1991 Dodge Caravan brakes problems

Filed Aug 4, 2014 · Brakes · 87,000 miles · MD

Tl* the contact owns a 1991 dodge caravan. The contact stated that the front brake calipers malfunctioned and made the vehicle difficult to move. The vehicle was taken to the dealer, who diagnosed that the hydraulic control unit that houses the brake actuator piston and the pump motor assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was not covered under the federal safety agency campaign number 96v099000 (service brakes, hydraulic) although the recall indicated that the part would have a life time coverage. The failure mileage was 87,000.

Filed Mar 27, 2014 · Brakes, Electrical · NV

1991 dodge caravan. Consumer writes in regards to anti lock brake system recall and seeks reimbursement for repairs. *smd the consumer stated he paid for the repairs on april 20, 2006 and was charged $376.73, even though a recall had been issued. The consumer experienced ABS problems again in december 2013. The consumer stated the recall letter stated if the problem occurred again, chrysler would cover any repairs. The dealer informed the consumer, he had to pay $112 for a diagnostic test, to see if the problem would be covered, under the recall. The dealer then informed the consumer, they didn't have the equipment to test his vehicle, due to the age. However, a few days later, the dealer informed the consumer, they had the equipment, but it would cost $336. The consumer declined the test. Also, the transmission, starter, fuel pump, ignition coil blocks , serpentine belt, pulleys, power steering pump, and radiator were all replaced. *jb updated 04/16/14

Filed Feb 5, 2007 · Brakes · 49,091 miles · FL

1991 dodge caravan with ABS failure problems**cc a recall was issued after the consumer had the first repair done. The consumer is requesting reimbursement.

Filed Nov 21, 2006 · Brakes · 145,000 miles · CA

Dt*: the contact stated recall # 96v099000 for the service brakes: hydraulic: anti-lock was received. When the service dealer was called to schedule the recall repair, the service dealer informed the contact, there would be charges for replacing the accumulator plus labor costs. The manufacturer requested the receipts to be sent for review for possible reimbursement. Updated 01/10/07.

Filed Mar 20, 2006 · Brakes · 130,000 miles · IL

Hello below is a copy of text on your recall site with details of this recall comments I make are below that.. Make : dodge model : grand caravan year : 1991 manufacturer : chrysler corporation the federal safety agency campaign id number : 96v099000 mfg's report date : apr 19, 1996 component: service brakes, hydraulic:antilock potential number of units affected : 321000 summary: the ABS hydraulic control unit can experience excessive brake actuator piston seal wear causing pump-motor deterioration. Consequence: if this condition occurs, the ABS function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident. Remedy: dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). The thing I find here is the term regarding piston assembly when I took my van in due to failure only the piston assembly was replaced it should be revised to include the whole unit because a accumulator made of cast iron that is connected to the unit is never replaced rust keeps entering the unit from this accumulator being it is made of a rusting metal and just keeps making the unit fail this is my second repair in 2yrs and the rust is now getting into the lines causing the rear wheels to lock in wet weather all the parts stores that even carry the unit which is few sell it as a complete unit not in pieces such as with other master cly. 's without ABS I find cast iron a poor choice for a air tank of a air pump which by nature injects air into the metal cast iron tank stainless steel would been a better choice if it would meet the tank pressures. I am seeking replacement of the entire brake system since it is now a total loss due to the rust and prefer non ABS if that's able .

Filed Mar 20, 2006 · Brakes · 180,000 miles · MI

Dt*: the contact stated recall work was performed on the vehicle prior to the contact being aware of the recall. The manufacturer was contacted about reimbursement which they denied because the recall work was not performed at an authorized dealership. The federal safety agency recall # 96v099000 concerning the service brakes: hydraulic: antilock.

Filed Jan 13, 2006 · Brakes, Suspension · 133,000 miles · WA

Dt*: the contact stated there is a vibration in the front end and the brake pedal is pulsating. This has persisted for 3 years. The tires were replaced and realigned numerous times to correct the vibration, however the problem still occurs. The brakes were replaced 3 times, although the pulsating is currently evident. The vibration occurs around 30 MPH. When the vehicle speed increases, the vibration is less noticeable. The manufacturer has not been contacted.

Filed Aug 16, 2005 · Brakes · FL

Dt: the contact stated the function pressure switch in the ABS system needed to be replaced. The contact stated the vehicle did not have any braking capability. The service dealer claimed ABS brakes needed to be replaced. The service dealer attempted to the repair the problem, but did not succeed. There was a recall on the ABS piston pump and motor assembly. The recall was serviced on may 16, 2005, but did not resolve the braking problem. *ak updated 3/3/2006 - another dealer replaced the pressure switch and the problem has not recurred.

Filed Jun 2, 2005 · Brakes · 107,545 miles · NY

1991 dodge grand caravan experienced ABS failure.*mr ABS light illuminated. This was the second time the ABS failed. The vehicle was taken to the dealer but they didn't have the part to repair it yet.

Filed Aug 12, 2004 · Brakes · IL

Problems with the anti lock brake equipment on 1991 dodge caravan.*mr the vehicle ABS light illuminated while driving. The consumer has had multiple problems with the vehicle ABS system since 1997. In march, 2004 the dealer replaced the hydraulic system.