2006 Dodge Grand Caravan engine problems

Filed Nov 28, 2025 · Engine · 122,000 miles · NC

The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle idled roughly, jerked and stalled while driving. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed with power train failure. The vehicle was taken to the dealer, where the contact was informed that the vehicle was missing the Exhaust Gas Recirculation (EGR) valve. The contact was provided DTCs: P0403 and P0404. The vehicle was not repaired. In 2019, the vehicle was taken to a tire business and the EGR valve was installed on the vehicle. The failure was progressively worsened, and the vehicle was no longer being driven. Upon further investigation, the contact found information on various auto websites indicating that the vehicle was manufactured in Canada and imported to the United States. The contact was the second owner. The contact found information on other auto websites that stated that the EGR valve was removed from the vehicle, and it was removed in stages. The manufacturer was notified of the failure. The contact was informed that the VIN was not under recall. The failure mileage was approximately 122,000.

Filed Nov 14, 2019 · Engine · NY

Tl* the contact owns a 2006 dodge grand caravan. While driving 45 MPH, the oil pressure and an unknown warning indicator illuminated when the brake pedal was depressed. The vehicle was taken to an independent mechanic, but the failure could not be duplicated. On november 9, 2019, while driving 55 MPH, when the accelerator pedal was depressed, the vehicle failed to accelerate. The vehicle was losing speed, but was able to be pulled over to the side of the road. In addition, the steering wheel became difficult to turn. The vehicle was unable to be driven. The contact called the police due to her disabled husband being in the cold for over two hours. A police report was filed. He was transported to the hospital, but there were no injuries or medical attention needed. The vehicle was towed to the contact's residence and then towed to an independent mechanic. The contact was informed that there was an oil leak in the engine and the engine needed to be replaced. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer was notified of the failure. The failure mileage was unknown.

Filed Oct 15, 2018 · Engine, Fuel system · 95,600 miles · NY

I've taken the vehicle to pepboys twice because although the gas gauge was working, the vehicle would click the gas nozzle off and would not accept fueling. Pepboys replaced the in-tank pump as a remedy twice. Dodge/chrysler said it was the breather tube. Who's right?

Filed May 13, 2015 · Engine · 141,000 miles · VA

Tl* the contact owns a 2006 dodge grand caravan. While driving at 35 MPH, the vehicle stalled. The contact was able to restart the vehicle. The vehicle was not diagnosed or repaired. The failure recurred on numerous occasions. The manufacturer was not notified of the failure. The failure mileage was 141,000.

Filed Apr 3, 2015 · Engine · 40,000 miles · WI

After filling fuel tank, pulled into traffic and the van stalled 30 seconds later. Was able to pull out of traffic and restart. This happens now every time the fuel tank is filled. Within a minute or two of leaving the gas station, the engine will at least hesitate and many times stalls completely.

Filed Feb 12, 2015 · Engine, Fuel system · 106,000 miles · NE

After fueling, the vehicle with surge and often stall with need for restart. Very frequently it does this when taking off from a stop sign which can cause a stall in the middle of an intersection.

Filed Feb 1, 2015 · Engine, Fuel system · 84,800 miles · IL

After filling up with gas engine stalled approximately 1/2 mile from the gas station. Had to coast to side of the road without power steering. Placed engine in park, turned of key and restarted. Engine ran rough had to depress accelerator for additional gas. Once restarted engine ran fine for the rest of the trip. This same problem also occurred in early january 1/03/2015 after filling up with gas. Not only is this an inconvenience, but very dangerous in heavy traffic scenarios.

Filed Jan 2, 2015 · Engine · MN

Engine unexpectedly stalls shortly after refuel.

Filed Jan 2, 2015 · Engine, Fuel system · 105,000 miles · VA

Investigation: dp 14-002; prompted by: defect petition; date opened: 09/05/2014; investigator: [xxx]; reviewer: [xxx]; approver: [xxx]; subject: engine stall after refueling. Please include me in the above mentioned complaint/investigation # dp 14-002. After refueling, my engine stalls about 1 to 2 minutes after starting almost every time I fill-up with fuel. When the fueling nozzle trips for the first time, I do not attempt to continue adding more fuel and possibly overfilling the fuel tank. I have been caught in heavy traffic at times with the engine stalling and it takes 2 to 3 attempts to restart the vehicle. This is very dangerous! Now after refueling, I pull away from the pumps and park out of the way and allow the engine to stall. After attempting to restart several times, the engine will misfire for about 30 to 45 seconds, then the engine will smooth out and run fine until the next refueling. I want to thank you in advance for all of your help in this matter. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Nov 21, 2014 · Engine, Fuel system · 220,000 miles · MI

Over the last several weeks my 2006 dodge grand caravan with a 3.8 liter engine will stall out several times after refueling. It will restart & stall several times before the problem seems to rectify itself. All power assisted steering is lost and the vehicle becomes difficult to steer safely. Power braking is also affected. There have been a couple of occasions where I have been turning into traffic and had the vehicle stall. One time I was unable to complete the turn and stay in my lane. On one occasion I breached the lane to my left. While traffic was traveling in the same direction I was, another motorist had to slam on the brakes to avoid hitting me.