2021 Ford Ecosport: engine stalls while driving

Filed Oct 15, 2026 · Engine, Fuel system · AL

when driving the car, it will turn off all of a sudden and a message saying emergency power this is very dangers as it happened to my daughter in the middle of the road it will also stall to turn on after getting gas and you have to sit there and turn the car on and off till it decides to tune on this car has less than 50k on it.

Filed Jun 19, 2026 · Engine, Transmission · MI

Car had an interim engine placed in March 2024, for Ford recall 23S64. Then car stalled again in May 2026, took in it to have it checked and they repaired the engine and replaced the catalytic converter as per Ford recall 23S64. We replaced at our cost ther cam sensors. 7 days after picking up the vehicle, it shut down in the middle lane of the Southfield Freeway causing a safety issue to me and those around me. One the vehicle was safely on the side of the road thanks to some construction workers, I called for a tow. After 30 minutes I tried to start the car and it did not start. After 40 minutes the car started AAA and I was able to get it to Dean Seller Ford if Troy. They refused to check the work the did week prior and are saying that they can not test it until we replace the battery and starter. You don't need those to visually inspect. I do not feel the car is safe to drive at this point as it is a huge safety risk to myself and drivers around me

Filed Jun 9, 2026 · Electrical, Engine · 60,688 miles · OK

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at unknown speeds, the vehicle stalled. The vehicle restarted after 20 minutes. The Check Engine warning light was illuminated. The "Charging System Failed" message was displayed. The vehicle was previously taken to the local dealer for the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling) recall repair. The vehicle was taken back to the local dealer, where it was diagnosed with needing the EVAP purge system replacement. The vehicle was repaired; however, the Check Engine warning light illuminated while leaving the dealer. The vehicle was taken to the same dealer, who informed the contact that a diagnostic test was needed, and that there was no warranty coverage. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 60,688.

Filed May 29, 2026 · Engine, Steering · NY

Manufacturer issued a recall with no remedy. The vehicle stalled and loss power will I was driving on the highway in June 2025. The vehicle was taken to an authorized dealership for a safety recall regarding this issue. The manufacturer and dealership held my vehicle for 11 months to complete the repair. However, just 5 days after receiving the vehicle back, the engine shut off again while I was driving. The vehicle stalled while driving at approximately 25mph on a highway exit. There was no warning prior to the engine shutting off. The vehicle remains unremedied and unsafe to drive. The manufacturer has failed to repair the defect within a reasonable timeframe, keeping the vehicle out of service for nearly a year.

Filed May 14, 2026 · Engine, Fuel system · VA

I am filing a complaint regarding Consumer Portfolio Services (CPS) and the reporting and collection of a repossession deficiency balance related to my 2021 Ford EcoSport, VIN [XXX] and Ford Motor Company. The vehicle was affected by serious safety defects and recall-related issues that endangered my safety and substantially impaired the vehicle’s reliability, usability, and market value. Despite these known defects, CPS is attempting to collect a large deficiency balance following repossession and is reporting the account negatively on my credit report. I dispute the validity and fairness of the alleged deficiency balance because the vehicle’s value was negatively impacted by manufacturer-related defects and safety concerns. I also question whether the vehicle was sold in a commercially reasonable manner and whether the resale value properly accounted for the vehicle’s defective condition. Ford was notified and did nothing to resolve any matter. The vehicle stalled on th interstate in [XXX] while traveling to vacation. Ford has not reimbursed me all of my money. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 29, 2026 · Engine · 60,000 miles · MI

The contact owns a 2021 Ford EcoSport. The contact stated that while driving 60-65 MPH, the low oil pressure warning light was illuminated. The contact exited the highway and pulled into a truck stop service station, where the contact was informed that the oil level was normal. The contact resumed driving, and the check engine warning light illuminated while pulling out of the parking lot. The contact was able to drive to the nearest Walmart station, but no technician was available. The vehicle was taken to O'Reilly, where the vehicle stalled upon pulling into the parking lot. The vehicle was diagnosed with an undisclosed failure. The vehicle was towed to the dealer, where it was diagnosed and determined that the engine had failed. The dealer determined that the failure was related to a recall. The dealer sent a claim to the manufacturer, and the manufacturer informed the dealer that the recall part was shipped. However, upon following up with the dealer, the contact was informed that the part could not be tracked, and there was no estimated time for arrival. Additionally, the contact was informed that the manufacturer was sending 60-80 parts to the dealers nationwide, per week. The vehicle was not yet repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 60,000.

Filed Apr 21, 2026 · Engine · 60,000 miles · NJ

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at an undisclosed speed on the turnpike, the vehicle made an abnormal sound before it stalled. The vehicle was pulled over to the side of the road. The vehicle was towed to the dealer where it was diagnosed with engine failure. The failure was associated with the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

Filed Mar 26, 2026 · Engine · NJ

My Ecosport prior to going to Celebrity Ford had no mechanical and electricial issues. It went to into Celebrity Ford of Toms River for the Engine Pump Recall on Dec. 23, 2025. I did not get the vehicle back until Feb 4, 2026 after major engine work was completed by Celebrity Ford. Substantial engine parts replacement—was performed as part of this recall repair (can been seen on service invoice). Since that installation, the vehicle has had continuous mechanical problems that did not exist beforehand. Since then, the vehicle has had multiple mechanical and electrical failures- from "Full Accessory Power Message" along with numerous times failing to start with multiple warning lights illuminated as well as the most recent incident on March 5th. While driving home from work on the Garden State Parkway at 70 mph, my vehicle began to shudder/ shake violently almost stalling with lose of power along with the check engine light blinking from an engine that had significant work done according to the first service invoice from 12/23/25 to 2/4/26. At the time, I was in the center lane. I had to carefully maneuver across parkway work traffic to the right lane while my vehicle continued operating abnormally. This was a frightening and dangerous experience that could have resulted in a serious accident.Since bringing my vehicle in for this recall, it has experienced repeated failures and serious safety concerns that have made it unreliable and unsafe to drive due to Celebrity Ford's liability issue for negligence and improper recall repair. Celebrity Ford performed the recall repair, installed/ replaced major engine components, caused repeated breakdowns and now is disrepair to a vehicle that was in perfect working condition prior. I am seeking accountability for the damage caused and a resolution to this ongoing issue. I do not have my vehicle currently as they are still trying to duplicate the concern and in contact with a "Hotline" team with no ETA of completion.

Filed Nov 21, 2025 · Engine, Transmission · FL

23S64-Engine Oil Pump RECALL 8/19/2025 driving from Hillsboro Beach, Florida to St. Petersburg, Florida. We had a full engine seizure, we lost oil pressure, and also lost use of the transmission. We overheated and the engine seized. With a loss of power, we had to guide the car off the road. The engine was smoking heavily. The back of the car was completely covered with motor oil. The Florida Highway Patrol called us a tow truck that took us to DeSoto Ford, 3039 Southeast Highway 70, Arcadia, Florida, 34266, 863‑494‑4848. DeSoto Ford ended up doing multiple repairs on the car. They did the replacement of the 23S64 recall for the oil pump belt and tensioner. The car was there for 24 days. We drove down on 9/12/25 and picked up the car. When they pulled the car out, the car was still covered in oil in the back. We found out within days that they neglected to fix the radiator. Once we got into the car and started driving, we had yet another very loud noise, forcing us to bring it to AutoNation, St. Pete, Florida. At AutoNation, we had a multitude of problems with it. We had severe vibration with the car when we brought it there 9/18/25. This was only a few days later. They changed out the radiator and replacing the full radiator because they said there was a full leak that was not fixed by DeSoto. They fixed the car and gave it back to us 9/30/25. On 10/22/25, I had the exact same experience with the car that we originally had on the highway in Arcadia. The engine fully seized in the intersection of 3rd Street South and 6th Ave south in St Petersburg just as it had done before. The car overheated and had full loss of power/motive power. I was able to restart it briefly to get out of the cross section. The car stalled two more times before I was able to bring it to a safe place. We ended up having it towed from 15th Ave S at 3rd Street S and brought to AutoNation. Vehicle broke down again 11/7 and has been in shop ever since. Much more details available.

Filed Nov 6, 2025 · Engine · 56,971 miles · MO

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at various speeds, the message "Charge System Fault" displayed on the instrument panel. The contact stated that the vehicle almost stalled, and the vehicle was running rough. The contact was aware of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The contact had taken the vehicle to a local dealer, who diagnosed the vehicle and determined that the oil pump had failed and damaged the engine. The contact was informed that several parts needed to complete the repair were on a national back order. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 56,971.

Filed Sep 27, 2025 · OH

The affected component is the oil pump drive belt and belt tensioner. This defect can cause loss of oil pressure and engine failure. Parts for the official recall remedy have not been made available by Ford or its dealers. My vehicle is available for inspection upon request. Safety Risk: This failure poses a serious safety risk. Loss of oil pressure or engine seizure can occur suddenly, causing the vehicle to stall while driving. This results in loss of motive power and potentially reduced braking assistance, placing myself, passengers, and other motorists at risk of a crash. Confirmation by Dealer/Service Center: The dealer confirmed the recall but stated that the parts remain unavailable and no final remedy is being offered at this time. Interim remedies are inadequate, leaving me to continue driving an unsafe vehicle.

Filed Jun 11, 2025 · Engine · 40,000 miles · TX

The contact owns a 2021 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V9055000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 70 MPH, the vehicle stalled. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the engine had failed, and the failure was related to the recall. The dealer replaced the engine free of charge; however, the contact stated that she was concerned that the failure would reoccur. The vehicle was repaired temporarily. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and denied the request to buy back the vehicle. The failure mileage was approximately 40,000. VIN tool confirms parts not available.