2016 Ford Escape body problems

Filed Jul 17, 2026 · Body, Engine · 113,000 miles · MI

The contact owns a 2016 Ford Escape. The contact stated that while driving at an undisclosed speed, there was a knocking sound coming from the engine, with the engine revving. The contact stated that while turning off the vehicle, the engine was knocking very roughly. The vehicle was taken to the dealer, but the dealer was unable to determine the cause of the failure. The vehicle was taken back to the dealer for failures with the bearings and the rotors. The contact stated that there were abnormal sounds coming from the bearings. The contact stated that the rotors were rusted, and there was a grinding sound coming from the rotors. The contact believed that the vehicle was a flood-damaged vehicle due to the rust on the rotors, bearings, and underneath the vehicle. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure. The failure mileage was 113,000.

Filed Nov 12, 2025 · Body, Electrical · 80,000 miles · PA

The contact owns a 2016 Ford Escape. The contact stated that upon opening the liftgate, the liftgate started closing unintendedly and struck the contact on the head. There was no injury sustained. The dealer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.

Filed Jun 10, 2024 · Body · FL

I have a sunroof and water leaks in and gets the headliner wet on both sides on the area vertically between windshield and front windows. I have had my front windshield replaced to ensure it wasn’t a windshield leak from a seal issue. It don’t fix the problem. I had my sunroof replaced in case it was that and it didn’t fix the issue either. I had the drain tubes for the sunroof flushed multiple times and it didn’t fix the issue either. This has been inspected/looked at by multiple auto places and it can not be located to the source of how water keeps getting in. Every time it rains it gets the headliner wet. There is no warning lamp indicating an issue. It is available for inspection should anyone else need to inspect it to try to find the source of why water gets in. It leaves water stains in my headliner. This is a safety issue if water gets into the car and the water can damage other components of the car. This issue has been ongoing for the last year approximately and I have brought the car in multiple times to address this but no one can locate the source so far.

Filed Apr 11, 2024 · Body · NY

The contact owns a 2016 Ford Escape. The contact stated that there was a leak coming through the sunroof around the trim. The contact stated that the water leaked onto the doors and trunk, and there was mold and mold odor inside the vehicle. The contact and passenger were coughing while riding in the vehicle. The contact's spouse used silicone to close the gaps in the sunroof. A dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was unknown.

Filed Jul 19, 2023 · Body · 50,000 miles · PA

The contact owns a 2016 Ford Escape. The contact stated that while driving at approximately 60 MPH, an abnormally loud sound was coming from the front undercarriage of the vehicle. The contact steered to the side of the road where it was observed that the undercarriage cover was detached. The vehicle was taken to the dealer where it was diagnosed that the undercarriage cover needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was 50,000.

Filed Jan 19, 2023 · Body, Engine · OH

Since purchasing this vehicle there have been many issues. I had purchased the additional warranties also only to have the dealership say they were not covered. First my roof leaked. Had to take to a repair shop through the dealership, luggage racks had to be taken off and welds redone. Next the catalytic converters went bad with only approximately 50,000 miles. Ford would not talk to me and the dealership stated it is not covered under the extended warranty. Somehow I paid minimal repairs but during that time their best mechanic was fired. Next the Continental tires pealed. I had the tire warranty and the dealership would not cover. I called Continental they stated that they knew these tires were bad but yet they were still sold on vehicles! After much complaining and stress all but $400 was covered by Continental. The dealership did very little. At approximately 65,000 the engine blew. I found out by a local repair shop that Ford had an Escape safety issue on their site about the engines. After speaking with Ford twice they refused to speak to me any longer and only the dealership if I wanted the engine replaced. I did and was given numerous different amounts it would cost me. Since this was Ford's manufacturing issue I should have paid nothing. It took over 4 months to repair my vehicle. I had to complain to Ford and the dealership to get a loaner. I am a 66 year old single women who depended on the quality of Ford. I had tried to email Ford representatives and call with no reply ever. Each of these issues had no warnings lights nor were there any problems prior to the issues occurring. These issues could have caused major accident by the engine quitting in traffic or blowing, and the tires pealing. Ford motor needs to pay for all these issues. There needs to be a class action suit.

Filed Jul 29, 2022 · Body · 45,000 miles · TX

The contact owns a 2016 Ford Escape. The contact stated that the vehicle's driver's side door had severe rust that was causing the skin of the vehicle to weld onto the outer panel of the door. In other areas of the vehicle, there was severe rust causing the paint to begin to bubble to the point that it was welded to the outer panel of the door. The dealer was not able to repair the rust on the body of the vehicle due to a lack of equipment. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 45,000.

Filed Jun 17, 2022 · Airbags, Body · MN

The roof rack leaks every time it rains or gets wet car wash etc. Underneath that roof rack mounting hole is the curtain airbag which is soaked every time that happens. The airbag is rusting/staining my headliner and I think based on that tachata recall this would be under the same scrutiny. Concerned about whether or not the airbag will deploy of if it's corroding away each time it rains. I reached out to Ford when the unit was under warranty and no assistance from them. I then tried to take things into my own hands and silicone it but it still leaks. I have no idea how or where anymore. Still assuming the roof rack though

Filed Jan 4, 2021 · Body · 49,000 miles · NC

I was driving and turned a corner on a local road and my rear left door swung open. There had been no indication it wasn't closed. Then, after stopping, I tried to close it and it wouldn't latch--it just bounced back open. The following link is video someone else posted that shows the exact issue I had: https://www.youtube.com/watch?v=_eiozph8_xg it's a different make and model from ford, but the issue is identical to what I am dealing with now.

Filed Sep 21, 2020 · Body · 53,032 miles · MO

2016 ford escape door will not stay closed. I was backing up out of my driveway when the light alerted me that the rear drivers door was not closed, I got out and closed it again but it will not stayed closed. Upon closer inspection the latch will not engage. My vehicle was not included in a recall of 2013-2015 ford escapes with the same latch defect.