2006 Dodge Charger engine problems

Filed Aug 26, 2026 · Engine · CT

I have a beautiful 2006 dodge daytona charger with 5.7L Hemi engine that has failed with 170,000 miles. It has been impeccably maintained with on time oil changes using Mobil 1 synthetic oil. The problem is the roller on the lifter for cylinder # 4 locked up and wiped the lobe off the camshaft...So now theres a misfire and the engine needs a rebuild! I know nothing lasts forever BUT.... most engines now a days make 200,000 no problem and most go well beyond that if maintained properly. I was expecting the same for this engine but This well-known problem finally struck me... I have had my lifetime warranty denied because the cost of the engine exceeds the value of the car so there lifetime warranty is a very mis leading and really an out rite lie!!! Chrysler/Stellantis knows all about these hemi engines failing but is leaveing its customers holding the bag! I think you should do an investigation do the huge number of failures!!!

Filed Mar 28, 2026 · Engine · WA

I filled up my gas tank on way home from work in [XXX] . Once i got on on ramp to get on freeway my 2006 dodge charger stalled. I lost all power and barely was able to get to side of on ramp. I waited a couple minutes after shutting car off. Then it started up again for me to get home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 18, 2025 · Engine, Transmission · 111,415 miles · DE

The contact owns a 2006 Dodge Charger. The contact stated while idling at the traffic light, the vehicle stalled. The contact stated that the failure also occurred while driving at various speeds. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The contact stated that the vehicle failed to restart on several occasions and was towed to the residence. The vehicle was taken to the dealer, where DTC: U0100 and P0700 were retrieved. The dealer flashed the computer; however, the failure persisted. The vehicle was taken to an independent mechanic, were the same DTC were retrieved and the failure was related to a loss of communication with the PCM and the Transmission Control Module. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 111,415.

Filed Mar 15, 2025 · Engine, Fuel system · CO

My 2006 Dodge Charger stalls after refueling, and now stutters when driving as if not getting fuel. I have noticed when attempting to break and stopping at stops this is happening more often. The car shuts down and could cause a accident. After researching this issue I found that this has been addressed already under investigation number PE13-016 by the federal safety agency.

Filed Nov 9, 2023 · Engine, Fuel system · IL

Valve in the top of the tank to release vapor through the purge system is stuck open allowing fuel in the system, is available for inspection. Car stalls while driving and at stops, stalled infront of ambulance. Has not been reproduced of confirmed by dealer, but it has happened everytime i fully refuel the car. Has not been inspected. No symptoms or warnings prior to issue occurring.

Filed May 10, 2023 · Engine, Fuel system · MD

On 3/10/2023 my vehicle suddenly starting trembling and shaking profusely! It terrified me severely. I immediately called my mechanic and it was towed in to be repaired. I was told it needed a tune- up. Towing, 3-Direct Ignition coils replaced, 6-spark plugs replaced and 1- fuel injection plenum gasket set replaced. Four weeks later on 4/16/2023 a warning sign of a backwards meeting parenthesis with a lightening bolt between to the two backwards parenthesis showed up on my warning lamp-Electronic Throttle Control (ETC) Indicator symbol; causing my vehicle on shake, jump and stall as I was driving on 29S heading toward 70W towards Baltimore to get home. I was able to drive to side of the road and my car completely stopped. A the horrific sounds of the traffic wizzed by me and my 12 year old child, I immediately called AAA, as we were in danger and severely terrified. We were finally picked up after 3 long hours!!!!! My car was the towed up the street from my home because the huge tow truck was unable to get directly in front of my door at that late hour. As I called AAA back the next morning to have my car towed to my mechanic shop, I was told I could only get 1 tow/ breakdown. I was totally in disbelieve after all we endured the evening/ night before. After explaining to a supervisor at AAA, she agreed that we had such a horrible experience the night before and adjusted the policy to accommodate my vehicle to be towed to my mechanic for repairs. This time, my fuel pump needed to be replaced and it has been. My vehicle still feels hesitate in its acceleration and as of today my engine light is on on my warning panel. I have been contacted by a NHTS recall team agent and have been scheduled for an appt

Filed Nov 29, 2022 · Engine · PA

Car stalled after refueling, restarted pulled out stalled again a minute later. No warning lamps. Able to drive 15 miles home, parked it. Investigation # PE13-016

Filed Sep 13, 2022 · Engine, Fuel system · 136,004 miles · TX

The contact owns a 2006 Dodge Charger. The contact stated while driving approximately 70 MPH, the vehicle started shaking, then lurch and the vehicle stalled. The contact stated that the vehicle lost power steering and braking functionality. The contact was able to coast the vehicle off the side of the road. The contact stated that the check engine, ABS, and the throttle control warning lights were illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the fuel tank and fuel system needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was again exhibiting the same failure. Additionally, the failure was more frequent and that there were days when the contact could not keep the vehicle from stalling after starting the vehicle. The manufacturer had not been informed of the failure. The failure mileage was approximately 136,000.

Filed Aug 29, 2022 · Electrical, Engine · WI

Car will stall and not start after filling with gas. After awhile car will run but shut off randomly. This can happen while driving. Car has been stuck at intersections and will stall even doing highway speeds. All lights will appear on dash engine car will lose all power. Small ding before it dies.

Filed Jul 31, 2022 · Engine, Fuel system · OH

After filling up the car with fuel (93 octane) the car stalls after a couple of minutes. This has caused unsafe situations as the car has stalled in the middle of intersections and on the road. This has happened consistently after filling up. The car does not start immediately after stalling. After a couple of minutes post stall, I am able to restart the car. At times, the car studders while moving. This all happens after topping off with fuel. The vehicle has approximately 106,000 miles.