Went to crank the truck one day and all of a sidden the igniton switch started smoking . It burnt the whole entire wire from the top all the way to the PCM
The worst 1994 Dodge RAM 1500 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical22
- Steering17
- Suspension16
- Brakes11
- Body8
- Lights8
- Airbags7
- Fuel system7
- Transmission7
- Visibility7
- Tires6
- Engine5
- Locks5
- Acceleration2
- Seat belts2
- Wheels2
Specific symptoms reported on the 1994 Dodge RAM 1500
Recalls
No recalls on record for this model year.
Defect investigations
Seat back failure
Odi has identified 30 incidents where it is alleged the seat back collapsed in a rear impact crash.these incidents are alleged to have contributed to 23 injuries and two deaths.the data presented to odi show that the seat back strength of the front seats comply with federal motor vehicle safety standard no. 207. Seating system.according to daimlerchrylser the front seats were designed to collapse rearward in rear impact crashes as part of the energy absorptioncapabilities of the seating system to reduce the chance of serious injury to the occupant.rates of occurance were compared to peer vehicles, and it was shown that the performace of the subject vehicle was comparable to those vehicles.in view of the forgoing, it is unlikely that the federal safety agency would issue an order for the notification remedy of a safety defect in the subject vehicles as defined by the petitioner at the conclusion of the investigation requested in the petition.therfore, in view of the need to allocate and prioritize the federal safety agency's limited resources to best accomplish the agency's mission, the petition is denied.for further details, refer to odi's response to the petition published in the federal register vol.69, no. 60 , dated march 29, 2004.
DP03006
Steering column separation
Mr. Larry a. Sackey submitted a petition to the federal safety agency by letter dated april 18, 2003, requesting that agencyfurther investigate the defective collapsible steering shaft system on 1987-1995 vehicles manufactured by the daimlerchrysler corporation.in part because of 49 cfr ? 30120(g), the federal safety agency has decided to limit the scope of the petition vehicles to 1993-1995 models, excluding the 1993 jeep grand cherokee and 1994-1995 dodge ram series trucks that were recalled (93v210 & 96v230) for steering column failure.if the analysis of these vehicles had identified a potential problem, the scope could have been expanded in an investigation.a review of odi's data base shows no recent complaints and a lack of a complaint trend concerning the subject issue on the subject vehicles as a whole or by individual models.therefore, the petition is denied.for details, see federal register notice volume 68, no. 130, july 8, 2003.
DP03002
Headlight circuit
The headlamp switch in the subject vehicles can over-heat and fail resulting in loss of head lamps and possibly other lights.daimlerchrysler conducted a series of tests and determined that the 3500 series is prone to generating head lamp switch temperatures in excess of the switch lubricant threshold of 100 degrees centigrade.when this occurs, the lubricant solidifies and adheres to the switch contach surfaces increasing internal resistance and therfore, temperature.daimlerchrysler informed the federal safety agency that it would initiate a recall of 79,3665 model year 1994-1997 dodge 3500 series ram trucks only based on additional testing from which it determined that the 1500/2500 series vehicles nominally operate significantly below the temperature threshold of the switch lubricant.owners of 1500/2500 series trucks were sent a notification letter advising of the proper methods for adding aftermarket lighting accessories.
EA98010
Alleged failure of steering pitman shaft
Steering box output (pitman) shaft breakage resulting in loss of control.
PE96022
Technical service bulletins for the 1994 Dodge RAM 1500 3
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
1994 Dodge RAM 1500 fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 3.9L 6‑cyl | RWD | 14-15 | 17-19 | 15-17 |
| 5.2L 8‑cyl | RWD | 12 | 16-17 | 13-14 |
| 5.2L 8‑cyl | 4WD | 11-12 | 15-16 | 12-13 |
| 5.9L 8‑cyl | RWD | 11 | 15 | 12 |
| 5.9L 8‑cyl | 4WD | 11 | 15 | 12 |
What 1994 Dodge RAM 1500 owners say
Most recent owner complaints, unedited.
I have has issues with electrical ony dodge truck, the light switch for headlights burning wires from nowhere when driving from light switch.aril of 2020 I was involved in an auto accident which was a result of my air bag steering wheel went off by itself, the light for the air bag was on for air bag was intermittent, but lately it wouldn't turn off anymore a mechanic checked said everything was fine,and would erase the lite, but would come back on, I called dodge and was told it would at the time a lot of money to me to have all the electrical checked at my expense and the light switch was an issue from mfc.I was driving around 30 miles more or less an hour when the bag went off and I was struck in the face, and collided with an on comming car on a 2 lane street.I want to know if there is a recall on the 94 dodge ram truck. Thank you
Lower intermediate steering shaft broke, causing complete loss of steering control. Fortunately, was just moving farm pickup out of barn and not on road at the time. Barely moving when control was lost trying to turn.
Tl* the contact owns a 1994 dodge ram. The contact stated that the ball joint that secure the throttle cable was worn and needed to be replaced. The contact took the vehicle to an independent mechanic who linked the failure to the federal safety agency campaign number: 01v037000 (vehicle speed control). The contact reached out to dch chrysler dodge jeep ram fiat of temecula (26845 ynez rd, temecula, ca 92591) where he was informed that the previous owner had the recall repair performed. The mechanic informed the contact that the recall repair performed failed to fix the vehicle. The contact also spoke to larry h. Miller dodge ram peoria (8665 w bell rd, peoria, az 85382) and larry h. Miller chrysler jeep dodge ram surprise (13165 n autoshow ave, surprise, az 85388) who both disputed the independent mechanic's claims. The dealers stated that the failure was certain to recur due to the high mileage on the vehicle. The manufacturer was notified of the failure and informed the contact that a recall repair was a one-time free repair and that any additional repairs were done at the vehicle owner's expense. The vehicle was not repaired. The failure mileage was 255,000.
Traumatic injuries to arm and abdomen; faint sound briefly was noticeable from clockspring area prior to airbag explosion; vehicle moving at 5 MPH, slightly turning right; never a collision or maintenance performed on steering column; with airbag removed the particular sounds are much more pronounced. Therefore, I suspect clock spring may have triggered explosion. Wire insulation appears worn away. I received no notice of this likelihood or possibility of failure. Allegedly, special investigations group will properly look into this. I question whether breach of the duty of care, and harm caused by the breach has occurred. I no longer feel relatively safe with dodge ram 1500 or that chrysler is honoring their obligation to provide a reasonably safe environment for the driver. *tt
Tl* the contact owns a 1994 dodge ram 1500. While using the truck to plow with the heater blower on high, the vehicle caught on fire. The contact was able to extinguish the fire. The vehicle was towed to the dealer to be diagnosed. The contact was informed that the inspector was not able to look at the vehicle for two weeks. The vehicle was not repaired. The vehicle was included in the federal safety agency campaign number: 00v135000 (electrical system). The manufacturer was notified of the failure. The failure mileage was unavailable.
Tl* the contact owns a 1994 dodge ram 1500. While driving approximately 40 MPH, the hood of the vehicle unlatched independently and caused the front window to shatter. The vehicle was towed to the contact's residence. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 300,000.
I was driving along at about 50-55 MPH when suddenly the rear of the truck is violently propelled upwards, lifting the rear wheels up off the pavement. I look up in the rear view mirror trying to make sense of what just happened and I see my spare tire standing straight up in the middle of the road and other vehicles braking and weaving to avoid the dump my truck just took in the middle of the road. Once I looked under the bed of the truck I noticed a 4 to 5 inch piece of frayed cable is all that's left where my spare tire used to be. It must have gotten hung up under the bumper when it dropped because the bumper is now pushed up towards the tailgate in the center. My spare was a brand new tire as well.
Tl* the contact owns a 1994 dodge ram 1500. The contact stated that the vehicle leaked fuel from the cylinder wall fuel injector. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was not available. Updated 02/18/15*lj updated 9/17/2017
The ram 1500 dashboard has developed several cracks. This was not my experience with the dakota.
Compare the 1994 Dodge RAM 1500
Other model years
1991199319941995199619971998199920002001200220032004200520062007200820092010201120122014
Questions about the 1994 Dodge RAM 1500
Is the 1994 Dodge RAM 1500 reliable?
Owners have filed 116 complaints about the 1994 Dodge RAM 1500, fewer than a typical RAM 1500 model year.
What is the most common problem with the 1994 Dodge RAM 1500?
Electrical system, with 22 complaints. Next is steering (17).
How many recalls does the 1994 Dodge RAM 1500 have?
No recalls on record.
What year does the Dodge RAM 1500 have the most electrical problems?
The Dodge RAM 1500 model years with the most electrical complaints are 2011 (214 complaints), 2012 (175 complaints) and 2006 (125 complaints).
What gas mileage does the 1994 Dodge RAM 1500 get?
Official estimates for the 1994 Dodge RAM 1500 range from 12 to 17 mpg combined. The most efficient version (3.9L 6-cyl, RWD) gets 14-15 city and 17-19 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Dodge RAM 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history