car has 63000 miles and engine needs replaced because there is antifreeze getting into cylinders. had checked at a service station. safety concern is gasket may fail allowing antifreeze to shoot onto block causing fire. there's a recall for the 2.0 ecoboost from 2015 to 2018 for this same problem but vehicle isn't under a recall. also engine light has come on 2 times. if reset the computer light turns off for a little while then comes back on. this started 3 weeks ago. also vehicle runs rough at cold start up and blows out white smoke.
2016 Ford Edge engine complaints
Page 6 of 15: complaints 131 to 160 of 414, newest first, as owners wrote them.
The contact owns a 2016 Ford Edge. The contact stated that while operating the vehicle, the check engine warning light remained illuminated and the message "Coolant Temperature High" was displayed. The vehicle was taken to the local mechanic who diagnosed and determined that there was coolant inside the engine. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were not yet contacted. The failure mileage was 86,000.
The contact owns a 2016 Ford Edge. The contact stated that while his daughter was driving at unknown speeds, the check engine warning illuminated. The vehicle was taken to an independent mechanic, who determined there was an error code related to a coolant intrusion into the cylinder. The contact called the local dealer, who informed him there was no recall coverage. The vehicle was not diagnosed or repaired. The dealer referred the contact to the federal safety agency Hotline. The manufacturer was not contacted. The failure mileage was approximately 45,000.
2016 Ford Edge Titanium with 58800miles, brought to Ford Dealership with check engine light on, diagnosed with blown cylinders/engine failure, requiring engine replacement. Replacement quote is $9900. Out of warranty, no customer support assistance, less than 60000miles. Known engine issues with 2.0 Ecoboost by Ford, but no recall.
Check engine light was on and took to ford dealership and code is P0304. Coolant is leaking internally into cylinder.
The contact owns a 2016 Ford Edge. The contact stated that upon starting the vehicle, the check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the vehicle had backfired, and the dealer determined that the spark plugs needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the local dealer, where it was diagnosed that the engine was fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and a case was opened. The manufacturer referred the contact to the federal safety agency hotline for assistance. The failure mileage was approximately 73,000.
Engine block crack leaking coolant into the cylinders. This was evident by white smoke coming from the tailpipe. This was confirmed by an independent mechanic who did a compression test on each cylinder and was able to identify the location of the cracked block.
Engine blew at 67,334 miles. Had complete new replacement. New engine blew at 116,239 miles
The contact owns a 2016 Ford Edge. The contact stated that while driving at various speeds, there was a cloud of white exhaust coming from the tailpipe causing an odor of exhaust to emit from the vehicle. The contact, an independent mechanic, had inspected the vehicle and noticed water leaking into the cylinders. The contact replaced the water pump, thermostat, and temperature sensors. The failure persisted. The contact stated that after some research, the contact learned it was a known failure that required the engine to be replaced. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure. The manufacturer had referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was unknown.
The contact owns a 2016 Ford Edge. The contact stated while driving at an undisclosed speed, there was coolant cooling leaking into the cylinder and the vehicle made an abnormal sound. The vehicle was able to restart on the third attempt; however, the failure recurred. The vehicle was driven to the independent mechanic and was diagnosed and determined that engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 85,000.
We are Canadians live in Calgary, AB Canada. We have a 2016 ford egde. There was an engine warning sign popped up when we had a road trip in US days ago. We also noticed that the car chokes when cold start with white sweet smoke come out. We had the car checked up by a ford dealer at coos bay, Oregon. Here is the diagnostics - dtcp0303 stored related to cylinder 3 misfire - found engine coolant level low - topped off coolant and pressure tested system - found pressure to bleed off abnormally - no external leaks observed - removed aprk plug and bore scope cylinder - verified coolant intrusion in cylinder 3 also found signs of burning coolant on spark plug - recommended repair is long block replacement. We cancelled our unfinished trip and struggled to drive 2000km back home(low speed, keep checking/adding coolant and engine oil). The local ford dealer quoted me 10k CAD to replace the long block. Our car is not even 8 years old at 130K kms. I called Ford Canada and was told they are sorry but the car is out of warranty and no recalls. Although there is a TSB#22-2229 which proves this is a known issue to Ford. I spent some time search on line found many ford owners had same experience and referred by them to post a complain here.
Coolant is leaking into the engine. My car unexpectedly and very suddenly started overheating while driving, without any warning that coolant levels were low. The car was inspected by the dealer's service center, and they confirmed this issue, stating the only solution is to completely replace the engine. The check engine light on the car did come on, but the code was related to an engine misfire. I had spark plugs and an engine coil replaced, but after a few days, the check engine light came back on with the same code of an engine misfire. One day while driving, the temperature gauge warning came on, saying that the temperature of the car was too high and to stop driving immediately. At this point, I checked under the hood and saw that the coolant overflow tank was completely empty.
My Ford Edge was running rough and white smoke was coming out of the exhaust. Tge engine light came on my dashboard. I took it to MasterTech in Dimondale MI on July 5, 2024 and they said coolant is leaking into the 4th cylinder. He said Ford recommends an engine replacement for the issue. He said Ford knows about this issue with the ecoboost engine. I have 88,000 miles on my car and shouldn't need a new engine. I have not taken it to the dealership because they charge to look at the car. They said they know about the issue but there is not a recall and it would cost $9,000 to fix. I have been informed that it is possible that the car will catch on fire.
The contact owns a 2016 Ford Edge. The contact stated that when the vehicle was started, there was white smoke coming from the exhaust pipe. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 49,500.
When starting white smoke appeared for about 5 minutes. Check engine light came on 2 weeks ago after getting my oil changed. Car felt like it had lost its power and/or pep when accelerating. Found P0301 & P0316 engine misfires. TSB 22-2229 applies to concern. Performed coolant pressure test for 2 hours, removed cylinders 1 & 2 plugs inspected with bore scope and found coolant present in cylinder1, indicating coolant intrusion. Recommend replacement of engine long block as per TSB 22-2229 and retest. Also, bushing shifter cable recall was completed as well. Went to Bruce Titus Ford, Inc. Port Orchard, WA today [XXX] . This is what the service department diagnosed my 2016 Ford Edge SEL AWD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Coolant leaked into engine causing cylinder to crack. The entire engine needs to be replaced. Codes showed misfires.
My Edge has 41,000 miles on it and the engine light came on. I took it to my local dealership and they found that it has coolent intrusion and therefore I need a new engine. The dealership told me there is a TSB# 22-2133 (2.0L EcoBooser - Coolant in Cylinders) for this issue but Ford never issued a recall. I did my own research to find out that there is a class action lawsuit in the Eastern District Court for this exact issue. I contacted Ford Corporate and they said they know nothing about this issue but would help expedite the repairs of my vehicle. The TSB I looked up is directly from Ford so I am a little preterbed they aren't taking responsibility for this. Engines and rental cars are not cheap.
The contact owns a 2016 Ford Edge. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to the local mechanic who diagnosed a misfire in cylinder #3. The cylinder #3 spark plug, and ignition coil were replaced; however, while driving 55 MPH, the message "Engine Over Heating" was displayed. Upon inspection, it was discovered that there was no coolant in the coolant reservoir. The contact added coolant and the vehicle was driven to the residence. The cause of the failure was not yet determined. The local dealer was notified. The manufacturer was not yet contacted. The failure mileage was 122,000.
Coolant disappearing without leaks took the vehicle to Parrish Motor Co. in Goochland Va. The diagnostics showed the engine was blown. Per Ford Forum and Reddit this has been an ongoing issue with the 2.7 Edge Ecoboost. My parents are [XXX] and [XXX] on a fixed income and brought this car brand new always took care of the maintenance but there has been several recalls for major reasons since they have owned this vehicle and it’s paid for by individuals that don’t have the $8000.00 for a new motor on a vehicle that’s paid for. Started late July 2024, vehicle currently at dealer, [XXX] drives vehicle if stranded not able to walk far. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Faulty engine design leads to head gasket failure, engine misfire and stall. Engine stall can cause loss of vehicle motive and braking by loss of vacuum assisted braking. Dealer just completed service on this vehicle and reported the failure after completing repair on another defective part, the flexplate assembly. After completing repairs advised it likely has coolant intrusion issue. Did not inform customer about the TSB showing FORD determined the block is defective and should be replaced at customer cost. Ford has known about this issue since about 2011. These engines need to be recalled. Repair data available to mechanics and on popular video sites show that Fords updated block removes two water paths that interfere with head gasket seating on 2015 - 2019 Ford Edge 2.0L EcoBoost engines. This is a known manufacturer defect that puts owners and occupants in uneeded danger due to Ford's refusal to recall and rectify these engines. There are multiple reports of these engines failing for this issue with as few as 30,000 miles. This engine is also installed in multiple other Ford and Lincoln vehicles including focus, fusion, taurus, Escape, edge, mkz, mkc, and nautilus.
The contact owns a 2016 Ford Edge. The contact stated that the check engine warning light illuminated intermittently. The contact stated that while refueling, the accelerator pedal had to be slightly depressed to prevent the vehicle from stalling. The vehicle had been taken to the dealer where it was diagnosed and determined that ignition coil #3 had failed and needed to be replaced. The vehicle was repaired. The contact stated that after the repair, the vehicle would emit excessive exhaust fumes when accelerating and while starting the vehicle. The contact stated that the vehicle was choking and hesitating while starting the vehicle. Additionally, coolant had to be added every other day. The contact stated that the check engine warning light remained illuminated. The contact became aware of Technical Service Bulletin: 22-2134, the federal safety agency ID Number: 10210392 (Engine and Engine Cooling, Equipment). The dealer was contacted and informed the contact that due to the failure being persistent, the short block needed to be replaced. The dealer confirmed that the VIN was not included in TSB. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed the VIN was not included in a recall. The manufacturer had referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 14,500.
Coolant intrusion into cylinder 4, apparently due to a design flaw. Ford knows about this problem but won't pay to fix. New motor is required at the cost of $8300. This vehicle only has 88300 miles
I'm filing a complaint regarding my 2016 Ford Edge Titanium with the 2.0L EcoBoost engine, which required two engine replacements due to a defect causing coolant intrusion into the cylinders.The engine failed due to coolant leaking into the cylinders, a problem diagnosed and confirmed by Ford technicians. Both engines are no longer in the vehicle, but documentation is available upon request. My safety and the safety of others were put at significant risk on two separate occasions. The first engine failed at 67,000 miles, leading to the engine blowing while I was driving on the highway. This nearly caused an accident as the vehicle suddenly lost power. The second engine, which was a replacement from a 2018 Ford Edge with the same 2.0L EcoBoost engine, also failed in a similar manner at 87,000 miles, again while I was driving on the highway. On this occasion, I was left stranded on the side of the highway in the desert for 7 hours in over 100-degree weather, further endangering my safety. The problem was diagnosed and confirmed by a Ford dealership on both occasions. The first failure was diagnosed as coolant leaking into cylinder 3, causing the vehicle to misfire and eventually leading to the engine blowing. The second engine was inspected by a Ford repair technician during a recall service, where the same coolant leak issue was diagnosed. Less than two months after this diagnosis, the second engine also blew while I was driving. Ford service technicians inspected and confirmed the problem both times. Repair and diagnostic reports are available. The first indication of the problem with the original engine was a check engine light so I took the vehicle to Ford. The dealership diagnosed the issue as coolant leaking into cylinder 3, causing misfires. Despite this diagnosis, the engine failed before I could arrange for the recommended long block replacement. The second engine began exhibiting the same symptoms—misfiring and coolant loss—shortly before it also failed.
The contact owns a 2016 Ford Edge. The contact stated that when the vehicle was started, on several occasions the contact observed a rattling sound coming from the engine compartment. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the flex plate had cracked and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 133,000.
Engine is overheating the car is missing real bad. Allpro mechanic evaluate the car and replace the spark plugs. Antifreeze continues to leak into the engine. Mechanic said the engine block needs to be replace.Capstone Law has a class action suit against Ford for this very issue.
I'm filing a complaint regarding my 2016 Ford Edge Titanium with the 2.0L EcoBoost engine, which required two engine replacements due to a defect causing coolant intrusion into the cylinders.The engine failed due to coolant leaking into the cylinders, a problem diagnosed and confirmed by Ford technicians. Both engines are no longer in the vehicle, but documentation is available upon request. My safety and the safety of others were put at significant risk on two separate occasions. The first engine failed at 67,000 miles, leading to the engine blowing while I was driving on the highway. This nearly caused an accident as the vehicle suddenly lost power. The second engine, which was a replacement from a 2018 Ford Edge with the same 2.0L EcoBoost engine, also failed in a similar manner at 87,000 miles, again while I was driving on the highway. On this occasion, I was left stranded on the side of the highway in the desert for 7 hours in over 100-degree weather, further endangering my safety. The problem was diagnosed and confirmed by a Ford dealership on both occasions. The first failure was diagnosed as coolant leaking into cylinder 3, causing the vehicle to misfire and eventually leading to the engine blowing. The second engine was inspected by a Ford repair technician during a recall service, where the same coolant leak issue was diagnosed. Less than two months after this diagnosis, the second engine also blew while I was driving. Ford service technicians inspected and confirmed the problem both times. Repair and diagnostic reports are available. The first indication of the problem with the original engine was a check engine light so I took the vehicle to Ford. The dealership diagnosed the issue as coolant leaking into cylinder 3, causing misfires. Despite this diagnosis, the engine failed before I could arrange for the recommended long block replacement. The second engine began exhibiting the same symptoms—misfiring and coolant loss—shortly before it also failed.
coolant intrusion into the engine’s cylinders, which caused my engine to fail and ford failed to disclose these defects when I bought it now my engine has failed and I can not afford to fix it or buy another if my extended warranty wont cover it
The coolant is leaking into the engine causing misfire, and overheating.
Code for Cylinder #2 Miss Fire. Upon inspection by pressurizing the coolant tank it was observed to have coolant leaking into cylinder #2
Motor has known manufacturing defects. Was told by Ford dealership. Needs a motor at 118k miles
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford Edge?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history