2006 Dodge Grand Caravan: check engine light

Filed Nov 28, 2025 · Engine · 122,000 miles · NC

The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle idled roughly, jerked and stalled while driving. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed with power train failure. The vehicle was taken to the dealer, where the contact was informed that the vehicle was missing the Exhaust Gas Recirculation (EGR) valve. The contact was provided DTCs: P0403 and P0404. The vehicle was not repaired. In 2019, the vehicle was taken to a tire business and the EGR valve was installed on the vehicle. The failure was progressively worsened, and the vehicle was no longer being driven. Upon further investigation, the contact found information on various auto websites indicating that the vehicle was manufactured in Canada and imported to the United States. The contact was the second owner. The contact found information on other auto websites that stated that the EGR valve was removed from the vehicle, and it was removed in stages. The manufacturer was notified of the failure. The contact was informed that the VIN was not under recall. The failure mileage was approximately 122,000.

Filed Jun 18, 2014 · Engine, Steering · 5,758 miles · IL

For no apparent reason, the engine shuts off while driving. The clock remains on, but accessories such as the heater also shut off, and I have no power assist with steering. So far, it's happened within 5 minutes of start-up; the outside temperatures were below freezing, but the engine has not always been cold. 1/17/07 approx. 5 min. After I'd been driving, at about 30mph, I realized the noisy fan for the heater turned off. I thought maybe the new van has a feature I didn't know about, where it reaches a set temperature then shuts off automatically? Then I realized the radio had also gone quiet. I tried to accelerate but it wasn't responding, so I went to pull off on the shoulder and discovered I didn't have power steering, either. Fortunately, I was able to brake. I turned the key to the off position, restarted the van, and it seemed to work fine. At no time did I see a check engine light. 1/18/07 I had driven to a gas station, turned the van off to fill the tank, and restarted it a few minutes later, to drive away. I accelerated about 5 feet before the van turned itself off again. I stopped, moved the key to the off position, restarted it, and went on my way. 1/24/07 I backed out of the garage, but after I accelerated in reverse, about 10 ft. Down the driveway the van turned itself off again. Other days I had the heater/accessories running, but this time nothing else was turned on. The clock remained lit, so it doesn't seem like a battery issue. I turned the key to the off position and restarted the van, resumed my drive, and made an appointment with the dodge dealership under warranty. They said there were no computer codes showing; they drove 17 mi. But couldn't duplicate the problem. Since then, the van has only shut off by itself once more when my spouse was driving, but now it seems like a probable ignition switch safety issue to investigate.

Filed Mar 7, 2014 · Electrical, Engine · 70,867 miles · NC

Tl* the contact owns a 2006 dodge grand caravan. The contact owns a 2006 dodge grand caravan. The contact stated there was an egr and electrical problem that recurred. The engine light illuminated when she was driving on multiple occasions. The rear right passenger door would not lock or close properly. The left brake light and left turn signals were repaired multiple times. The failure was diagnosed by an independent mechanic. An independent mechanic diagnosed that the egr valve system, the left brake light, left turn signal light, front wipers, front brake pads, and rotors needed to be replace. The vehicle also needed a major tune up. All of the repairs were made minus the egr valve system and the rear passenger side door which the dealer was unable to repair. The manufacturer was notified of the failure. The approximate failure mileage was 70867.

Filed Feb 6, 2012 · Airbags, Body · 29,900 miles · CA

My 2006 grand caravan has had problems almost since I bought it in 2007 (it had 18,000 miles when I bought it). It now only has 68,000 miles on it. My drivers side electric door does not operate when it is warm outside (29,000 miles). The passenger side axle broke and had to be replaced (65,000 miles). When it rains my power steering goes out periodically (65,000 miles) . My engine light is on (haven't taken it in to check it yet) (66,000 miles) and now my airbag light is on (68,000 miles). Also I have replaced the battery and still have problems starting it. It clicks clicks clicks like a hundred times then eventually it starts.

Filed Dec 30, 2011 · Transmission · 44,000 miles · FL · crash

Tl* the contact owns a 2006 dodge grand caravan se. The contact was driving 20 MPH when the engine stalled while attempting a left turn. The vehicle also jerked and the brakes locked causing the vehicle to crash into another vehicle. The check engine and transmission warning lights illuminated intermittently prior to the failure. There were no injuries as a result of the crash but the police were contacted and a report was filed. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure and the current mileages were 44,000.

Filed Jan 13, 2011 · Airbags, Engine · 5,089 miles · OH

Back rear window imploded for the second time(first time 2009, second time 2010), nobody seems to have an answer for why this happens other than it was cold and snowy outside so the weather must have caused this to occur, (that is what they say) my family was in the van in the driveway getting ready to leave so I know for a fact that "nothing" went thru the window just a major defect of dodge. Numerous issues with this van starting when van had 5000 miles, air bag sensor on, sliding doors do not work properly, loud sound from engine, tie rods need replaced for third time, control arm broke, locks make a whiny sound, check service engine light on told 3 times that we needed new spark plugs . Really at 30,000 miles. We changed them, light still on today. After an inspection of van now dealer sates that the alternator, water pump, serpentine belt, egv valve, valve gasket, all needs replaced and the light on had nothing to do with spark plugs, go figure. I have sent dealership and chrysler letters in regards to my safety concerns. This would be my fourth time calling chyrsler about major issues. They lack customer service and nothing ever done. We purchased new and van is now 5 years old with same and new problems since 5000 miles, now has 77,000. I will not be purchasing a dodge van again!!

Filed Feb 20, 2010 · Body, Brakes · 27,803 miles · SC

Our 2006 dodge grand caravan with less the 28,000 felt like it would not fully stop when hitting the brakes. I already had the front brakes done and take it to the dealer routinely for oil change and inspection. So I thought it was the tires since they were greatly worn (which is hard to believe @ this mileage) we changed all 4 tires. When we took it in to the dealer for an oil change and to get the automatic door failure looked @ they found the rear brakes were completely worn out and when they went to change the pads and machine the rotors it was so bad that everything started braking on them . Mechanics own description on receipt " ck. Brakes are scrubbing in rear rotors were rusted to hub. Pins for parking brake shoes to backing plate broke when taking off. Replaced brake pins & 2 broken wheel stubs. Chrysler has no respect for customers safety. Tires and brakes are worthless, automatic doors malfunction all these are safety issues! Not to mention there cars are lemons water pump broken, issues with air bag, engine light on (5 times) and air conditioning all this with less then 28,000 miles on the car. When is government going to stop giving these thieves bail out money and going to dedicate time to keeping us safe and not allowing car manufactures to rip us off! I am a mother of 4 and fear for my family's safety not to mention that these rip offs really hurt family's financially.

Filed Apr 4, 2009 · Steering · IA

Maintained oil changes & at 14670 mi did 15000 mile service/maintenance kit; 3/6/08-20565 miles,leaking steering rack, under warranty, gear assembly power steering replaced & checked brakes for noise but no repair of them; 3/11/08-20740 miles, ses light is on & just replaced rack & pinion, cause=leak detection pump failure,pump natural vacuum leak detection, emissions,under warranty; 5/12/08-22282 miles, checked brakes for noise, replaced front brake pads & rotors,I paid & reflash for harsh 1-2 @/or 2-3 shift so reflashed PCM per tsb 21-018-07 for harsh shift, no charge but don't know if it was b/c of warranty; 9/09/08 25192 oil change & on 9/19/08 25562 miles ck engine light on & van died twice while driving, cause valve exhaust gas recirculation control so replaced egr valve, covered under warranty; 10/13/08 26324 miles, brakes squeaking, clean & adjusted brakes; 10/31/08 26788 miles,breaks squeaking, replaced front brake pads,under warranty; 1/13/09 28092 miles replaced right faulty right sliding door track,under warranty; 2/2/09 28463 miles replaced battery b/c battery failed vat test & did oil change; 2/20/09 28945 miles did 30k service said will need rear brakes soon had no choice but to get the extended warranty due to all the time spent at the dealer. Reported all problems to chrysler but all they did was notate it but doesn't appear are going to do anything about all of the issues I had. They said, well the car was repaired. No one should have to be at a dealer this many times &so frequently especially since I only avg over 9000 but less than 10000 a yr. 3/30/09 car turned off by itself at stop light, I turned it on, van shook, gas pedal wouldn't move, turned on &off a couple of times &kept shaking &pedal wouldn't move &then finally it stopped shaking& I drove off. I set up appt & was sch for 2 days later but was able to drive the car so I cancelled & was told to bring in if happens again. Approx incident date is date of 1st issue since multiple issues.