2017 Ford Edge fuel system problems

Filed Nov 5, 2026 · Engine, Fuel system · FL

Vehicle Safety Complaint – 2017 Ford Edge 2.0L EcoBoost VIN: [XXX] the federal safety agency Service Request: XXX I am submitting a formal vehicle safety complaint regarding a 2017 Ford Edge equipped with the 2.0L EcoBoost engine. The vehicle has experienced recurring overheating problems, including at highway speeds. Multiple diagnostic and repair efforts have been undertaken, including replacement of cooling-system components and evaluation by an authorized Ford dealership. The case involves suspected coolant intrusion into the engine, a condition addressed in Ford Technical Service Bulletin 22-2229. I have sought assistance from Ford Motor Company and requested a technical review and goodwill consideration. I am concerned that this condition could cause unexpected engine overheating, loss of engine power, or engine failure while driving, creating a potential safety hazard. I respectfully request that the federal safety agency review this complaint, consider the available Ford diagnostic documentation, and evaluate its relevance to investigation DP26-008. Please assign an ODI Complaint Number and advise whether additional documentation is required. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 9, 2026 · Engine, Fuel system · MI

The coolant is getting consumed by the engine. I need to add coolant every so often and there is no visible leaks in the hoses. It cause the check engine light to come on, a rough idle at start, and a cylinder to misfire.

Filed May 20, 2026 · Engine, Fuel system · VA

Recently I have noticed, in my 2017 Ford Edge SEL, that my coolant level in reservoir has been low a few times with no puddling anywhere under car. I have read that this is a known issue with this vehicle that has the 2.0L ECOBOOST engine. What can be done about this? From what I have been reading, this a design issue that Ford knows about but has not offered a fix. The cost to replace the engine is more than vehicle is worth. Is there some financial assistance or full coverage to cover the cost for my vehicle to be fixed? This has been an ongoing issue starting with, shifting hard at times, coolant loss with no explanation, and rough idling after cold start.

Filed Mar 10, 2026 · Fuel system · WI

The check engine light is on and upon diagnostics it shows there is an issue with the EVAP purge valve. This cause the vehicle to have problems starting when refueled. Cost of the repair is around $1000 due to where the valve is.

Filed Oct 7, 2025 · Brakes, Driver assistance · 94,000 miles · SC

The contact owns a 2017 Ford Edge. The contact received notifications of the federal safety agency Campaign Numbers: 25V544000 (SERVICE BRAKES, HYDRAULIC) and 25V572000 (BACK OVER PREVENTION). However, the parts to do the recall repairs were not yet available. The contact stated that while driving at various speeds, the brake pedal was depressed but traveled down to the floorboard. The contact stated that while driving, the brake pedal was vibrating. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that on a separate occasion; after refueling the vehicle, the vehicle was restarted and jerked and then stalled. The oil pressure warning light illuminated and remained illuminated. After several attempts, the vehicle restarted. The contact depressed the accelerator pedal several times to prevent the vehicle from stalling. The vehicle then functioned normally. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The failure mileage was approximately 94,000.

Filed Sep 30, 2025 · Engine, Fuel system · FL

Faulty fuel pump, vehicle stops while driving and rolls backwards

Filed Sep 22, 2025 · Brakes, Fuel system · 210,000 miles · MS

The contact owns a 2017 Ford Edge. The contact received notification of the federal safety agency Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormally loud sound. The brake warning light was illuminated. The contact stated that the front brake pads had previously been replaced. The vehicle was towed to an independent mechanic, who determined that the flywheel had fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 210,000.

Filed Jun 5, 2025 · Engine, Fuel system · CA

The 2.0 ecoboost engine 2017 Ford Edge Titanium coolant leaking into many places. White smoke coming from exhaust flooding into the streets I have been told the Long block issue as well. The vehicle was at an independent service center where it sat for over three weeks while they worked hard trying to find the issues. Finally they advised me to get a second opinion through Ford which I did for over $300 for the same inspection. They have given me an outrageous estimate of over $16,000 to repair the issues. This is a common issue with this particular engine. I have read numerous complaints since purchasing it . Ford needs to be held accountable for all these defective engines they have yet to recall these dangerous vehicles. My vehicle is currently sitting in storage because it is inoperable. I’m still making loan payments on this defective vehicle. I have reached out to Ford many times for assistance and they have turned me away. I will soon have to file a Lawsuit against Ford if they do not come forward and resolve this issue. I will never ever purchase another Ford.

Filed Feb 27, 2025 · Brakes, Fuel system · WA

On multiple occasions, the climate control system cuts out causing no defrost, the wipers stop working, and while driving the rear brake line failed which almost caused an accident. Ford stated it was outside of the warranty however the vehicle is driven only on streets and seems like a strange failure.

Filed Jan 7, 2025 · Engine, Fuel system · UT

Took my car to my mechanic said that coolant was draining into my 2.0 ecoboost engine in cylinder 4 causing misfire, white smoke to come out of my pipes, sweet antifreeze smell in the cabin. Have to constantly dump coolant into the car so that it doesn't over heat.when i start the car in the morning it acts as if the car is going to die if I don't hit the gas. Contacted ford, they said it was my problem. I bought the car a year ago. It started at about 72000 miles.