2022 Ford Escape Hybrid engine problems

Filed Sep 16, 2026 · Electrical, Engine · OH

"While driving my 2022 Ford Escape Hybrid, the vehicle suffered an abrupt powertrain failure. A wrench icon and check engine light illuminated on the dashboard, and the vehicle immediately dropped into a low-speed mode that severely limited my throttle control on the road. I was unable to drive home and had to leave the vehicle on the road until I could get a tow. The vehicle is currently grounded and unsafe to operate at a Ford dealership lot. Ford customer service is actively refusing to authorize alternative transportation or honor the extended coverage parameters outlined in Customer Satisfaction Program 23N06, which covers this exact engine defect."

Filed Sep 9, 2026 · Brakes, Engine · 55,000 miles · MI

The contact owns a 2022 Ford Escape. The contact stated that upon starting the vehicle, the check engine warning light illuminated and remained illuminated. The vehicle was taken to a local dealer where it was diagnosed, and a code for ABS Internal Module Failure was displayed. The contact was informed that further diagnostic tests were needed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 55,000.

Filed Jul 24, 2026 · Body, Engine · MI · fire

On 20 July 2026, my 2022 Ford Escape HEV caught fire in the engine compartment while parked. The vehicle is likely a total loss (insurance pending). On-site emergency personnel responded within minutes of the fire and the local fire department was on scene within 5 minutes of the 911 call. They cleared the incident (and d/c the 12V) within 32 minutes of arrival. Detroit Fire Department Incident: 202620101471. This vehicle was subject to Ford Safety Recall 23S27 and Customer Satisfaction Program 23N06, which address a manufacturing defect in the 2.5L HEV/PHEV engine. Under that recall, connecting rod bearing journals were not properly finished, causing premature bearing and engine failure that can release engine oil and fuel vapor into the under-hood area resulting in a fire. The recall remedy was completed on my vehicle, as were all customer satisfaction program campaigns. The dealer performed the PCM software update, which is intended to detect early signs of bearing failure through diagnostic trouble codes (P1061 and P032F) so the failure can be caught before an engine breach occurs. The engine long block was NOT replaced. Under Ford's own criteria, long block replacement was only authorized if the vehicle exhibited loud metal-to-metal clanking noises, a loss of torque, or the associated diagnostic codes. Dealership personnel assured me an engine light would illuminate and I would have time to safely move the vehicle to the side of the road. My vehicle did not have any warnings: no clanking, loss of torque, or leaks-no diagnostic warnings of any kind before the fire. The recall remedy did not prevent the exact failure it was designed to prevent--Ford's response was inadequate to protect owners. My the federal safety agency VIN lookup shows no open recalls. I completed every recall and CSP Ford issued. I have complete dealer service records for this vehicle, photos of the damage, hi-res surveillance video is saved at work, as well. The vehicle is intact and has not been salvaged.

Filed Mar 13, 2025 · Electrical, Engine · NY

This defect has resulted in multiple vehicle shutdowns while in operation, significantly increasing the risk of a crash. Additionally, Ford has identified a potential risk of battery thermal venting, which could lead to a vehicle fire, further endangering my safety and that of others on the road. Ford has advised not to charge the vehicle, further limiting its functionality and reliability. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, Stevens 112 Ford has confirmed that the vehicle is experiencing high-voltage battery failure, consistent with the recall. However, they have also stated that Ford has not developed a solution to repair this issue. Ford’s hotline has advised against any further repairs at this time. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected and diagnosed by Stevens 112 Ford, who confirmed the issue. Ford’s technical hotline has been contacted, and they acknowledged the defect but advised against further repairs. No inspections by police or insurance representatives have taken place.

Filed Jan 30, 2025 · Brakes, Electrical · CA

Egr coolant leak in the first 70k miles of driving the car this has been causing my check engine light to turn on and the problem is 'discovered' when the part is no longer covered by warranty.

Filed Oct 22, 2024 · Engine · CA

See attached document for complaint.

Filed May 22, 2024 · Engine, Transmission · WA

In March 7: Received vehicle alert from Ford PASS , "WARNING MESSAGE: SERVICE ENGINE SOON WARNING THE POWER TRAIN CONTROL MODULE HAS DETECTED THE ENGINE TIMING CHAINS EXCEEDED 95% OF THEIR USEFUL LIFE AND REQUIRES SERVICE NOW. THE CONTROL SYSTEM INVOKES A SYMPTOM OF LIMITED POWER" while I was driving in highway I5 at WA. The vehicle suddenly slow down itself and lost of acceleration. Took to the dealership ans they could not identified issue. Reset the code and returned the car back to me. In May 12: Same symptom happened again. Took to the dealership next day and the technician did see the issue since the Service Ranch icon was shown on the screen. The service advisor said they contacted Ford Engineering to see how to fix but no result. They reset the code and I brought the car back while they are still waiting form Ford engineering.

Filed Apr 26, 2024 · Engine · MI

The contact owns a 2022 Ford Escape. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Filed Apr 22, 2024 · Engine · MN

The contact owns a 2022 Ford Escape Hybrid. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Filed Apr 21, 2024 · Engine · FL

This recall has been out since May 26, 2023. This is a potentially dangerous situation. I am a [XXX] widower and my Ford Escape is my only means of transportation. If I were to have an engine fire I would be in trouble! Why is it almost a year and Ford cannot fix this problem? Any assistance that you can provide would be greatly appreciated. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)