Ford Bronco Sport collision warning problems

Filed Sep 11, 2026 · Brakes, Engine · 11,000 miles · AL

The contact owns a 2021 Ford Bronco Sport. The contact received notification of the federal safety agency Campaign Number: 25V467000 (Fuel System, Gasoline). The contact stated that while driving on several occasions at various speeds, there was an abnormal gasoline odor inside the vehicle and the vehicle sputtered. The ABS, traction control, engine, seat belt, battery, and other unknown warning lights illuminated, and the messages, "System off to Save Battery - Please turn off to Start Engine", "Charging System Service Now", "Pre-Collision Assist not Available", "Front Camera Temporarily Unavailable", "Service Vehicle Soon", and "Check Brake System" were displayed. The vehicle was taken to a dealer where it was diagnosed and determined that the battery needed to be replaced and the body control module software needed to be updated. The vehicle was repaired, but the failure reoccurred five months later. The vehicle was taken to another dealer but was not yet diagnosed. The contact stated that fault codes for the battery and alternator were retrieved. The failure mileage was 110,000.

Filed Aug 16, 2026 · Acceleration, Brakes · KY · crash

Pre-Collision System warning activated unexpectedly. The vehicle then accelerated by itself unexpectedly and the accelerator/throttle was engaged by itself. Breaks were then hard to push and vertically impossible to slow down. At the time, there was no vehicle or obstruction immediately around the vehicle other than a possible box, or small obstruction in the road. Yes the vehicle is available for inspection upon request. Due to the unexpected activation of the pre-collision system followed by unexpected acceleration by itself, caused the vehicle to move unexpectedly and resulted in a collision with another vehicle, creating a safety risk to the occupants of both vehicles. No. The problem has not yet been reproduced or confirmed by a dealer or independent service center. No. The vehicle has not yet been inspected by the manufacturer, police, insurance representatives, or any other party. The police did come to the accident and a police report was filed. Yes. The vehicle's Pre-Collision System warning activated unexpectedly immediately prior to the incident. There were no other known warning lamps or messages before the vehicle unexpectedly accelerated by itself and collided with another vehicle.

Filed Jul 29, 2026 · Airbags, Driver assistance · 20,500 miles · CO · crash · 1 injury

The contact owned a 2025 Ford Bronco Sport. While the contact’s brother-in-law was driving approximately 55 MPH, the vehicle crashed into the rear of another vehicle, causing the vehicle to flip over and slide between 50 and 75 yards. During the crash, the Forward Collision Avoidance system failed to activate, and the front driver’s side air bags did not deploy. The driver was later taken to the hospital and treated for a concussion and arm and leg abrasions. A Police report was filed at the scene, and the vehicle was towed away and later deemed a total loss by the insurance company. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was 20,500.

Filed Feb 9, 2026 · Driver assistance · 40,000 miles · MD

The contact owns a 2022 Ford Bronco Sport. The contact received notification of the federal safety agency Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE). The contact stated that while driving around the neighborhood at slow speeds, the "Forward Collision Warning" system failed to function as intended. The contact stated that the alarm sounded while there were vehicles parked on the street. Occasionally, the vehicle experienced phantom braking. The contact stated that on a separate occasion, while driving on the freeway at an undisclosed speed, the "Forward Collision Warning" alarm sounded, even though no vehicles were nearby. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was not made aware of the issue. The failure mileage was approximately 40,000.

Filed Sep 28, 2025 · Brakes, Driver assistance · CA

The transmission and/or shift-by-wire control system appears to have failed. While the vehicle was in motion, the system engaged “Park” and remained stuck in this position. The vehicle immediately became immobilized and could not be shifted out of Park. The vehicle remained locked in Park for 3 weeks. The failure occurred without prior warning and eliminated essential vehicle control functions. Has the problem been reproduced or confirmed by a dealer or independent service center? I could not cross the border in a tow truck with a stranger- so I had it repaired in Tijuana at a Ford Service Center. The vehicle was towed to an authorized Ford service facility (Ford Surman BC – Tijuana, Baja California), where technicians confirmed a defect-related failure and performed warranty repairs to restore functionality. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? Yes. An authorized Ford dealer inspected the vehicle and conducted the warranty repair. The manufacturer has been notified of the incident. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? No warning indicators were displayed before the incident. After the uncommanded shift into Park and immobilization, the instrument cluster displayed multiple error messages including “Park Brake Fault – Service Now” and “Pre-Collision Assist Not Available.” Additional context: The vehicle had been serviced at an authorized Ford dealership in the United States less than one month prior to the incident and had fewer than 13,000 miles Vehicle broke down at night with my children in the vehicle. I incurred costs from tow trucks and rentals to get to work the following week. Now with this new Recall and no possible repair for it, this vehicle is extremely unsafe, I have been in communication with Ford and they claim they are going to do nothing about. Please help.

Filed Sep 24, 2025 · Driver assistance · PA

Potential systemic issue: I purchased the 2022 Ford Bronco Sport on 06Aug2025 which is still within its warranty period. During the test drive I identified the Pre-Collision Assist with Automatic Emergency Braking (AEB) wasn't operable. The dealership stated yes that model does have it and that it is not working. All safety settings were verified on and that it should be functioning but isn't. The dealership troubleshot but couldn't identify the issue. The dealership then contacted the Ford maintenance headquarters twice and received responses to the effect of "Where looking into it" with no path forward or timeline to correct the issue. Important considerations and information: 1. This is an important safety feature that people assume is working if turned on. This is no alarm or error code showing that it has malfunctioned. 2. While driving the Pre-Collision Assist with Automatic Emergency Braking (AEB) alarms went on twice at different times. There was no vehicle in front of me, and it didn't attempt to brake. If it did auto-brake this could've caused someone to rear end me. 3. I was given loaner Ford Bronco sport, and the same safety feature and others didn't work in that one either. This leads me to think this is a systemic malfunction and not a one-off. 4. All other safety features work 5. Ford Headquarters customer service opened case# CXH-XXX. Phone: [XXX] ext. 79202. Case owner is [XXX] 6. There are two versions of Ford Co-pilot 360 which most customers don't know of. One has dynamic cruise control, and the other doesn't. It's assumed by the customer that it is equipped with dynamic cruise control. This isn't clearly stated to the customer. This assumption could be a potential safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 28, 2025 · Electrical, Engine · PA

On August 16, 2025 while accelerating on an on ramp to the PA turnpike my vehicle stopped acceleration which nearly caused an accident as I was trying to merge on turnpike and my vehicle stopped. A few days before my screen went black. I have had issues with this vehichle for the back up camera and the collision warning coming on when there was nothing near the vehicle (this was corrected by the dealership). I took my vehicle to the dealership on 8/25/25 concerning the black screen and loss of acceleration and was told no error code came up on the event.

Filed Jun 12, 2025 · Brakes, Electrical · VA

Break stated feeling a thumping while driving, not breaking, ABS sensor came on dashboard. Car stated giving me a collision warning, pre-collision not available, hill assistant warning, Blind spot detection with cross traffic, and service advance tracking. ABS sensor is faulty. My car is stuck on slippery mode, it’s hard to turn, electrical system is faulty. Goats is not working, I can’t turn options on or off. And it became hard to steer. I had the battery recall done. Left from dealer and they assured me that this will fix the issue. It came all back about 30 seconds after I left the dealership.

Filed May 6, 2025 · Driver assistance, Fuel system · NV

They sold me a car that wasn’t ready to be sold. They promised to fix it, but they didn’t. Child seat anchor latch ,cross traffic alerts rear,rollover stability control, front drive airbags antilock brakes front passenger airbags the trim electronic/control brake assist running light side impact airbags. Say current airbags, front passenger airbag front dryer airbags Ford collision warning, warning don’t worry, automatic emergency break for compound doesn’t work in base. It’s supposed to be a gold certified vehicle. they’re lying to me about my warranty in the packages that I bought. My caliper was supposed to be fixed because it was ready when I got it my chassis and Auntie breaker system my gateway to be reprogramming for inspection and maintenance the warranty for the rest. The budget powertrain the SOS post crash alert system. They never gave me copy my certified thing. I have a non-conformity part on my car and it’s supposed to be certified that supposed to be on there cause preowned CPO certified the non-conformity part don’t fit in there or fit as it supposed to because it’s not after four part because they don’t do it. I bought extra. I bought extra warranties and extra upgrades and they’re not honoring it they want to give all my paperwork when I bought the car. There was no buyers guide in the window per federal regulations or state creditors I paid for seat covers upgraded. They never put them in. Ford dealership in nevada on decatur

Filed Apr 24, 2025 · Driver assistance · 32,000 miles · MA

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at various speeds, an alarm was intermittently activated associated with the Forward Collision Avoidance system while there were no other vehicles nor objects nearby. The engine warning light was illuminated. The vehicle was taken to a local dealer and was diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. In addition, the contact stated that the radar sensor system was replaced previously. Upon further investigation, the contact related to failure to the federal safety agency Campaign Number: 21V982000 (Forward Collision Avoidance); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 32,000.