2019 Ford Ecosport: engine failure

Filed Sep 2, 2026 · Engine · IA

My 2019 Ford EcoSport suffered sudden low oil pressure and catastrophic engine failure 10 months after receiving service under Safety Recall 23S64. the federal safety agency Campaign 23V905. The Authorized dealership is refusing to inspect the vehicle or honor Ford's engine replacement remedy, claiming the recall is closed and too much time has passed. This leaves me with an un-remedied safety hazard.

Filed Aug 5, 2026 · Engine, Fuel system · MO

A young teenage driver faced a terrifying highway emergency when her vehicle suffered an abrupt, dangerous loss of motive power at 70+ MPH on the interstate due to sudden turbocharger failure. Moving at high speeds in heavy traffic, the sudden drop in acceleration left the driver vulnerable to rear-end collisions from oncoming semi-trucks. The vehicle was driven into the shop with a failed turbocharger and a completely contaminated oil ecosystem. The engine block has not seized yet, but all components are highly contaminated. The affected components are preserved and available for federal inspection. The root cause is a completely choked oil pump pick up tube screen. After a week-long standoff where the consumer had to escalate the case to Ford Corporate to force the dealership to drop the oil pan, teardown photos revealed the intake mesh was blanketed and impacted by a thick, suffocating mat of degraded wet belt fibers. This debris choked off oil pressure, proving the dealer fraudulently certified Safety Recall 23S64 as complete while leaving the lethal hazard trapped inside. In addition to this extreme debris, internal Ford OASIS logs admit the technician snapped a tensioner bolt during the recall. They drilled it out but failed to clean the engine, trapping sharp metallic shards that circulated into the oil system, destroying the turbocharger seals and scorching the gaskets. The dealer was given urgent warnings on April 7, 2026, when the driver reported interstate stalling ("limp mode at 70+ mph") and an AutoZone turbo pressure code. The dealer treated this severe safety risk as a low-priority task, failed to check the oil pressure, and released the car. After the forced pan drop in July, Ford Corporate denied coverage for a new long block and turbocharger, instructing the consumer to pay over $8,000 out of pocket for repairs caused entirely by their own botched recall.

Filed Aug 4, 2026 · Engine · PA

No issues with vehicle until failure, properly maintained, regular oil changes. While driving the vehicle the engine lost power and check engine light came on. The vehicle RPM's increased but had no power. Was able to drive the vehicle home but was at inconstant speeds / RPMS could not get above 40 MPH. Low oil light came on while driving home as well. Made appointment at Ford local dealership, they verbally told me the engine blew and there was no oil in vehicle and metal in oil pan. The vehicle never missed a oil change. As a result I had to replace the engine with a used one the dealership had. Total engine failure at 98956 miles. This appears to be a recall on the 1.0 engine for same issue. My wife and kids were in car when it failed, in traffic.

Filed May 22, 2026 · Engine · NE

I brought my Ford EcoSport into the Baxter. Ford, in Papillion, Nebraska, because it was malfunctioning, the oil pressure got real low and my car was not accelerating like it should Also I advise them that there is an open recall on the vehicle. As well and I that the recall and the engine malfunction are related. They told me that it wasn't, and I'm sure it was. Then, they advised me that after speaking with Ford. Ford agreed to pay $3000 for a new engine, while I was responsible for the remaining $4000, I asked if I can have an email showing the communication with Ford, I was advised that they don't have access to that. They're unable to forward me an email, which is a red flag i would like to get a second opinion on the diagnosis of my engine in the fort. Ecosport. I don't understand why they would not be able to forward me an email of the communication between them and Ford. When asked the service manager about that, he advised that he does not have access to it. Which is a red flag? Is there anything you guys can do?Please let me know.Thank you have a good day

Filed Apr 27, 2026 · Engine, Fuel system · TX

This is now going to be the FOURTH time we are going to have to put a NEW engine in the same exact car. We just replaced the engine barely a year and a half ago.

Filed Apr 25, 2026 · Brakes, Engine · IL

My 2019 Ford EcoSport 1.0L EcoBoost engine began making loud noise consistent with oil pressure failure. I brought the vehicle to an authorized Ford dealership. The dealership performed a teardown and confirmed the oil pump belt tensioner had failed — the exact defect described in Safety Recall 23S64. The dealer replaced the oil pump belt, tensioner, and oil pump under Recall 23S64. However, the dealer then stated that the resulting engine damage — severe scoring of connecting rod bearings and crankshaft journals caused by oil starvation — is “not related to the recall” and refused to replace the engine under Recall 23S64. Ford’s own recall documentation states: if engine failure is related to a broken oil pump belt or tensioner, a long block engine replacement is authorized as an interim repair at no charge. The updated Service Action also states the oil pump belt and tensioner no longer need to be replaced before long block installation. The causal chain is direct: tensioner failed (recall defect) → oil pressure lost → engine destroyed. The dealer’s refusal to replace the engine appears to violate Ford’s own Recall 23S64 service procedure. The vehicle has been inoperable for weeks. I continue making monthly loan and insurance payments on a vehicle I cannot drive. My extended warranty claim was also denied because the warranty company requires written confirmation from Ford that the engine damage is not recall-related — a document the dealer says they cannot provide. I am requesting the federal safety agency to investigate whether Ford dealers are systematically denying recall-related engine replacements under 23S64 that they are obligated to perform per Ford’s own recall service procedures. Additionally, prior to the complete engine failure, the vehicle stalled unexpectedly while stopped at a red light in active traffic without any warning. The engine shut off suddenly, consistent with sudden loss of oil pressure caused by the recall defect. This created a dangerous safety situation

Filed Apr 16, 2026 · Engine · NJ

I don't know who could help resolve the issue we have. Our 2019 Ford Eco-sport had several recalls. The last recall Holman/Ford kept our car for 9 months but kind enough to lend us a car to use while they waited for a part. We had to cancel our vacation trip to Turner Maine to see our daughter's family because we were not permitted to drive the loaner out of state! Later they decided that they had to give us a new engine and gave us the car back in November of 2024. After receiving our car back we noticed a gas smell each time we put the heater on. It was strong to the point of opening our windows for ventilation. My husband called several times leaving a message and no one called back. We left more messages saying why is the check engine light on all the time when it is a brand new engine? Finally they informed us that we need to pay for a diagnostic test that was well over $100 and we brought it to their attention that it has not been right since we got the car back so why should we have to pay for a dianostic test? We went to pepboys to get the diagnostic test that was cheaper and they informed us that Ford should have removed and replaced the canister purge solenoid when putting in a new engine. Without doing that, it could ruin the engine again as well as the canister purge solenoid. We did research to learn they should have replaced the canister purge solenoid as well. My husband called and left several messages and no one would return his call. Once again he called them today and a "Jim" called back from Holman Ford, Maple Shade [XXX] saying that the recall was on a new engine and they did not have to replace the canister purge solenoid. He told my husband it would be cheaper to go to PepBoys to replace the canister purge solenoid. Is this true that they did not have to replace the canister solenoid? We had several recalls on our 2019 Eco Sport. Isn't it considered under a lemon law? How do we get them to fix it properly with no charge? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA

Filed Apr 7, 2026 · Engine · 119,000 miles · IL

The contact owns a 2019 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the check engine warning light and low oil warning light were unexpectedly illuminated. The vehicle was taken to the dealer several times and was eventually diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact stated that after the repair, while driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light and low oil warning light illuminated. The vehicle was restarted; however, it was later towed to another dealer, but was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 119,000.

Filed Mar 24, 2026 · Engine · 60,000 miles · MI

The contact owns a 2019 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The contact stated that after exiting the freeway, the low oil pressure warning light illuminated, the vehicle vibrated, and the check engine warning light illuminated. The contact attempted to pull into a gas station but instead pulled over to the side of the road and turned off the vehicle. The contact exited the vehicle and checked the oil level, and the oil level was at the proper level. After waiting for approximately 30 minutes, the vehicle was restarted. The contact attempted to drive, and the engine seized. The vehicle was hauled by a friend to the residence. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The vehicle remained at the residence and had not been driven since the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

Filed Mar 4, 2026 · Brakes, Engine · TX

I have had to put a new engine in my 2019 ford ecosport 3 times due to the open recall on the vehicle. It is currently at the ford dealership due to coolant leaking into the head gasket. The problems with the vehicle have been confirmed by the dealers. And no there were ZERO warnings or signs before the vehicle completely failed on us on the highway the first time. Then the same issue happened yet again and had to put my car in the shop again for another new engine due to the recall.

Filed Feb 20, 2026 · Engine · 38,000 miles · NY

The contact owns a 2019 Ford EcoSport. The contact stated that while starting the vehicle, the low oil warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the oil pump had failed, which caused the engine failure. The contact was informed that the engine needed to be repaired. The vehicle was not repaired. The dealer informed the contact that the failure was related to a previous repair completed under the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); where the oil pump tensioner assembly had not been replaced, and only the oil drive pump belt had been replaced. The dealer contacted the manufacturer to request an engine replacement due to the recall-related failure. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 38,000.

Filed Feb 11, 2026 · Engine, Fuel system · TX

Car went in for recall. Ford replaced engine because they claim a bolt broke. I have taken the car about 300 miles since I received it back and the engine light appeared. I let them know. Light went off and I had another important meeting to make in DFW . This time wrench and engine light came on . It sat at airport for 2 days. Then I got back in , no warning lights on but I got home with more warnings then. Engine was super hot and making humming noise. The next day warning light again. I took videos and called Ford . They have refused to help me. I just had a new engine installed because of a recall.