Tl* the contact owns a 2005 dodge durango. While the contact was filling the fuel tank, fuel spilled out. The contact was not able to complete filling the tank. There were no warning indicators illuminated. Bender chrysler dodge jeep (3400 mabry dr, clovis, nm 88101, (575) 762-4511) replaced the fuel check valve. The manufacturer was notified and did not assist. The failure mileage was 190,000.
2005 Dodge Durango fuel system complaints
Page 3 of 26: complaints 41 to 70 of 751, newest first, as owners wrote them.
Tl* the contact owns a 2005 dodge durango. When filling the fuel tank, the fuel tank valve failed and caused fuel to spill out. The vehicle was taken to jstar motors (8200 crystal dr, anaheim, ca 92807, (866) 906-0586) where it was diagnosed that the fuel tank needed to be repaired. The vehicle was not repaired. The contact stated that the vehicle was experiencing the same symptoms listed in the federal safety agency campaign number: 09v003000 (fuel system, gasoline). The failure mileage was 145,000.
When attempting to re-fuel, immediate backflow/discharge of fuel causing hazard. This occurs even when fuel tank is below 1/4 tank level. Re-fueling must be done at a very slow rate to reduce number of backlow discharges that occur during a single re-fueling session.
When refueling the vehicle at the gas pump and the tank becomes full and the gas pump clicks fuel spews out of the gas tank opening.
Tl* the contact owns a 2005 dodge durango. The contact stated that the fuel tank leaked when attempting to top off the fuel tank. In addition, the vehicle stalled often, would not restart, and the headlights failed to illuminate. The vehicle was taken to gettle dodge ram and chrysler (2323 tamiami trail, punta gorda, fl 33950, (941) 347-6706), but the cause of the failure could not de determined. However, the dealer replaced an unknown fuse in the engine and the vehicle restarted. The manufacturer was not informed of the failures. The failure mileage was 130,000.
I had taken my dodge durango for a recall on air bag and they replaced.. Also mention that when I am filling up my dodge durango with fuel it wouldn't automatically stop when tank was full caucusing fuel to splash all over including me they indicated to me that it was a recall on my durango they ordered the parts and two days later called me and said we are not going to fix it. Dealer was davis moore dodge in witchita, kansas
My car caught on fire from the hood area (I have photos) and air bags never deployed . I took my car in and the air bags were replaced but never deployed and car is a total lost due to fire.
Tl* the contact owns a 2005 dodge durango. The contact stated that the fuel overflowed without warning. The vehicle was not diagnosed by an independent mechanic and a dealer. The dealer (pearson chrysler jeep dodge, 8250 w broad st, richmond, va 23294, (804) 965-0300) stated that the vehicle was not included in any recalls. The vehicle was not included in the federal safety agency action number: rq08005 (fuel system, gasoline). The manufacturer issued two fuel system recalls and three fuel system tsbs. The manufacturer was notified of the failure and provided no solution. The approximate failure mileage was 60,000.
Large amount of fuel spits out of fuel inlet tube at the end of refueling. Existing recall that address this issue does not cover enough vins.
Owner of 2005 dodge durango with faulty check valve in fuel filler tube. Vehicle VIN currently not included in chrysler recall h45, (the federal safety agency 05v034000). Upon fuel fill up, vehicle overflows substantial amount of fuel from filler neck onto side of vehicle and ground on every fuel hose cut off.
"takata recall" I'm handicap, trying to get airbags replaced, keep getting run around, dealers no help, finally one dealer says parts are on order , but still no results, have been over 1 year, I'm still recieving recall letters in mail, frustrated, need vehicle fixed,
When filling the gas tank fuel spits out everywhere resulting in a fire hazard and personal safety issues for the person fueling the vehicle. This had been an issue since I purchased the vehicle in february. I contacted the family of the previous owner who stated this has always been a problem.
Tl* the contact owns a 2005 dodge durango. The contact stated that the check engine indicator illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that there was an emissions leak and the fuel tank needed to be replaced. The vehicle was taken to mt. Ephraim chrysler dodge ram (620 n black horse pike, mt ephraim, nj 08059 (856) 931-2000) where it was diagnosed that there was a very small evaporative emission system leak. The dealer stated that the vehicle needed a new o-ring, lock ring, and the fuel tank needed to be replaced. The contact referenced the federal safety agency campaign number: 09v003000 (fuel system, gasoline) and stated that the vehicle was previously repaired twice; however, the failure recurred. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 112,680.
I stopped at the gas station to put gas in my 2005 durango. When it was full the gas sprayed out all over my leg and boots. When I looked for a recall there was one but not for my VIN. Because of this my finder is rusting out and ever durango I see the same make as mine has the same rust spot. I don't understand why it isn't part of the recall. The gas overflow and the rust spot.
My dodge durango is filled with gas it will overflow. The gas pump kicks off and then gas comes spraying back out and spills gas down the side of the car. It will continue pushing gas out for about 30 seconds to a minute. I'm afraid to fill the tank to capacity due to the fire danger or explosion.
Every time I fill my tank, fuel burps back out and spills all over the side of the SUV and on the ground. I called dodge, and they said the recall for this was already performed, and that repairing it will cost me around $900! If a recall, has been fixed, and still the problem persists, then the recall should be re-performed!
Upon filling the gas tank since the first time on june 15, 2017, and every time since then, the fuel always spits back, and all over the place, including on the gas attendant, upon any one walking by, on the car, and of course, on the ground. It may or may not be the fuel tank inlet check valve (fuel filler tube), but the dangerous safety issue remains. I have read that 20,000 durangos have been recalled from 2005 for this issue, but for reasons unknown, even though my 2005 durango also has this dangerous safety problem, I am told by the dealer that my 2005 durango has not been recalled. If for some reason it has not been recalled, it obviously should be recalled because it has the same exact issue that the other 2005 durangos have been recalled for. So why not mine?
My 05 dodge durango, which I am the only owner of, overflows gas while filling up the tank. I was told it is a recall, I called the local dealership to schedule an appointment to fix it, I was treated with absolute disrespect and was told my car was already fixed through the warranty, I assured them I was the only owner and it was never fixed, they again told me it was and they would not pay for it to get fixed again even if it is the same issue that the recall was for. I have had the gas overflow and spray all over me multiple times, including one time while I was holding my infant child. This is not ok and so beyond unsafe!!! It clearly wasn't fixed and I would like it fixed before someone gets hurt! The vehicle was off and parked. I also know multiple people with this same model and theirs do the same thing and all have rust eating through their vehicles on the panel under their gas tanks, was fixing that also in the recall since it is clearly due to the gas overflowing?
After fueling, when tank is full, it will begin dumping (spitting) fuel from gas filler tube. Vehile is turned off and stationary when this occurs. This occurs at every fill up.
A recall that supposedly happened before I purchased the vehicle is showing the symptoms of why it was recalled to begin with. The recall #e01, the federal safety agency #05v‑034 which involves the fuel filler tube inlet check valve. Every single time I try to put gas in my durango, the fuel spurts out at me... Even when I go super slow in filling it up. This has been going on for at least 2 years now. The area around and under the gas cap is now all corroded and rusted. I recently took some pictures during the fill to show all the gas on the ground and on the car. I took this to dodge city in brookfield, wi and they could not fix the problem without charging me for the work (almost $600). In researching this problem, I see many people with these durangos have this issue but chrysler will not fix it without charging the end user.
Tl* the contact owns a 2005 dodge durango. While attempting to fuel the vehicle, the contact was unable to insert the entire fuel pump nozzle into the fuel filler neck. The fuel filler neck would only allow a certain amount of fuel to enter at a time. The vehicle was taken to the dealer where it was diagnosed that the fuel filler neck and fuel tank parts needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was made aware of the failure. The failure mileage was 129,494.
Fuel tank overflows every time when fueling. I try to pump as slowly as possible but fuel still runs down side of truck when about 3/4 full every single fill-up. Last happened previous saturday. This has been occurring last 15,000 miles. Local dealer claims nothing is wrong.
Tl* the contact owns a 2005 dodge durango. The contact stated that there was a recall regarding the fuel tank filler inlet check valve. The contact's vehicle was not included. The contact stated that fuel leaked out of the fuel tank after filling the tank. The contact noticed a strong odor of fuel while driving. The contact took the vehicle to a dealer. The manufacturer was notified of the issue. The failure mileage was 156,000.
Engine cuts off at any speed, but especially at low idle, when nearing an intersection, or turning the vehicle at a lower, safer speed. This happens on highway, residential streets, stoplights, basically anywhere at anytime.
Tl* the contact owns a 2005 dodge durango. While attempting to refuel the vehicle, there was evidence of a fuel leakage coming from the filler neck of the fuel tank. The contact stated that the failure recurred on every fuel fill up. The vehicle was not diagnosed or repaired. The vehicle was not included in the federal safety agency campaign number: 09v003000 (fuel system, gasoline). The manufacturer was notified of the failure. The approximate failure mileage was 238,990.
When filling the gas tank a large amount of gasoline spits out after the fuel nozzle clicks off. I first thought is was a defect with the fuel nozzle. But it continues to happen each time I fill up. This is very dangerous and could cause serious injury or death in the event of a fire or explosion. There are several videos on ytube which clearly show this problem. When this occurs the vehicle is stopped at the service station with the engine and ignition is off. I have researched and found the chrysler has a recall on this problem but VIN is not included. The recall should include all vehicles that have this problem. Pleas advise on what can be done to get chrysler to rectify this dangerous problem at their expense. Thank you. This problem first occurred in november 2016 and has continued each time I fill up.
Tl* the contact owns a 2005 dodge durango. The contact stated that when attempting to refuel the vehicle, fuel leaked from the gasket once the fuel level reached half a tank. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 24,000.
Everytime I fill the tank up it spits fuel back out at me.
Reason for filing a vehicle safety complaint is as follows; every time I have tried to fill-up my gas tank on my 2005 dodge durango, the gas not only starts to shoot out of the tank itself, but also all over my truck, myself and all over the floor. This happens each time I fill my SUV regardless of the gas station I go to.
Fuel tank overflows when being filled- doesn't auto stop the pump like it should. This happens whenever the car's gas tank is filled unless the amount of gas needed is estimated lower and the pump is stopped manually.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Dodge Durango?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history