My vehicle was parked in the driveway with a car cover over it and it caught on fire. The fire appeared to have started by the driver side headlight area and quickly ignited and burnt the whole front end of the car. The fire department showed up to put the fire out and they did not see any foul play. Surveillance camera shows the car catching on fire on it own without anyone near it. The last time it was driven it was a week ago. No after market parts in the car either, it’s all stock with very low miles or 12K.
Dodge Challenger fire or smoke problems
47 of the 1,695 owner complaints about the Dodge Challenger describe fire, smoke or burning smell, most of them for the 2010 model year.
- owner complaints
- 47
- worst model year
- 2010
- typical mileage
- 33,200
Is there a fix? There are 10 recalls for this area of the car. See below
By model year
Often reported together
Stalling 8Won't start 4Loss of power 4ABS 4Warning lights 3Key fob 3Headlights 3Check engine light 3
What owners say
On Saturday 1:20am 11/15/25 DRIVING 27 MILES FROM DISTANCE VEHICLE STARTED TO MALFUNCTION ELECTRICALLY WITH INTERNAL LIGHTS QUICKLY POWER OUTAGES ON AND OFF INTERIOR LIGHTIN. dim headlights, or issues with electrical components. 11/15/25 A vehicle fire occurred, and preliminary investigations suggest a battery malfunction as the probable cause. The malfunction led to an uncontrolled thermal event within the battery system, rapidly escalating into a fire that engulfed the vehicle. Further analysis is underway to determine the specific nature of the battery failure and contributing factors.NO WARNING ADVISORY ON THE PRELIMINARY OCCURRENCE IT ESCALATED FROM FLASHING ON AND OFF LIGHTS AND STEREO TO A STIFF STEERING WHEEL AND VEHICLE COMPLETE SHUTDOWN AND RAPIDLY SMOKE COMING FROM THE INTERIOR OF THE TRUNK AND FIRE STARTED CONSUMING THE REAR END OF THE TRUNK AND VEHICLE. THIS WAS A VERY DEVASTATING AND OVERWHELMING TRAGEDY IT HAPPENED WITHIN 15 MINUTES TIMEFRAME AND FIREDEPARTMENT ARRIVED WITHIN FIVE MINUTES INTO THE CONCERNING FIRE IT ALSO TOOK AROUND AROUND A HOUR FOR THE FIREMAN TO PUT OUT THE FIRE FROM THE TRUNK OF THE VEHICLE.
* The ignition switch failed to release the key fob. I brought the car home after completing some repairs and sending the car through emissions testing to renew the plates. I made numerous attempts turning the car on and off and trying to get the key fob out of the ignition. The ignition off position would flash ACCESSORIES the same as the accessory position. I was concerned to leave the car as there maybe a short that would draw down the battery or worse ? I locked the doors and left the key fob in the ignition. * YES- available for inspection. * safety issue was is there an electrical issue that would start the car on fire ? * The diagnosis was done by my performance and high end mechanic's shop. The battery in the key bob was changed while being stuck in the ignition to see if a low powered battery was failing to send a signal. No changes. The shop did inform me later in the day that they forced the fob to the left and was able to extract it from the ignition switch. * YES, inspected and review by my trusted mechanics shop. * No signs prior to the attempted removal of the key bof at the finish of returning to my home.
I know this has probably been posted. Driving last night with the wife and I smell fuel. Then the gas gauge starts to drop from full to empty in less than 3 minutes. I pull over, the car shuts down. I see fuel on the passenger side , just in front of the tire. Get the car safely towed home. I pop the back seat and remove the access cover for the fuel pump. See picture. This is how I found the fuel line. The green locking tab was not locked. Even though theirs a green paint mark to confirm the fuel line is secure. Obviously not. The locking tab barely engages and is so easy to move to the unlocked position with no effort at all. Stellantis should be embarrassed that a vehicle left their plant in an unsafe condition. Either the locking tab was not engaged fully or in my opinion a terrible design. It should lock with some effort. With the high pressure the fuel system is under there should be a better locking mechanism. This is a poor design. My car is not modified, has only 2,000 miles on it and has never been tracked. To me a design flaw or piss poor installation tech is responsible. The car could have caught on fire and hurt someone if it was in my garage. These lines should use aircraft style fasteners for the fuel lines, especially at the top of the pump. I have seen at least 12 other instances like this online. That means there are many more. There needs to be a recall that changes the fuel pump and a much more reliable fastening and locking system. These car were and are not cheap. I’ve never complained here or anywhere. I really enjoy the car. But now my confidence in the vehicle’s safety is very much in question. When I called Chrysler roadside assistance they said I couldn’t get a two until Monday 11-3. WTH! @DodgeCares sounds like you don’t really care. The BMW dealership that I have bought two cars from where out in 30 minutes to help and get me and my car home.
The contact leased a 2012 Dodge Challenger. The contact stated that the check engine warning light was illuminated. The contact stated that while driving at 45 MPH, the vehicle stalled. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed with melted wiring. Additionally, the contact noticed smoke coming from underneath the engine. The vehicle was not repaired. The vehicle was later towed to the residence. Additionally, the contact was aware that the VIN was included in the federal safety agency Campaign Numbers: 19V018000 (Air Bags) and 17V435000 (Electrical System); however, the parts to do the recall repairs were not yet available. The dealer was contacted for the recall repair, but no assistance was provided. The used car dealer was contacted, but no assistance was provided. The manufacturer was notified of the failure. The failure mileage was approximately 140,000.
I got the car on 4/13/2025 from a Toyota dealership with about 31000 miles they told me the car fax showed the car had 2 owners a regular customer and another dealership, they also told me they change the battery but they failed to disclosed that they took the car to a body shop to fix a dent and to be repainted, by mistake they offered me the Toyota warranty 5 years or 60000 miles , on 8/10/25 while driving the car it caught on fire luckily nobody got injured , after putting the fire off the fire department told us the cause of it was an engine malfunction only after 4 months and with about 39000 miles ,from the pictures we suspect the fire started by the fuse box and now I'm looking for answers and who's responsible, the dealership, the previous owner or the manufacturer, the car got totaled.
On August 7, 2025, at approximately 11:30 PM, my 2014 Dodge Challenger caught fire in the trunk area where the battery is located. I had just parked at my location and was about to get out of the car when I noticed a strong burning smell and smoke coming from the rear. Flames were visible inside the trunk. The fire damaged the trunk interior, wiring, and surrounding components, but the battery still functioned afterward. There were no warning lights or prior issues before the incident. This poses a serious safety hazard and could have caused injury or further damage if it had occurred while driving.
The vehicle is available for inspection. The issue caused a fire under my carport and within 30 feet of a neighbor's house. The car is immobile and still at the location of the incident, it has not been reproduced or inspected. there were no warning lamps at the time of the incident. The electrical system seemed to have several issues over the past years. The passenger side tail light would burn out at least twice a year. The driver's side window would go up and down when the car was off and ran out of battery. The vehicle would allow the key fob to be locked in the car. I took it to the dealer but they were unable to determine the cause. Most recently what a mechanic thought was the starter failed twice in less than six months. Last month, I went to start the car, and it started and then turned off. I heard a pop and crackling sound, and the trunk battery was on fire.
Was driving normally going 65 mph on the highway when white smoke was emitting from inside the steering wheel. Between the dashboard and steering wheel. Engine was fine and no warning lights came on. Everything ran great except for the white smoke. I don’t know what it could be. Luckily it didn’t catch on fire
Tipman module is melting and has a burning smell and black marks where there has been spark. Fire hazard. Draws too many amps from headlights. Drivers side seatbelt won't register and seatbelt airbag light is on.
Related recalls
Electrical system: instrument cluster/panel
- What is wrong
- Chrysler (FCA US, LLC) is recalling certain 2021 Dodge Challenger vehicles. The affected vehicles do not illuminate their safety system status indicators sufficiently in both daylight and nighttime driving conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
- Risk
- Without visible safety system indicators, a driver may not receive information regarding vehicle safety, increasing the risk of injury or a crash.
- Remedy
- Dealers will re-program instrument clusters with the correct software version, free of charge. Owner notification letters were mailed on October 5, 2021. Owners may contact FCA US LLC customer service at 1-800-853-140. FCA US LLC's number for this recall is Y58.
Recall number 21V664000 · Recall details
Electrical system: instrument cluster/panel
- What is wrong
- Chrysler (FCA US LLC) is recalling certain 2019 Dodge Challenger and Charger and Chrysler 300 vehicles. The instrument cluster may not properly illuminate driver warnings. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
- Risk
- Failure of the instrument cluster to properly illuminate may prevent the driver from receiving warnings about the vehicle's systems, increasing the risk of crash.
- Remedy
- Chrysler has notified owners, and dealers will update the instrument cluster software, free of charge. The recall began April 8, 2019. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is V32.
Recall number 19V203000 · Recall details
Electrical system: wiring: front underhood
- What is wrong
- Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
- Risk
- A vehicle stall can increase the risk of a crash.
- Remedy
- Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is U87.
Recall number 18V524000 · Recall details
Electrical system: wiring
- What is wrong
- Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
- Risk
- If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
- Remedy
- Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Recall number 18V332000 · Recall details
Electrical system: alternator/generator/regulator
- What is wrong
- Chrysler (FCA US LLC) is recalling certain 2014 Dodge Challenger, Charger, Durango, Chrysler 300, and Jeep Grand Cherokee vehicles equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
- Risk
- If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
- Remedy
- Chrysler will notify owners, and dealers will replace the alternator, free of charge. The recall began December 15, 2018. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is T75.
Recall number 17V741000 · Recall details
Electrical system: alternator/generator/regulator
- What is wrong
- Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
- Risk
- If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
- Remedy
- Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is T36.
Recall number 17V435000 · Recall details
Electrical system: instrument cluster/panel
- What is wrong
- Chrysler Group LLC (Chrysler) is recalling certain model year 2015 Dodge Challenger vehicles manufactured June 30, 2014, to October 8, 2014. In the affected vehicles, the instrument cluster may become inoperative. This could cause the gauges to oscillate at zero and the Vehicle Theft Alarm could remain illuminated. Thus, the affected vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) No. 101, "Controls and displays."
- Risk
- If the instrument cluster becomes inoperative, it can increase the risk of a vehicle crash.
- Remedy
- Chrysler will notify owners, and dealers will install a software enhancement, free of charge. The recall began on December 15, 2014. Owners can contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is P74.
Recall number 14V749000 · Recall details
Electrical system: alternator/generator/regulator
- What is wrong
- Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
- Risk
- If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
- Remedy
- Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is P60.
Recall number 14V634000 · Recall details
Electrical system: wiring: front underhood
- What is wrong
- Chrysler is recalling certain model year 2013 Dodge Challenger vehicles manufactured from December 3, 2012, through January 24, 2013 and equipped with a V6 engine. The battery positive cable at the starter motor may experience an electrical short circuit to ground.
- Risk
- A short circuit could lead to a vehicle fire.
- Remedy
- Chrysler has begun notifying owners and they are being advised to immediately refrain from driving their vehicles and to contact their dealers. Chrysler Group further advises affected owners not to park their vehicles in, or near, any structures. Dealers will replace the under hood starter cable assembly, free of charge. The recall notification began on March 22, 2013. Owners may contact Chrysler at 1‑800‑247‑9753.
Recall number 13V103000 · Recall details
Electrical system: ignition: module
- What is wrong
- Chrysler is recalling certain model year 2010 chrysler 300, dodge challenger, charger, jeep commander, grand cherokee and dodge ram vehicles. These vehicles may have been built with a wireless ignition node (win) module exhibiting a binding condition of the solenoid latch.
- Risk
- The result of the defect could lead to a condition where the key may be removed from the ignition switch (win module) prior to placing the shifter in park. This could result in the potential for unintended vehicle movement and could increase the risk of a crash.
- Remedy
- Dealers will inspect and replace the win module free of charge. The safety recall is expected to begin on or before august 23, 2010. Owners may contact chrysler at 1‑800‑853‑1403.
Recall number 10V200000 · Recall details
Questions about the Dodge Challenger fire or smoke
Which Dodge Challenger years have fire, smoke or burning smell problems?
The model years with the most reports are 2010 (8 complaints), 2013 (8 complaints) and 2012 (6 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used Dodge Challenger?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history