I have not had an "incident" with my 1998 ford expedition, but I am scared senseless having read the many reports by owners who have. I have two daughters ages 3 and 7 who ride daily in our family vehichle. I am urging you to consider a mandatory recall on expeditions with similar cruise control systems to the 2000 models. Please don't allow anyone else to suffer or die.
The worst 1998 Ford E Series problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Tires7
- Brakes1
- Fuel system1
- Locks1
- Seats1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Tires7
- Brakes1
- Fuel system1
- Locks1
- Seats1
- Transmission1
Recalls 1
Engine and engine cooling: engine: diesel
- What is wrong
- On certain heavy duty trucks equipped with 7.3l diesel engines, the camshaft position sensor located on the engine of the vehicle may function intermittently, possibly resulting in an engine stall.
- Risk
- In the event of an engine stall, a crash could result without warning.
- Remedy
- Dealers will inspect the sensor and replace it with an improved camshaft position sensor free of charge. The recall began on december 29, 2007. Owners may contact ford at 1‑866‑436‑7332.
Recall number 07V553000 · Recall details
See all 1 recalls for the 1998 Ford E Series
Defect investigations
Spark plug ejection from cylinder head
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi?s analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles.however, odi?s analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences.none of these showed any evidence of a serious safety consequence.given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low.in view of the foregoing, it is unlikely that the federal safety agency would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition.therefore, in view of the need to allocate and prioritize the federal safety agency?s limited resources to best accomplish the agency?s safety mission, the petition is denied.
DP05005
Technical service bulletins for the 1998 Ford E Series 128
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Ford: the blower motor on some vehicles are operating either incorrectly or not operating or just...
- Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Guidance for cng tank inspection for vehicles produced after december 2, 1996
- Intermittent rough idle - non-commanded EGR (exhaust gas recirculation valve) flow
- Diagnostic trouble code B1876, B1880, B1915 and/or B1920 in the ecs module - vehicles equipped with...
- A driveline clunk or bump when starting from a stop
- General (PCM) power train control module programming procedures
- Some 7.3L diesel turbocharger pedestals may leak oil around the exhaust back pressure actuator (EBP)
- Engine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
What 1998 Ford E Series owners say
Most recent owner complaints, unedited.
Tire tread separation of firestone steeltex radial r4s lt 225 75 r/16 ms load range e tubeless radial 2 steel ply tire. On 1999 winnebago minnie motorhome (ford v10 - e superduty series) with 9,400 miles. We limped the vehicle into nearest gas station with steel belt showing on tires. No apparent road damage to tire. The tread just separated from the tire. Tires were checked at dealership two days prior to trip for proper air pressure and wear prior to leaving on trip. Everything checked out fine. We are going to try and contact firestone directly regarding this matter and see if they will assist.
I have a 1998 ford diesel van that I have just purchase about a couple of months ago. The former owner gave me a clue of a problem that I didn't pick on when I bought it. He said don't fill the tank full or the fuel will overflow. Well it does overflow full or not but worst with a full tank. Ford and the federal safety agency had issued a recall for possible cracking of fuel tanks in van's like mine. The recall was for 1997 thru 2001 econoline_van's. I took it to a ford dealership in charleston sc but they refused to look at it and told me that no recall was ever made on my van. I called ford customer care and they said the same thing. But a recall was made on june 29, 2000. The fuel tank does not appear to leak while stopped even if the motor is running and I have let it run for more than a hour. It leaks very bad while underway. The wiring harness that runs by the fuel tank and just underneath it is full of diesel fuel. I open up the harness plastic cover and drain the fuel from it but it will fill up again as soon as I drive the van. Although I have tried to pin point the source of the leak I have not been able to do so. I clean the tank but the fuel will reappear with no visible source of leak. This has got me scared and since ford will not look at it unless I agree to pay for repairs and I am at lost as to what to do now. I feel that this problem is just like all the other van's that they have already repaired or install insulators to protect the tank from cracking if it is not leaking. I believe ford should look at the van and fixed at their expense if the tank is indeed crack like I suspect. I found that a recall # 01v114000 was made on march 30, 2001 for possible fuel tank cracking in 1998 e350 van's. I also found that the federal safety agency had also issue a tsb #15113 for 1998 ford e350 vans for possible fuel fill valve sealing condition. I think recalls are more important anyway and can be verified.
The inside passenger side duel tire tread separated while driving at 55 MPH.*ak consumer heard a noise from the tires and 15 minutes later the entire tread blew off the tire. It damaged the wiring, frame and body. This was not a recalled tire. Consumer no longer trust the remaining tires, ford or firestone. *ph
I own a 1998 coachman motorhome, class c with steeltex radial r4s lt225/75r16 m/s tires on it. While traveling up i64 headed toward crozet, va. From my home in mechanicsville, va. I experienced tire problems. While driving along around 62 miles per hour I experienced a severe bumping which felt like a tire problem and after pulling over and inspecting the tires discovered that the right rear outside tire was the problem. After calling good sams road service and getting the tire changed the tire looked as if the tread had separated from the rest of the tire and was coming apart. These tires only had roughly 16,800 miles on them at the time. The spare had never been used and still had the sticker on it so I was able to continue on my trip. I sent an email to firestones web site and to this day haven't heard a word about the tires. These tires are load range 'e' tires and had 80 lbs. Of air in each because I check them before taking any trips. I've got another tire on the front of my rv that is wearing odd also. Normally when a tire is under inflated it wears the outside treads down and if over inflated it wears the center tread or treads down. This tire is wearing down on the second and fourth tread. Isn't this odd? The first, third and fifth tread look okay. I'd hate to think more of these tires doing the same thing and possibly causing injury or damming the next time. We were fortunate this time. Thank you.
Tire size lt22575r16; these tires are used on a winnebego motorhome 1999. The inside rear of the wheel weld was damaged due to a tire capping off. The other tires are now starting to exemplify the same failure pattern. Ts there was a loud noise. The consumer found that the inside rear tire had lost the cap. The dealer found that all of the tires were separating. Scc
Without warning rear dual firestone (225/75r/16) tire tread started to separate, causing damage to propane gas line of the motor carrier and tail pipe framing under wheel well. Dot # vd11xd347ak.*ak
Firestone steeltex tires p225/75r16 dot vd1l1xd experienced blowouts, one occurred while it was raining, consumer states there was property damage.
Tread separation (possibly due to lack of adhesion) and blowout, causing damage to right side of motorhome and exhaust pipe. Two outside storage bins were damaged; mud flap torn loose; wheelwell trim torn loose; bin lights broken; exhaust pipe was bent at a 90 degree angle; fiberglass damage to one bin door. (dot number: vd1l1xd367 tiresize: lt22575r16)
Driver unable to read speedometer because steering wheel blocks view, location of indicator creates poor visibility. Yh
Compare the 1998 Ford E Series
Other model years
Questions about the 1998 Ford E Series
Is the 1998 Ford E Series reliable?
Owners have filed 13 complaints about the 1998 Ford E Series, 2.2 times a typical E Series model year.
What is the most common problem with the 1998 Ford E Series?
Tires, with 7 complaints. Next is brakes (1).
How many recalls does the 1998 Ford E Series have?
1 recall, covering engine and engine cooling.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1998 Ford E Series?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history