1995 Ford Aerostar transmission problems

Filed Jan 23, 2001 · Transmission · NM

Transmission/gears failed more than once. *ak the consumer says the cost for replacing the transmission that failed again was paid by the consumer.

Filed Dec 7, 2000 · Transmission · CA

Transmission has been replaced 4 times.vehicle stalled in middle & when going in reverse. Problem is intermittent. Dealer just rebuilds transmission, not knowing if parts are defective.

Filed Jun 6, 2000 · Transmission · TX

Consumer found out through a technical service bulletin that transmission had a design flaw. They had to alter the original design to repair the problem. Opening to transmission pump was too small, allowing the pump to become clogged up. It built presure to blow the front seal.

Filed May 4, 2000 · Transmission · TX

Continual loss of torque over last seven months. Dealer has always said it was the small engine until on 5-1-00 it refused to take off when stopped at a stop sign and had a leak coming from the transmission. Leak later stopped and a check of the fluid level showed it to be normal. Ron clark ford checked it out today and said the torque converter and entire transmission was worn out and estimated replacement at $2,800 for a rebuilt transmission. It was brought to their attention that each time we have taken it in for a check for the symptom that lead to this failure we have been told that nothing could be found wrong.

Filed Apr 10, 2000 · Transmission · NV · fire

Ford refunded us $1000.00 for 1 transmission, the first one was still on warranty, the most recent transmission failure occured at 55 miles per hour and it was the tourque converter that blew in this case.

Filed Mar 16, 2000 · Transmission · NC

Recall 97v204000: transfer case: recall been repaired twice by two ford dealers quality ford, whiteville, nc and pervis brothers, fayetteville, nc 910‑864‑3983. The problem is still occurring, remedy did not fix the safety defect. Owner has been trying to get rid of the van, dealer would not take it for a trade in. *ak

Filed Sep 2, 1999 · Transmission · OH

Received recall notice 97v204000 concerning 4-wheel drive & contacted dealer. Took vehicle to dealer for repairs. Picked up vehicle. Was not satisfied with the recall repairs.

Filed Aug 24, 1999 · Transmission · PA

This vehicle is exhibiting some of the same symptoms as previously experienced with the recall number indicated (97v204000). This recall was done in early march 1998. The resonance, which occures while the vehicle is neither being pulled by the drive train nor the engine being pushed by the drive wheels(floating between acceleration and decelleration), is begining to be in the drive train, just as it had been before the recall. Is it possible that the recall procedure was incorrect, or not completely engineered? Gibbons motor sales, dickson city, pa has in my past experience been competent. They were the servicing dealer. I feel that the problem is returning. I am unsure if the company would be obligated to repair this problem again?

Filed Jun 25, 1999 · Transmission · NJ

Consumer had new tires put on vehicle due to vibration, problem still exist. However, the drive shaft / transfer case was replaced which was the cause of the vehicle experiencing sudden acceleration and vibration, prior to recall notice (97v‑204).

Filed May 7, 1999 · Transmission · TN

Vehicle will not shift into park, cause unknown. Please give any further details.