1. The transmission/torque converter causes the car to shift randomly causing almost constant jerking motion especially between 10-40 mph. This tends to lead to reduced power output as the car is constantly shifting gears or stuck is an incorrect gear. Yes, it is available for inspection. This issue is described in TSB 21-2389, which I have had preformed on the vehicle by ford but did not fix the issues. 2. Safety is impacted by the shifting gear reducing the available power output and inconsistent speeds. 3. I have had it in with the Ford Dealership and an independent mechanic. Both could reproduce it. Ford updated the software per TSB 21-2389 which is supposed to address the specific problem, but it did not fix it. The independent dealer reset the control unit, but that also did not fix the issue. 4. Only the ford dealership and independent mechanic. 5. There are no warning lamps or messages.
2019 Ford Edge engine complaints
Page 4 of 7: complaints 71 to 100 of 185, newest first, as owners wrote them.
The contact owns a 2019 Ford Edge. The contact stated when the vehicle was started, the contact noticed white smoke coming from the exhaust. In addition, the contact noticed a burning odor on the interior of the vehicle. No warning light was illuminated. The vehicle was driven to the residence. The contact stated that later in the day, the contact's husband was driving the vehicle and the failure reoccurred. The contact's husband parked the vehicle and checked the coolant level. The contact's husband noticed that the coolant reservoir was almost empty and noticed a burning coolant odor. The vehicle was taken to an independent mechanic and was diagnosed with coolant intrusion and engine coolant. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was referred to the federal safety agency Hotline to report the failure. The failure mileage was approximately 50,000.
The contact’s wife owns a 2019 Ford Edge. The contact stated that on several occasions while driving at various speeds, the vehicle jerked when the accelerator pedal was depressed, and the vehicle lost power. The check engine, power train, and several other unknown warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the wastegate was stuck closed in the turbocharger valve, and the turbocharger valve needed to be replaced. The vehicle was repaired but the failure reoccurred four months later while driving at an undisclosed speed. The contact stated that during the failure, the vehicle lost power and failed to accelerate as intended. The vehicle was taken to an independent mechanic again where it was diagnosed that the wastegate was stuck closed again, and turbo turbocharger valve needed to be replaced. On another occasion, the contact stated that while driving 30 MPH, his wife observed white smoke coming from the exhaust pipe. The contact stated that his wife then observed that the EGR and check engine warning lights were illuminated. The message "Engine Overheating” was displayed. The vehicle was steered off the highway and restarted three times after cooling down and was taken back to the same independent mechanic, where it was diagnosed that the EGR valve had failed, the coolant level was low, and there was coolant passing through the exhaust EGR coolant system and had leaked into the exhaust system. The contact was informed that the EGR system needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 33,654.
my wife was driving on [XXX] made a left turn on to [XXX] had enough time but because the Transmision slip on the car slowed down and the car coming from [XXX] have at a high speed was able to hit the caron the right back panel i had power train malfunctions alerts messages from the car. Ford could not find the problem now at 54000 miles I need a new transmission the model needs a recall for the Transmission this is a frequent problem that is well documented on the internet. And Ford knows about it and is not doing anything about it. I had to pay for a new Transmission when it should have been covered under warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
During normal driving conditions in stop and go traffic the engine coolant over-temperature warning message displayed on the dashboard. Also, for a couple days prior to this incident, the vehicle exhibited hesitation when attempting to accelerate, and the engine was very close to stalling multiple times. There wear no other symptoms of the problem prior to the failure. The vehicle was towed to a local Ford dealership, where it was confirmed the issue was related to existing TSB 20-2234 (2.0L EcoBoost - Illuminated MIL With Various DTCs And/Or Low Coolant Level, White Smoke From Tailpipe And/Or External Coolant Leak), and repairs were completed.
My car is a 2019 Ford Edge I almost got into a accident because the transmission went out of gear and the car would slow down and sometimes just speed up
2019 Ford Edge ran out of coolant without any indication of low coolant level or check engine light, resulting in loss of heat and poor engine performance due to coolant combustion. According to Ford service (who confirmed the root cause), this was due to the known issue of a faulty EGR cooler [XXX] ) leaking internally, but repairs had to be paid out of pocket. Loss of heat in winter could be dangerous, and in prolonged error state, catastrophic engine failure could occur. Failure occurred at ~55,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The car shudders and jerks/lunges forward around 35-40 mph and I am afraid that I’m going to rear end someone should it lunge forward!
Head gasket issues Design defect in engine block Passenger seat belt tension
See attached document for complaint.
The contact owns a 2019 Ford Edge. The contact stated that while driving at 25-30 MPH into town, the contact noticed there was white exhaust smoke emerging from the tailpipe. The engine shut down. Several unknown warning lights were illuminated. The contact stated that the failure was related to TSB: 20-2234. The vehicle was taken to an independent mechanic who determined that water had leaked into the engine. The contact called the local dealer, where it was diagnosed that the head gasket needed to be replaced and was unable to confirm any water in the engine. The dealer referred the contact to the manufacturer. The vehicle was not repaired. The manufacturer was contacted, opened a case, and referred the contact to the federal safety agency Hotline. The approximate failure mileage was 53,000.
The vehicle was not shifting properly and was surging while traveling at lower and higher speeds. There was NO CHECK ENGINE light on or any other warning lights at all. The vehicle is in my name, however, my daughter drives 9 hours for college by herself and could have been at risk of injury had the vehicle stalled in the wintertime between Minnesota and Kansas. I drove it while she was home over the winter break and noticed it. I took it to a Ford dealer and they said the transmission needed to be replaced. I went from diagnosing there was a problem myself with no warning lights to the dealer saying this is very common for the Ford Ecoboost engines and that the car is not drivable at all. He was also concerned the low coolant level was due to an engine failure which he said they've also seen a lot of. The vehicle only has 57,000 miles on it, however, it is 6 months past warranty. I have read the Ford forums about this vehicle and there are SO MANY people who have experienced the same thing and Ford refuses to do a recall to cover their mistake. There needs to be a recall on this to protect consumers like myself. This is so frustrating. Now I need to pay out of pocket for a new transmission on a car that I need to get rid of ASAP after hearing about all of the engine failures. I know that would be next, which would put my daughter at risk once again on the road.
82000 miles on car. Torque converter and throttle body needs to be replaced
December 19, 2024, engine failure and seatbelt failure. The seatbelt went loose and would not retract, lights started blinking on dash, car smelt funny the air coming through vents in to the cab of vehicle, white smoke out the tail pipe and then warning to pull over, temperature, check engine. I pulled over and called a tow truck. After getting my vehicle towed to certified mechanic, they advised my engine and chassie was 2018 model even though the VIN list it as 2019. I contacted Ford for recall on these items and they said they only go off the VIN. I did research along with the mechanic and there has been recalls and TSB for these items and several others my 2018 parts should have been inspected and FORD refused to do so. The engine failure is due to the coolant leaking into the engine. Whole engine needs replaced. Ford is refusing to assist in this matter. I have filed an official complaint with FORD, CXH-03434375-W8X5T6. There is several others that I believe my car should be checked for. Why is FORD refusing to repair my engine and chassie parts that are stamped 2018? This is a great risk and liability.
vehicle shuddering at speeds between 25-40...vehicle has a little over 58k miles on it...found no recalls but numerous issues of same degree...Ford not wanting to take responsibility for bad product! Costing the owners thousands in repairs!
Slipping transmission, the torque converter clutch performance stuck in off .
While my vehicle was in the shop having the transmission rebuilt and the torque converter replaced, the techs identified that there was a continued shudder. At this time, after researching the codes on my vehicle, they identified that the EGR Purge Valve needed to be replaced. They identified it because the vehicle was running rough and should not have been after the items were repaired.
My vehicle had to have the EGR cooler replaced for the second time. The first time was when the vehicle was at almost 37,000 miles, the second time was at 129,575 miles. Just like during the previous occurrences, the check engine light came on and the message in my Fordpass app advised that there was a problem with the engine cooling system and I needed to proceed to my dealership. In this instance, I had it towed to the dealership rather than driving it. This is the same system that currently has a TSB issued for it.
The sensor on the EGR cooler failed. I have had my EGR cooler replaced two times. The most recent time was in September of 2024. In December of 2024, the engine light came on and the warning messages showed in the Fordpass app stating there was an issue with the exhaust system. After the dealership reviewed it, they had to replace the EGR sensor.
The EGR cooler on my vehicle had to be replaced. This is listed on a TSB issued by Ford, however, is not a recall. The first time it had to be replaced was 11/2021 when my vehicle had 36,949 miles on it. This was diagnosed by the dealership and the part was replaced. The engine warning light came on and the messages showed in the Ford app letting me know what was occurring and that I needed to go to the dealership
The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine and coolant warning light illuminated. The contact also noticed white smoke coming from the exhaust. The vehicle was taken to the dealer where it was diagnosed that the EGR valve failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 26,446.
The contact owns a 2019 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle shut down. The vehicle was taken to a dealer and the dealer refused to diagnose the vehicle and provided the contact an estimate for the repair. The contact stated the air conditioner and catalytic converter also had failed to operate as designed. The vehicle was then taken to an independent mechanic for the repair. The contact stated that the purge valve and spark plugs were replaced, and an oil change was performed. After the vehicle was repaired, the contact stated while depressing the accelerator pedal the vehicle hesitated to respond. The vehicle was inspected by another independent mechanic at the residence, and it was diagnosed and determined that the spark plugs and ignition coil needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the federal safety agency Hotline to report the failure. The failure mileage was 70,000.
The contact owns a 2019 Ford Edge. The contact stated that the vehicle was experiencing excessive coolant consumption. The contact stated that there was a coolant leak. The contact stated that while driving at undisclosed speeds, the engine overheated even though coolant had been added to the vehicle five days prior. The low coolant warning light was illuminated. The contact was able to pull over safely. The contact called the local dealer and was informed that the VIN was not under recall. The vehicle was towed to an independent mechanic, where it was determined that there was no visible coolant leak. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the vehicle was not covered under TSB Number: 19-2346. The failure mileage was approximately 50,000. The VIN was not available.
Engine overheated while driving on the highway. White smoke came out of tailpipe during engine running. Coolant reservoir was empty after I parked the car and turned off the engine. Had to get the car towed to the dealership the next day to get it checked out and was confirmed that coolant got leaked inside the engine.
Cooling intrusion to motor, engine replaced
2019 Ford Edge has the same 2.0 liter eco boost 240PS that’s currently involved in the class action lawsuit. The problem is that the coolant sleeve is too close to the toy he cylinder and failed causing coolant to enter the engine. I was traveling on the interstate and with no warning the hot engine light came on and engine shut down. The dealer confirmed that the mother need to be replaced with the updated long block that is being put in the 2015 - 2018 Ford Edge and the 2017 - 2019 Fusion/MKZ/Escape and MKC vehicles. The vehicle only has 75000 miles on it and has never towed or been used hard. We had the vehicle for less that 15,000 miles and now have a completely useless vehicle. Ford refuses to admit any fault even with the engine codes being the exact same. The 2019 for edge need to be looked into and included with the class action lawsuit for safety and consumer satisfaction.
The contact owns a 2019 Ford Edge. The contact stated that while driving at 70 MPH, the "Engine Coolant Overheating" warning message appeared on the instrument panel. Due to the failure, the contact had the vehicle towed back to the home. The manufacturer was notified of the failure and the contact was informed that there was a recall on the vehicle for the failure(recall unknown); however, the contact's vehicle was not included in the recall. The contact was then referred to the federal safety agency Hotline to file a complaint. Upon investigation, the contact discovered that the failure was caused by the engine consuming coolant at a rapid pace. The vehicle had yet to be repaired. The failure mileage was approximately 57,000.
engine coolant sucked into motor. Check engine light and temp light came on. Luckly was intown and doing 40 mph. Copy of repair order from dealer uploaded.
My 2019 Ford Edge SEL has 37,000 miles and I keep it maintained regularly. We were 2 miles from our house when a loud blaring signal popped on my dashboard that my coolant was very low and at that point the car started "sputtering". We inched it home and sure enough, the coolant was empty. We've had no leaking on the driveway at any time. We filled the coolant reservoir and the message did not go away. We had it towed to our mechanic the next day and he said the engine needed to be replaced!!!! What? NO WARNING!! Now 2 days prior (which was a Friday), my check engine light came on and I could see a white smoke coming from the exhaust pipe and the car hesitated. After a few minutes, that went away. Drove it to work and back - 4 miles each way. The next day it happened again and again it stopped after a few minutes. I drove it maybe 10 miles after that running errands and then parked it for the day. The following day is when it "died". I received no other message or warning until it was too late. We were told by our mechanic that Ford has had numerous complaints on this engine. It is a Turbo on a 4 cylinder. The Turbo part will eventually overwork the 4 cylinder. Of course it is out of warranty. Now I am spending over $6,000 to replace this engine. Why in the world would Ford even install an engine like this in their vehicles? And why are they not recalling them?????? My husband has always had Ford Trucks and Mustangs - We have always been Ford People. I will never buy another Ford - SO DISAPPOINTED!!!!!
Purge flow valve had replaced by Ford Service on 10/5/24. Car wouldn’t start after getting gas. Check engine light came on. Code was Po496. Currently, upon acceleration @15-20 mph car starts jerking, buck, slipping, very hard to go hill. Took to Ford Service for diagnostic on 10/15/24. Told torque converter shuddering on PIDS. Recommend replacing torque converter @ a cost of $5200. Per, reviewing many complaints on this same model & yr many haven’t had success with just replacing torque converter. It doesn’t fix issue. Transmission had to be replaced. Ford does have a TSB 21-2389 that supersedes TSB 21-2081 out. It states cars with 8F35 transmission may have this issue due to the software in the power train control module. Instructing, to reprogram the PCM & the transmission solenoid strategy. After reviewing all complaints on this issue, this solution does not correct problem. I was also told by Ford service; this wouldn’t fix the issue. From what I’ve read the way this transmission is engineered will likely cause it to always do this. Because Ford Frankensteined the 6F35 (previous models) by inserting 2 gears in between existing ones, the transition from 1-2-3 will never be as fluid as 3-4, 4-5, and so on. Basically what is 1-3 on mine (8F35) is 1-2 on a 6F35. This quite frankly is a terrible transmission & only a matter of time before transmission goes completely out & someone gets killed. This year & model has numerous issues not listed here. Seems like as soon as warranty expires problems start popping up. Some issues pop up before warranty expires. This is getting dangerous & very expensive!
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ford Edge?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history