issued after the consumer had the first repair done. The consumer is requesting reimbursement.
Hello below is a copy of text on your recall site with details of this recall comments I make are below that.. Make : dodge model : grand caravan year : 1991 manufacturer : chrysler corporation the federal safety agency campaign id number : 96v099000 mfg's report date : apr 19, 1996 component: service brakes, hydraulic:antilock potential number of units affected : 321000 summary: the ABS hydraulic control unit can experience excessive brake actuator piston seal wear causing pump-motor deterioration. Consequence: if this condition occurs, the ABS function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident. Remedy: dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). The thing I find here is the term regarding piston assembly when I took my van in due to failure only the piston assembly was replaced it should be revised to include the whole unit because a accumulator made of cast iron that is connected to the unit is never replaced rust keeps entering the unit from this accumulator being it is made of a rusting metal and just keeps making the unit fail this is my second repair in 2yrs and the rust is now getting into the lines causing the rear wheels to lock in wet weather all the parts stores that even carry the unit which is few sell it as a complete unit not in pieces such as with other master cly. 's without ABS I find cast iron a poor choice for a air tank of a air pump which by nature injects air into the metal cast iron tank stainless steel would been a better choice if it would meet the tank pressures. I am seeking replacement of the entire brake system since it is now a total loss due to the rust and prefer non ABS if that's able .
Dt: the contact stated the function pressure switch in the ABS system needed to be replaced. The contact stated the vehicle did not have any braking capability. The service dealer claimed ABS brakes needed to be replaced. The service dealer attempted to the repair the problem, but did not succeed. There was a recall on the ABS piston pump and motor assembly. The recall was serviced on may 16, 2005, but did not resolve the braking problem. *ak updated 3/3/2006 - another dealer replaced the pressure switch and the problem has not recurred.
1991 dodge grand caravan experienced ABS failure.*mr ABS light illuminated. This was the second time the ABS failed. The vehicle was taken to the dealer but they didn't have the part to repair it yet.
Problems with the anti lock brake equipment on 1991 dodge caravan.*mr the vehicle ABS light illuminated while driving. The consumer has had multiple problems with the vehicle ABS system since 1997. In march, 2004 the dealer replaced the hydraulic system.
This vehicle has the same problem as stated in the federal safety agency recall 96v099000 concerning ABS brake failure. The ABS hydraulic control unit can experience excessive brake actuator piston seal wear, causing pump-motor deterioration. Dealership indicated sorry this vehicle was not included in the recall due to VIN.
Recall 96v099000 concerning ABS brake failure. Vehicle was repaired under the recall. 30,000 miles later brakes failed again. Dealer did a diagnostic test, and determined that the parts that were repaired under the recall failed, causing the vehicle to lose brake power. Dealer would not do any repairs until consumer agreed to pay for them.
The dealer refused to correct recall 96 v 099 000 because the consumer would not let them repair the ABS.
The ABS light illuminated, and the brake pedal traveled to the floor when applied.
While traveling on the highway the ABS illuminates on the dashboard. There is some braking power. Please furnish additional information dealer is aware of the problem.
While driving the ABS light illuminates, consumer states the brake pedal gets very hard, and causes fluid to come out of the pump onto the ground. Please provide any further information. Ts
Related recalls
Service brakes, hydraulic: antilock/traction control/electronic limited slip
- What is wrong
- The ABS hydraulic control unit can experience excessive brake actuator piston seal wear causing pump-motor deterioration.
- Risk
- If this condition occurs, the ABS function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident.
- Remedy
- Dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. Also the warranty on all ABS components will be extended to 10 years or 100,000 miles (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). Owners will also be reimbursed for previous ABS component repair costs.
Recall number 96V099000 · Recall details
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
- What is wrong
- The anti-lock brake system high pressure pump may be porous which will result in brake fluid leakage.
- Risk
- Fluid leakage eventually causes the loss of both theanti-lock brake system and hydraulic assist for the brake system, resulting inincreased likelihood of brake lockup and increased stopping distances, whichcould result in a vehicle accident.
- Remedy
- Replace the ABS high pressure pump and high pressure hose if the last six digits of the bar code label on the pump are between 052300 and 059262.
Recall number 92V030000 · Recall details
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
- What is wrong
- The anti-lock brake system high pressure hose may leak or detach at its crimped end fitting resulting in the discharge of hydraulic fluid.
- Risk
- Fluid discharge eventually causes the loss of both theanti-lock brake system and hydraulic assist for the brake system, resulting inincreased likelihood of brake lockup and increased stopping distances, whichcould result in a vehicle accident.
- Remedy
- Replace the ABS high pressure hose with a hose of different design and construction.
Recall number 91V191000 · Recall details
Questions about the 1991 Dodge Caravan abs
Is ABS light or ABS activating a common problem on the 1991 Dodge Caravan?
144 of 616 owner complaints about the 1991 Dodge Caravan (23%) mention ABS light or ABS activating. The model year with the most reports is 1993.
Is there a recall or service bulletin for this on the 1991 Dodge Caravan?
There are 3 recalls and 0 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 1991 Dodge Caravan
Brake failure 53Seat belt 33Transmission failure 16Door locks 13Loss of power 10Wipers 9Fire or smoke 7Power steering loss 7Stalling 7Fuel leak 6Grinding brakes 5Headlights 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 1991 Dodge Caravan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history