Ford Bronco Sport adaptive cruise problems

Filed Sep 9, 2026 · Driver assistance, Electrical · CA

The contact owns a 2025 Ford Bronco Sport. The contact stated that while driving downhill on the freeway with the adaptive cruise control engaged, the transmission independently shifted into neutral, the vehicle lost power, and failed to accelerate as needed. The vehicle was pulled over to the side of the road and shifted back into drive. The contact exited the freeway, and the vehicle was towed to a dealer. The contact stated that the word “CANCEL” in orange was displayed on the instrument panel, and the vehicle went into LIMP Mode. The dealer was unable to duplicate the failure. The vehicle was not repaired. The engine had seized but was operating under reduced power.

Filed Jul 8, 2026 · Driver assistance, Fuel system · IN

The vehicle is only a 2022 and has a jerky acceleration during non-highway driving with RPMs fluctuating. The tire, cruise control and seatbelt indicator lights are illuminated with no resolvable issue (the dealer clears them out and they come back). There’s an audible muffler rattle that has been present for a long time that the dealer says is normal. When I fuel up the engine audible bogs down. On a recent road trip to New York the vehicle vapor locked at a gas station and had to be jumped. The vehicle has been nothing but recalls and issues

Filed Jun 19, 2026 · Driver assistance, Seat belts · UT

Passenger seatbelt doesn’t loosen up driven normal. Adaptive cruise control doesn’t work, never has. I didn’t know about it until Monday I am taking it to a ford dealership today at Ken Garff Ford. .

Filed Jun 14, 2026 · Fuel system · CA

Ford has done nothing to repair this recall. I was a vehicle defect investigator for a major Insurance Company during the ignition switch and cruise control deactivation switch. I saw fires in garages, business and carport that put peoples lives in danger. This is the same type of danger and needs to be corrected immediately. Manufacturer Recall Number25S76 the federal safety agency Recall Number25V467

Filed May 19, 2026 · Driver assistance · NY

Adaptive +predictive cruise control malfunction causing 1) sudden vehicle acceleration and 2) Cruise on but disengaged suddenly engaged and set a higher speed than originally set. Merged into light traffic on 4 lane interstate, no other vehicles within 200yds or so. Turned on, then set cruise control at 70mph, about 10 seconds later I felt the car surge, I looked down, saw the cruise indicator now showed 80, tapped the brakes to disengage. About 2 miles later repeated the same but was watching and vehicle repeated same behavior, I turned the system off. About 2 miles later I repeated the same with the same result. Each time set to 70 and within 10-20 seconds vehicle accelerated to a self set higher speed - 80. Problem 2, a few miles later, after a merge onto another interstate the speed limit changed tried this again except this time, as a came out of the curve (doing about 45mph) I turned the cruise on, a few seconds later I look down and watch the cruise indicator turn from white (on but not engaged) to green (on and engaged) without touching the set button. On the return trip I duplicated the acceleration twice more. 4 days later dealership service called to confirm that they reproduced problem 1 and were in contact with the manufacturer for how to proceed. No warning lights or messages, dealership service stated no fault codes.

Filed Apr 13, 2026 · Acceleration · NC

UNINTENDED CRUISE CONTROL ACCELERATION TO 85 MPH Engaged cruise control to set speed approx 72mph and within 30-45 seconds the cruise control suddenly without warning reverted to 85mph. Startled, I immediately hit brakes and cruise disengaged with no accident. Following days, in safe traffic setting I repeated the pattern of setting highway cruise speed and within 30-45 seconds vehicle cruise setting reverted to exactly 85mph. Obviously, this is a serious safety risk defect requiring immediate attention. On Friday, I brought the vehicle for diagnosis/repair to dealership where I purchased it. After 2 days their technicians reported that they had never encountered this unintended cruise control acceleration before and had submitted the problem to Ford headquarter "engineers" to help guide them. I have sent email to dealership GM to inform him of this serious defect, and informed the Ford Customer Relationship Center (case# [XXX]) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 7, 2026 · Driver assistance, Electrical · OH

I purchased the 2021 Ford Bronco Sport in August of 2025. There were issues after about a week with all kinds of messages of components not working cycling through constantly on the display. The electric brake would engage on its own while parked and had to be shut off before I could go forwards after starting the vehicle. I took it to the dealership where I bought it and after a few days they said it was a batter issue and replaced it at no cost to me. It worked okay for a short time and then I had the same issues and now added to those were it wouldn't start for at least 15 minutes and several tries. Cruise Control could not be used and the turn signals would not work while all of the messages were displaying. The windshield wipers would only work at the highest setting and the rear wipers would not work at all. I took it to another Ford Dealership and they said it was an electrical wiring issue that they found. The High Speed Cam wiring is what they found a break in and they fixed it and cleared the codes. I paid $450 for this repair. Just 4 days later the issues have returned. Messages about components not working, this time the right turn signal would not shut off. I am concerned about the safety issues while driving with my turn signal stuck on. I called the same Ford dealership and they can get it in on Friday so that I can have a loaner car. I just don't feel safe driving the Bronco. I don't have the money to loose on trying to trade it in with these issue. Help!!!!

Filed Nov 26, 2025 · Brakes · MO · crash

• What component or system failed or malfunctioned, and is it available for inspection? The brake system on my 2024 Ford Bronco Sport failed to respond for approximately 2–3 seconds after I pressed the brake pedal. This occurred immediately after freeing my foot from underneath the gas pedal while cruise control was active. The vehicle is available for inspection. • How was your safety or the safety of others put at risk? The vehicle did not slow down when the brake pedal was fully pressed, causing me to enter an intersection while other vehicles were turning. I had to swerve to avoid a collision, but another vehicle entered my path and a crash occurred. The braking delay directly increased the risk of a serious accident. • Has the problem been reproduced or confirmed by a dealer or service center? UNKNOWN. I have not yet had a dealership or service center attempt to reproduce or diagnose the issue. • Has the vehicle or component been inspected by the manufacturer, police, insurance, or others? The accident was documented by police and insurance, but the mechanical issue itself has not yet been inspected for cause. • Were there any warning lamps, messages, or symptoms prior to the failure? When did they appear? There were no warning lights, messages, or prior symptoms before the brake failure. The brakes simply did not respond when pressed. • Description of the incident: While traveling northbound on Sterling Ave approaching Truman Rd, the light turned yellow. I attempted to brake, but my foot was caught under the accelerator due to cruise control being engaged. After freeing my foot, I pressed the brake firmly, but the brakes did not respond for approximately 2–3 seconds. I swerved left to avoid turning traffic and sounded my horn. Another vehicle continued its turn and my front passenger quarter panel struck its rear passenger quarter panel at about 15 mph. The brakes only began functioning after the vehicle jerked from evasive steering input.

Filed Sep 24, 2025 · Driver assistance · PA

Potential systemic issue: I purchased the 2022 Ford Bronco Sport on 06Aug2025 which is still within its warranty period. During the test drive I identified the Pre-Collision Assist with Automatic Emergency Braking (AEB) wasn't operable. The dealership stated yes that model does have it and that it is not working. All safety settings were verified on and that it should be functioning but isn't. The dealership troubleshot but couldn't identify the issue. The dealership then contacted the Ford maintenance headquarters twice and received responses to the effect of "Where looking into it" with no path forward or timeline to correct the issue. Important considerations and information: 1. This is an important safety feature that people assume is working if turned on. This is no alarm or error code showing that it has malfunctioned. 2. While driving the Pre-Collision Assist with Automatic Emergency Braking (AEB) alarms went on twice at different times. There was no vehicle in front of me, and it didn't attempt to brake. If it did auto-brake this could've caused someone to rear end me. 3. I was given loaner Ford Bronco sport, and the same safety feature and others didn't work in that one either. This leads me to think this is a systemic malfunction and not a one-off. 4. All other safety features work 5. Ford Headquarters customer service opened case# CXH-XXX. Phone: [XXX] ext. 79202. Case owner is [XXX] 6. There are two versions of Ford Co-pilot 360 which most customers don't know of. One has dynamic cruise control, and the other doesn't. It's assumed by the customer that it is equipped with dynamic cruise control. This isn't clearly stated to the customer. This assumption could be a potential safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 18, 2025 · Acceleration · 33,000 miles · CA

The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving 60 MPH with the cruise control engaged, while slowing down to exit the freeway, the cruise control failed to disengage, and the vehicle continued driving at 60 MPH. There was no warning light illuminated. The contact depressed the brake pedal several times, and the vehicle slowed down to approximately 20 MPH, and the cruise control disengaged. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 33,000.