2016 Dodge Grand Caravan engine problems

Filed Sep 30, 2026 · Engine, Transmission · 138,000 miles · CT

The contact owns a 2016 Dodge Grand Caravan. The contact stated that while driving at various speeds and attempting to accelerate, the vehicle hesitated and jerked slightly before accelerating. The check engine warning light was illuminated. The vehicle was taken to a certified mechanic, and the vehicle was diagnosed with transmission pump failure. The contact was informed that transmission pump needed to be replaced. The mechanic declined to repair the vehicle after discovering the federal safety agency Campaign Number: 16V461000 (Power Train) for the issue. The mechanic referred the contact to the manufacturer, who was informed of the issue and confirmed that the VIN was not included in a recall. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 138,000.

Filed Jul 27, 2026 · Engine · 140,000 miles · MA

The contact owns a 2016 Dodge Grand Caravan. The contact stated that while operating the vehicle, there was an abnormal knocking sound coming from the engine compartment, with the check engine warning light remaining illuminated. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet contacted. The failure mileage was approximately 140,000.

Filed Mar 25, 2026 · Engine, Seats · WA

1) At D/S Stow and Go seat malfunctioned and was repaired by CarMax Service Center Jan 2023 - 2) Around 97,000 so - Engine started ticking on or about JUL/SEP 2023, enstate Lloyds Automotive in Spokane Valley replaced out engine due to manufacture defect in Oct 2023. 3) At 103,672mi - P/S stow and Go seat was repaired for same issues as D/S stow & Go Seat by Lloyds Automotive Oct 2023 when engine was replaced out. 4) Around 116,000mi the Transmission was flushed when I got the oil changed because I noticed jerking shifting at times, this was Aug 2024 there was no check engine or diag faults. 5) Around 132,720 Fell under CXLHX982 / CXLHX981 Actuator Sliding Door D/S & P both repaired and Transmissioned serviced again because my van started stalling out at stops and the jerking happened again no check engine or diag faults 6) Around 138,000 - D/S Sliding door hatch pin repair by Coos Bay Area Dodge. On 24Mar2026 - Around 142,000mi my transmission overheat warning came on and my van would not go any faster than 45 to 50mi, the RPMs went from 1.5 to 4 to 5 then 7 and back down, I immediately pulled over and sat for about 40min turned my van back on there was no overheat warning so I drove around 50mi per hour in the emergency lane to the next exit which was Hood River, Or and trailer towed my van from Hood River, Or to AAMCO, North Spokane Wa for transmission service. - I believe my vehicle 2016 Dodge Grand Caravan R/T model - transmission was built with some underlying transmission serious safety defects and should have been recalled and a part of Part 573 Safety Recall Report 16V‑461. My vehicle malfunctioning could have caused an accident if not for my quick thinking that day and keeping my vehicle maintained at a high standard. I do keep all my service records.

Filed Dec 16, 2025 · Engine · 85,000 miles · PA

The contact owns a 2016 Dodge Grand Caravan. The contact stated that while driving 55 MPH, the contact's husband smelled an abnormal burning odor coming from the front of the vehicle. Upon inspection, both the contact and her husband noticed that there was an oil leak. The vehicle was taken to an independent mechanic, where it was diagnosed that the oil filter housing had melted and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was 85,000.

Filed Oct 28, 2025 · Acceleration, Engine · NY

while driving the engine light came on within 10 minutes the car started jumping in place and then within 5 minutes completely would not go in any direction forward reverse or neutral and just revved the torque locked up the transmission quit completely did not even give me time to pull over and access the issue was 7 min from home when completely quit

Filed Oct 24, 2025 · Engine · CO

Head gasket and head failure at 86000

Filed Oct 7, 2025 · Engine, Fuel system · LA

Today, I was driving my van to work, and I stopped at a stop sign, went to go, and the van made a horrible clunk noise and wouldn't drive. I shifted through the gears, and each one made the van shake hard. I purchased this van 2 weeks ago from a used car lot. Earlier today, the check engine light came on, which I planned on going check it when I got off work. I had a mobile diagnostic worker come check it out, and he told me it was my transmission. I contacted the lot where I bought it, and am waiting to get it towed back there. This was dangerous because it stopped driving at a stop sign, and I didn't know what to do. I had to flag traffic to go around and wait for people to come help me push it out of the way of traffic. I am a single mother with a three year old.

Filed Jul 30, 2025 · Engine · 45,000 miles · GA

The contact owns a 2016 Dodge Grand Caravan. The contact stated while the vehicle was at the independent mechanic for a service appointment, the contact was informed that the oil pump housing had melted and needed to be replaced. The contact was informed that the oil pump housing was made of plastic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.

Filed Jun 7, 2025 · Electrical, Engine · MI

My wife was stopped at a drive through window in DRIVE when the engine stalled. It wouldn’t crank over and needed to be pushed out of the way and towed. The TIPM failed and needed to be replaced. The repair was done at a Chrysler dealer and they took the faulty part after repair. Safety was at risk because if this had happened in the middle of the road it could have caused an accident. My wife was lucky it happened at the drive through. Vehicle not inspected by police or insurance. No warning lights or other symptoms, just engine stalled

Filed May 19, 2025 · Engine, Transmission · 225,419 miles · MO

The contact owns a 2016 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed, the vehicle stalled, and the vehicle failed to shift into gear properly. There was no warning light illuminated. The contact became aware there was oil leaking from the front end of the vehicle near the engine compartment. The vehicle was towed to the residence. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 225,419.