1991 Dodge Caravan fuel system problems

Filed Mar 27, 2014 · Brakes, Electrical · NV

1991 dodge caravan. Consumer writes in regards to anti lock brake system recall and seeks reimbursement for repairs. *smd the consumer stated he paid for the repairs on april 20, 2006 and was charged $376.73, even though a recall had been issued. The consumer experienced ABS problems again in december 2013. The consumer stated the recall letter stated if the problem occurred again, chrysler would cover any repairs. The dealer informed the consumer, he had to pay $112 for a diagnostic test, to see if the problem would be covered, under the recall. The dealer then informed the consumer, they didn't have the equipment to test his vehicle, due to the age. However, a few days later, the dealer informed the consumer, they had the equipment, but it would cost $336. The consumer declined the test. Also, the transmission, starter, fuel pump, ignition coil blocks , serpentine belt, pulleys, power steering pump, and radiator were all replaced. *jb updated 04/16/14

Filed Nov 15, 2005 · Fuel system · 189,600 miles · WA

Dt: the consumer stated that after smelling gas, he took the vehicle to a mechanic. The mechanic told the consumer to start the vehicle. He then told the consumer to shut the vehicle off. The mechanic suggested that the vehicle was not safe to drive. The fuel rail had been replaced at this time. The federal safety agency campaign id # is 00v268000 did not include the consumers VIN. *nm (12/08/05)

Filed Jul 22, 2003 · Fuel system · PA

Consumer states fuel pump has failed. Dealer notified.

Filed Mar 24, 2003 · Body, Fuel system · 100,000 miles · GA

I own both a 1991 and a 1995 dodge caravan... The 1991 has numerous problems, including a back hatch that won't stay up because the area of the frame that the shock latches into is broken due to a stress crack.. This makes it really hard trying to get things in and out when you have a baby.. The driver seat also falls backwards and does not stay in place. The gauges do not work, with no known cause... Both these vehicles are white in color and the paint is peeling in the same exact spots on both vans. It's across the hood and across the top. All I have to say is, because of these problems - I hate my vans and probably won't ever purchase another caravan.

Filed Jan 22, 2003 · Fuel system · CA

Fuel rail leaks onto super-heated exhaust manifold - extreme fire/explosion danger. This is precisely the same problem as in oficial recall of slightly later (1996 -...) dodge/chrysler minivans. Many other identically registered complaints at the federal safety agency for same year model as mine. Believe this to be a chrysler design/safety defect. Outrageous repair cost for consumer to bear the brunt of chrysler safety/design flaw. Opinion: chrysler is negligent.

Filed Mar 19, 2002 · Fuel system · AZ

While backing out there was a fuel leakage. Mechanic stated fuel rail line needed to be replaced. Also, has a newer model, and there has been a recall on fuel rail line.

Filed Jun 4, 2001 · Fuel system · AR

Filter in the fuel line sprayed fuel directly onto muffler. Vehicle has been repaired.

Filed Apr 25, 2001 · Fuel system · NY · fire

Consumer was going about 30 MPH and noticed gas gauge had dropped. Consumer started smelling gas inside of vehicle. Consumer pulled over, got out, and didn't see anything. Then, got back in. When consumer and children got back into vehicle, flames and smoke were coming out from under hood. They got out, ran across the street, and fire department put out the flames. Vehicle was totaled. Insurance company ruled that the it was a ruptured fuel line that sprayed fluid onto manifold, and that made it ignite. Consumer will contact manufacturer to file a complaint.

Filed Apr 24, 2001 · Fuel system · OH

A fuel leak occurred at the connection between a flexible fuel line from the fuel tank to where it joins a steel fuel line on the rear axle. The fuel leak was caused by failure of the crimped aluminum connector. The connector was severely corroded to the point where it broke. This allowed fuel to leak from this connection whenever there was pressure in the fuel system.

Filed Mar 22, 2001 · Fuel system · PA · fire

The faulty fuel rail caused a small engine fire, the 1996-2000 model caravans were recalled for faulty fuel rails, the consumer request reimbusement because he believes this is a design defect. Nlm