What happened: The torque converter/transmission system failed. My 2019 Ford Edge (VIN [XXX] , 75,000 miles) experiences a shudder and vibration under 60 mph during normal driving, with no diagnostic trouble codes present. This matches the condition described in Ford Technical Service Bulletin (TSB) 25-2154 for the 8F35 transmission. The vehicle is available for inspection upon request. Safety risk: The shudder occurs during acceleration and highway merging. It causes the vehicle to hesitate and lurch, which puts myself, passengers, and nearby drivers at risk — especially when merging into traffic or crossing intersections. Loss of smooth power delivery creates a hazard that could result in a collision. Dealer confirmation: The problem has been diagnosed and confirmed by an authorized Ford dealer, who quoted approximately $2,800 for repair (torque converter replacement and PCM reprogram). Manufacturer involvement: The issue was presented to Ford Motor Company, who acknowledged the TSB exists but denied goodwill assistance to cover the repair, even though this is a known defect. Inspections: The vehicle has been inspected by the Ford dealer’s service department. No inspections have been performed by police or insurance representatives. Warning signs/symptoms: There were no warning lamps or error messages. The first symptoms (shuddering and jerking below 60 mph) appeared around [insert month/year you first noticed]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2019 Ford Edge engine complaints
Page 3 of 7: complaints 41 to 70 of 185, newest first, as owners wrote them.
I am a loyal Ford customer reporting a serious issue with my 2019 Ford Edge, which has about 53,000 miles and is equipped with the 8F35 transmission. The vehicle is experiencing shuddering, bucking, and jerking during acceleration, especially at speeds up to 35 mph. In addition, the auto Start/Stop accumulator switch no longer functions. These issues directly match the conditions described in Technical Service Bulletin 21-2081 and Safety Recall 20S49, yet my VIN is not included in the Safety recall because the part was not assembled at the Oakville plant. I strongly believe this exclusion is unfair and irrelevant—my vehicle has the same defective part and is experiencing the same failures. Ford now recommends replacing the torque converter because the lock-up clutch broke apart, which means metal debris already entered the transmission. This is not a minor issue, and I do not want a temporary or partial fix. I am requesting a full replacement of the transmission—not a refurbished unit—as this damage is systemic and not my fault. These problems have created unsafe driving conditions and have already cost me approximately $7,000 in repairs. I’ve paid $1,300 out of pocket, and while Ford has offered about $2,700 discount, I am still left with about $4,000 balance for a defect I did not cause.
The torque converter is bad and is sputtering, jerking, not shifting, hard shifts, this is not safe. This is a danger to me and others when the car is jerking and not shifting correctly, safety hazard! Ford dealer confirmed the torque converter is bad. Hundreds, if not thousands of others complaining about their Ford Edge having the same issue. No warning or other problems, or symptoms, it just started jerking and sputtering.
Design flaw in engine which causes coolant intrusion into the cylinders causing misfires, overheating, and white smoke out of the exhaust. The vehicle is unsafe to drive due to the engine overheating. The vehicle has been inspected by a licensed mechanic that confirmed all of the above. The engine temperature would overheat and there was white smoke coming out of the exhaust upon starting the vehicle.
All lights came on randomly ford house said it was the torque converter
Samochodem szarpie na niższych biegach, nierówno chodzi silnik i przy zmianie biegów też szarpie.
vehicle hesitates while accelerating
My 2019 Ford Edge begin to stutter after I reached 60k miles. When I accelerate it stutter between 15-35 MPH I called Bill Brown Ford spoke to a service advisor , she stated it’s in the transmission so I took my vehicle to a transmission shop was informed nothing wrong with trans. The car jerks during take off biggest fear it shutting down while driving. No warning signals in the dash just begin to drive differently during take off. Too many complaint for this not to be listed as a recall before someone gets hurt.
I was driving to work on a busy street, started accelerating and the car completely shut down on me. I had to come to a complete stop on the main road during morning rush hour. Was close enough to idle into a parking lot. All my dashboard lights started flashing with an "Engine Coolant Over Temperature" alert. No throttle response. Had to have the vehicle towed to the Ford dealership where they determine that the coolant was leaking into the engine. Replaced the EGR cooler ($2300). Drove off the lot and the vehicle was shuttering upon acceleration. A( A known issue with the Ford 2.0 ecoboost engines but yet there is no recall) after diagnosing, Ford came back and said I need to replace the torque convertor ($3100). This is a 2019 vehicle with 84,277 miles on it. These issues SHOULD NOT be happening. Ford has done nothing but issue TSB's on them.
Last year, the 2.0 ecoboost had a coolant intrusion. After 2 times ford dealer talking with someone in company, the repacerd egr valve, egr cooler and finally had a long block motor installed. Then a little while later had to replace transmission, then the steering box. My extended warranty covered this but it ran out at the end of May. I think I should be compensated either by extended warranty or money. Any of those problems could have resulted in an accident. First took to Lynn layton ford in decatur, took back a couple of weeks and could not get to it, took to eddie pruitt ford in hartselle, where they took care of the problems.
Without warning or prior issues, while driving the car on a busy street the check engine light came on, the car shook and locked up/stopped suddenly. I was almost rear ended. The car would not restart. A known TSB is in place for this car and the head gasket design flaw allows coolant into the engine causing it to seize on even low mileage cars (under 46,000 miles). 19 year old female left stranded in highway after a near collision. Ford needs to be forced to recall these engines and fix this design flaw!
Torque Converter issue, vehicle shakes or stutters, or bucks when switching gears. It starts when I reach around 23 mph, comes out of it between 28-32, but then it happens again at 43-48. This is especially noticeable after being stopped at stop signs or red lights. Local dealer is aware. My mothers car (same make, model, year is having the same issue) No lights or anything come on.
Blown head gasket due to faulty engine block design
The problem is the torque converter. It causes a hesitation when accelerating from being stopped, usually around 30-43 mph is when the car acts like it isn't going to speed up and slows down instead of speeding up. I had the torque converter replaced once in Sept. 2024. My car has 82,213 miles. I took my car in today 8/5/25 and was confirmed that the torque converter need to be replaced again. The Ford service department told me that they have had 8 - 10 Ford Edges come in in the last 2 weeks with the same problem. I have 2 family members that have Ford Edges that is having the same issues.
The contact owns a 2019 Ford Edge. The contact stated while driving 45 MPH, the vehicle lost automotive power. The contact stated that the vehicle started jerking with white smoke coming from the rear end of the vehicle. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was advised that the engine was faulty due to coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 33,867.
Vehicle fails to utilize auto stop/start. Vehicle engine light comes on and off constantly. Vehicle hesistates, jerks forwards, sputters, and does not gain speed properly at any given time. Vehicle was looked at off an on for over 4 years by north brothers ford of michigan. They said on mutiple occasions car is fine and all symptoms are normal even as 4 other cars were brought in and again they said this was all normal. All of this off and on from about year 1 of purchasing vehicle till now (7/30/2025) and problems are still on going. Transmission has been rebuilt, oil changes regular, tune up performed. Coils replaced on prior services due to issues noticede by maintenance team.
Transmission is shuddering and jerking
Longblock engine cracked between the 2nd and 3rd cylinders due to coolant intrusion without any warning. No lights indicated low coolant nor that the temperature was rising. My car kept stalling at stop lights but would restart. By the time I got home, white smoke was coming from exhaust and it smelled like fireworks. It has 38,997 miles but is 6 years old and out of warranty. Ford wanted $12,691.17 to install a new engine with only a 1 year warranty. I had the engine replaced with a used engine and before I could get the car home, the replacement engine block cracked in the same place as mine. That engine only had 40,000 miles. Ford claims no issues with my car but the 2018 and 2017 Edge's have a recall for the same issue. This is not true!!
The contact owns a 2019 Ford Edge. The contact stated that the vehicle failed to immediately start. The contact stated that after the vehicle was started, while driving approximately 15 MPH the vehicle stalled. The vehicle was towed to the local mechanic and was diagnosed with coolant intrusion in the engine cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 61,500.
Vehicle has 71,452 miles and has started using coolant and the wrench and check engine light are coming on. This is a known issue in other years of ford vehicles and this vehicle should also be included in the recall.
Our 2019 Ford Edge (purchased in November 2018) has had a coolant leak into the engine's cylinders. As a result we are facing an estimated $12,000 expense to essentially rebuild the engine. In doing some research, it appears as if there is a class action lawsuit already filed against Ford for the 2015-2018 Edge. Our situation is exactly the same as that described in the lawsuit. Therefore, it seems as if Ford still has not rectified the issue.
The contact owns a 2019 Ford Edge. The contact stated that the check engine warning light was illuminated. The contact used a vehicle scanner to scan the vehicle. The contact retrieved DTC: P0446 (Evaporative Emission Control System (EVAP) vent control circuit malfunction). Additionally, the contact stated that the infotainment system was frozen and was inoperable, and there was rust underneath the hood because the vehicle was not equipped with a hood shroud. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 64,000.
In November 2024 Customer Complaint: Engine/transmission is sputtering on acceleration between 20–40 MPH. Code Pulled: Misfire code on Cylinder 4. Action Taken: Swapped ignition coil from Cylinder 4 to 3. Removed spark plug and noted wear/carbon tracing. Replaced all 4 spark plugs with Motor craft SP-594 (ASP594). No misfire present after repair. Same misfiring issue returns May 2025.
Engine - Yes it is available for inspection. Approximately a year/18 months I was driving on the interstate and the engine shut down. I was required to pull over four lanes with no power. I took it to a Ford dealership in Franklin, TN. Supposedly it was fixed. However I now have a problem with the engine missing. I took it to my routine service repair center and their mechanic advised me coolant was seeping into the engine block. No messages or warnings were desplayed.
The contact owns a 2019 Ford Edge. The contact stated that while operating the vehicle, the message "Coolant Overheated" was displayed, and the vehicle suddenly shut off. The contact stated that moments later, the vehicle was restarted and driven to the residence and examined by an independent mechanic. The contact was informed that the head gasket had blown. No further information was available. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 134,000.
While driving my RPM's dropped to 0 and my car stalled out. I was able to drive home by doing this a few more times. Then white smoke starting coming out of the exhaust and it smelled like fireworks. No warning lights came on and my Ford Pass app did not indicate there was a problem. I had it towed to AAA then had to have it towed to dealership. They told me I needed a complete new engine. It is a 2019 Edge Titanium with 4 cylinder 2.0L ecoboost turbo with 38997 miles! They started it was due to coolant intrusion. The 2018 Edge has a recall for this exact issue but not the 2019!! $12691.17 to replace the engine!
Torque converter Transmission! The whole car shudders when going from 10mph to 25/30mph. Shudder/shaking while accelerating Low mileage @ 67k miles
My 2019 Ford Edge with the 2.0L EcoBoost engine began experiencing a misfire, loss of power, and white smoke from the exhaust. No engine light was on when it started and the car has less tan 46K miles. I had the car towed to a certified mechanic and he confirmed that coolant is leaking into my cylinders, which matches the issue described in Ford TSB 19-2346. This appears to be a widespread manufacturing defect affecting many vehicles with this engine. The presence of coolant in the combustion chamber caused catastrophic engine failure and poses a safety risk due to sudden loss of power while driving. I have been told that to fix the issue I need to replace the whole engine. Repair costs are estimated at $10,600 for an engine replacement at a local repair shop. I would expect it to be even higher from a Ford dealer. Ford has acknowledged this defect in a TSB 19-2346, but no recall has been issued. I am submitting this complaint so the federal safety agency is aware of the defect and its safety implications. I urge the federal safety agency to investigate this issue and require Ford to take responsibility.
Shuttering transmission/bad transmission under 100,000 miles
The contact owns a 2019 Ford Edge. The contact stated that while driving at various speeds, the vehicle was driving rough, and the temperature gauge indicated that the engine was overheating. The contact stated that on several occasions, the vehicle stalled. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that there coolant inside the engine, causing the engine to overheat. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 71,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ford Edge?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history