2019 Ford Ecosport fuel system problems

Filed Oct 30, 2026 · Acceleration, Fuel system · FL

Unknown

Filed Aug 5, 2026 · Engine, Fuel system · MO

A young teenage driver faced a terrifying highway emergency when her vehicle suffered an abrupt, dangerous loss of motive power at 70+ MPH on the interstate due to sudden turbocharger failure. Moving at high speeds in heavy traffic, the sudden drop in acceleration left the driver vulnerable to rear-end collisions from oncoming semi-trucks. The vehicle was driven into the shop with a failed turbocharger and a completely contaminated oil ecosystem. The engine block has not seized yet, but all components are highly contaminated. The affected components are preserved and available for federal inspection. The root cause is a completely choked oil pump pick up tube screen. After a week-long standoff where the consumer had to escalate the case to Ford Corporate to force the dealership to drop the oil pan, teardown photos revealed the intake mesh was blanketed and impacted by a thick, suffocating mat of degraded wet belt fibers. This debris choked off oil pressure, proving the dealer fraudulently certified Safety Recall 23S64 as complete while leaving the lethal hazard trapped inside. In addition to this extreme debris, internal Ford OASIS logs admit the technician snapped a tensioner bolt during the recall. They drilled it out but failed to clean the engine, trapping sharp metallic shards that circulated into the oil system, destroying the turbocharger seals and scorching the gaskets. The dealer was given urgent warnings on April 7, 2026, when the driver reported interstate stalling ("limp mode at 70+ mph") and an AutoZone turbo pressure code. The dealer treated this severe safety risk as a low-priority task, failed to check the oil pressure, and released the car. After the forced pan drop in July, Ford Corporate denied coverage for a new long block and turbocharger, instructing the consumer to pay over $8,000 out of pocket for repairs caused entirely by their own botched recall.

Filed Aug 5, 2026 · Fuel system · NC

For a month, every time I put gas in my car whether I filled up or just put half a tank my car will not start for 10-15 minutes. I took it to the ford place and my extended warranty wouldn't cover it. It seems like an evap valve would be covered. I have only had my car 11 months. This is going to cost over $1,000 to fix. It seems like ford should be responsible for the repairs.

Filed May 14, 2026 · Fuel system, Transmission · CA

My car has been in and out of the shop since 2024 due to the power train system. As this is an active recall case my car was repaired 5 times. Recently, with the recall part replaced in January 2026, I got my car back and in May 2026 while driving, my car once again loss power. Going from 50 to coasting. After many guarantees that the problem is fixed, I continue to have the same dangerous problems.

Filed Apr 28, 2026 · Engine, Fuel system · CA

So my car is about to be out of warranty and I have called and made two appointments to get my recall taken care of as it is a safety risk for me and my kids. They canceled the first one with no communication and the second appointment they called and said they can’t get the part in so I have to call them in 2 weeks to check. After two weeks I believed my car will be over the 60k mark putting me out of warranty and voiding them to fix any issues that occurred because of this recall.

Filed Apr 27, 2026 · Engine, Fuel system · TX

This is now going to be the FOURTH time we are going to have to put a NEW engine in the same exact car. We just replaced the engine barely a year and a half ago.

Filed Mar 2, 2026 · Brakes, Engine · TN

The vehicle’s engine losses power while driving. Low oil pump pressure appears on the dashboard. The problem has been confirmed by a dealer. There were no warning lamps prior to the failure. The problems started February 2026.

Filed Feb 11, 2026 · Engine, Fuel system · TX

Car went in for recall. Ford replaced engine because they claim a bolt broke. I have taken the car about 300 miles since I received it back and the engine light appeared. I let them know. Light went off and I had another important meeting to make in DFW . This time wrench and engine light came on . It sat at airport for 2 days. Then I got back in , no warning lights on but I got home with more warnings then. Engine was super hot and making humming noise. The next day warning light again. I took videos and called Ford . They have refused to help me. I just had a new engine installed because of a recall.

Filed Sep 2, 2025 · Brakes, Engine · NC

I was driving and all of a sudden I received a low oil pressure alert on my care and within a min my car lost all power and was completely unable to accelerate. It is currently in the shop and they said it will be months before it is repaired.

Filed Aug 16, 2025 · Engine, Fuel system · SC

I received a recall on my vehicle February 2024 and still the parts are not available. Now I am having issues with my vehicle making it unsafe for me and my son to get to and from school and work etc. This is my only vehicle I have! I need my car repaired ASAP and I need another vehicle until mine gets fixed.