Powertrain control module failure causing vehicle to lose power and engine to run at 5 to 6 RPMs. and transmission not shifting properly. Vehicle is going into limp mode and will also shut down while driving but the engine stays running and the cruise does not shut off. There is not remedy for the recall that I believe is causing these issues. This has been going on for 6 month. This vehicle has been nothing but a problem.
2020 Ford Escape fuel system complaints
Page 5 of 8: complaints 101 to 130 of 201, newest first, as owners wrote them.
My car togs a lot. My tire sensors keep going out. I've smelt gas before while driving. It's very slow going up hill. I hear grinding sounds intermittently
The contact owns a 2020 Ford Escape. The contact received notification of the federal safety agency Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted; however, the contact was informed that parts were not yet available. The contact was informed that the repair would not be performed unless there was a fuel odor present. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
The contact owns a 2020 Ford Escape. The contact had received notification of the federal safety agency Campaign Number: 25V467000 (Fuel System, Gasoline). The contact called a local dealer and was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the lack of parts. The contact had not experienced a failure.
The contact owns a 2020 Ford Escape. The contact received notification of the federal safety agency Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the message "Tire Pressure Monitor Fault," was displayed. The dealer was not contacted. No further information was available. The manufacturer was not made aware of the issue. The failure mileage was 61,067.
The contact owns a 2020 Ford Escape. The contact's wife stated that while starting the vehicle, the check engine warning light illuminated. The contact received notification of the federal safety agency Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer, where it was diagnosed with fuel injector failure. The contact was informed that the fuel injector needed to be replaced. The dealer confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 48,000.
The contact owns a 2020 Ford Escape. The contact received notification of the federal safety agency Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE). The contact stated that the dealer was contacted; however, the contact was informed that parts were not yet available. The vehicle was not repaired. The manufacturer was contacted about parts availability. The contact had not experienced a failure.
Vehicle has active alerts for powertrain control module, and low boost pressure with the turbocharge along with emissions codes P0299, P0496 and P0456. The vehicle is constantly going into deep sleep mode. While driving the vehicle started to enter safe mode. And displayed an alert that said please turn ignition on. The dash and screen went black like vehicle was off but it was still running. This happened multiple times. My vehicle also will not start after pumping gas so I have to leave vehicle running every time I pump gas. My vehicle will not pass NY state inspection because of the recalls.
2020 Ford Escape SEL was taken into Ford Service Center for oil change and to address acceleration issue that started two days prior, (check engine light had come on the day before drop off). One week after dropping my vehicle off to be assessed, I was told I needed a small part and it would be complete in 3 days. Another week went by, so I reached out and was told that I need a new engine because of a known Ford issue. Unknown to me, coolant was leaking into the engine and destroyed it. I was assured by the Ford technician that this was a known issue and the problem did not arise from something I did/did not do. I was quoted over $9k and weeks worth of work. I easily drove the vehicle to the Service Center, but was told it is now no longer drivable. I drive a LOT for work and had only had the vehicle for 15 months, still owing over $16k on my auto loan. I had no choice but to purchase a new (NOT FORD) vehicle and am now stuck with two vehicle payments. Vehicle is still sitting at the Ford Service Center while I pay on it monthly.
The contact owns a 2020 Ford Escape. The contact received notification of the federal safety agency Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable timeframe for the recall repair. The contact stated that there was fuel underneath the vehicle. While inspecting the vehicle, the contact became aware of a fuel leak on top of the engine. The contact stated that the fuel injectors were leaking, and the vehicle was not safe to drive. The dealer was contacted and confirmed that the fuel injectors had failed and needed to be replaced. The dealer confirmed that the part was not yet available for the recall repair, and was unable to confirm when parts would be available. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was 15,000.
The contact owns a 2020 Ford Escape. The contact stated that since owning the vehicle, the front driver’s side door was replaced by the dealer after the door failed to open. Additionally, the contact stated that while driving 25 MPH and attempting to make a left turn, the vehicle failed to respond as intended, continued driving straightforward and nearly drove off the road into a wooded area. The vehicle was taken back to the dealer, where a wheel alignment was performed. Additionally, the contact received notification of the federal safety agency Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the check engine warning light was illuminated and related the warning light to the recall. The vehicle was taken to the dealer, where it was diagnosed that the purge valve had failed, and the purge valve was replaced. The contact was also informed that the fuel injectors were in good condition, and that the vehicle was safe to drive. The recall repair was not performed. The manufacturer was notified of the failure, but no assistance was offered. The contact was referred to the federal safety agency Hotline to report the failure. The failure mileage was 69,527.
I am the owner of a 2020 Ford escape. My vehicle falls under the recall dealing with defective fuel injectors. The dealership preformed the suggested service or installing the drain tube and updating the software. I’ve been noticing that my vehicle has a slight hesitation while accelerating in speed and I would periodically smell the strong scent of gasoline, but no check engine or warning lights ever come on. Here recently while driving, my car started slowing down unexpectedly by itself and started idling extremely rough, almost like a tractor and the check engine light came on. I pulled over in the nearest parking lot, turned the car off and looked under the hood but didn’t see anything out of the norm except a small wet spot on the engine cover and there was the slight smell of gasoline. I didn’t think anything of it because I had recently had my oil changed and thought it was probably just a slight spill from there they and refilled the engine oil. I was able to restart my car and everything seemed to have went back to normal. I was able to drive my car to the nearest auto part store where they were able to run a diagnostic scan to see why my check engine light was on. The scan pulled two error codes: the first one being P0302 which is a cylinder 2 misfire, and the second one being P3402 which is a Cylinder 1 Deactivation/Intake Valve Control Circuit Performance. I called ford to see what could be done and they informed me that there was currently no fix for my vehicle. And when asked what i should do the person on the phone told me to “drive the car until it was inoperable”. Which is absolutely crazy to me!
My vehicle had been driving great up till about three or four months ago. It started losing speed, stalling and would not accelerate unless i pressed the pedal to the floor which I had to do in order to avoid an accident. All while this was happening the service light with the 🔧 would comes on, but once I cut the car off and started it up again the next day or after running multiple errands the service light would be gone and my car would drive normal so I thought it was just a fluke and I didn’t worry about it again. Until now!!! Just today my car would not start and at the same time I would also get a warning saying, start the car or cut the engine off as I was trying to start the car so that was crazy. And in order to get it started I had to get the battery jumped, after that it would start right up. But later if I tried starting the car up again it would barley start up without multiple attempts of me pressing the push start, and pressing down hard on the brake pedal and to top it all off my car is losing speed and stalling again.. So because of this I had the battery, terminals, starter, and alternator tested and they said everything is fine so none of that is causing my car not to start up. While trying to find a solution and get a estimate on repairs, I found out my car model has three recalls on it but from what I can see non of these recalls should cause any of these issues. Still I made a appointment to drop it off tomorrow so they can fix the recalls and hopefully figure out what the problem is and fix these other issues. Any who, I thought I should share this just in case others are having these problems and maybe Ford will correct these hazards. Thank you.
I am the owner of a 2020 Ford Escape experiencing two serious issues: 1.My vehicle is exhibiting the exact symptoms outlined in Ford CSP 23B56—specifically, the failure of the driver-side door check-arm welds. The door produces loud popping noises, feels unstable when opening/closing, and has visible signs of structural stress. Despite this, my VIN has been deemed ineligible for the program. Given that the issue matches the failure described in CSP 23B56, I am requesting a re-evaluation of my VIN’s coverage and a formal inspection under this program. 2.My vehicle is also subject to the federal safety agency Recall 25V467 / Ford Recall 25S76, concerning the potential for a cracked fuel injector leading to fuel accumulation on top of the engine—a serious fire hazard. According to the federal safety agency, there is currently no remedy available. This adds another layer of safety concern, particularly considering the compounding risks and Ford’s delay in delivering a fix. Between the structural door failure and a pending recall involving potential engine fires, I am deeply concerned about the safety and reliability of my vehicle. I am asking that my concerns be formally investigated and that Ford take appropriate responsibility for repairs, reimbursement (if applicable), or an expanded VIN inclusion under the CSP.
Check engine light came on and car died at stop sign and wouldn’t restart. This happened multiple times after filling up car with gas. I took it to my dealership and they said it was the purge valve. I think should have been covered under warranty.
The vehicle in question shuttered into low RPM and then shut off with the electrical system still working with an error message: “Manual Restart Required” and a flashing orange auto-start/stop indicator on dashboard. Vehicle must be restarted after stopping at a red light or stop sign in traffic posing a safety concern to occupants and other drivers while the driver manually restarts the vehicle. Local Ford dealership attempted to troubleshoot the vehicle. Issue is worst after getting gas and with low fuel in tank. Initial diagnostics showed no error codes. Issue began happening around March 2025 and has persisted and gotten worse since then. Vehicle taken for diagnostics around May 8, 2025.
The contact owns a 2020 Ford Escape. The contact stated that the vehicle failed to start immediately and required several attempts before starting. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle returned to normal functionality; however, the vehicle drove rough. The check engine warning light and the maintenance warning light was illuminated. The vehicle was taken to an independent mechanic, where the contact was informed that the fuel injectors and high-pressure fuel pump had failed. The contact stated that the fuel injectors were replaced. The vehicle was pending a diagnostic test by the dealer. The manufacturer was not notified of the failure. The contact related the failure to the federal safety agency Campaign Number: 25V165000 (FUEL SYSTEM, GASOLINE). The failure mileage was approximately 41,000.
The contact owns a 2020 Ford Escape. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle unexpectedly decelerated to 20 MPH, and failed to accelerate as needed. There was an unknown warning light illuminated. The contact stated that the dealer had previously replaced the fuel pump twice, but the failure persisted. The vehicle was taken back to the dealer; however, the vehicle was not yet diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 55,000.
The contact owns a 2020 Ford Escape. The contact stated that upon starting the vehicle, the traction control, AWD, Forward Collision Assist, and several other warning lights were illuminated. The manufacturer was notified of the failure, and the contact was informed that there was a recall for other model vehicles for a similar failure; however, the VIN was not under recall. The vehicle was taken to an independent mechanic where the vehicle was diagnosed with a defective purge valve assembly. The contact had the part replaced; however, the check engine warning light became illuminated again. The vehicle was repaired. The failure mileage was approximately 20,000.
The contact owns a 2020 Ford Escape. The contact stated that after refueling the vehicle, the vehicle failed to immediately restart. The contact stated that upon depressing the accelerator pedal continuously, the vehicle started. The check engine warning light was illuminated. Additionally, the contact stated that the vehicle was making an abnormal knocking sound. The vehicle was taken to an independent mechanic, where the contact was informed that the fuel was not reaching the engine. The mechanic determined that an unknown part needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and informed the contact that the VIN was not included in a related recall. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.
Got the car with many problems . Last recent problems purge cvavle, leak in emission, air make loud sounds . Now it’s my door was making popping noises when closing or opening, now the door doesn’t shut at all. No incident happen, just happen by itself
The vehicle has 27,500 miles on it. Based on what the dealership repair group mentioned, there is an issue with Pa. Purge valve. The part # is #FO LX6Z-9D289-SH TUBE ASY - FUEL VAPO. Since the car has such a low mileage, this repair should be covered under the warrantee.
When I go to start up my vehicle it stalls before it turns on. And everytime I put gas in my car it shakes as if it wants to cut off.
The contact owns a 2020 Ford Escape. The contact stated while driving at various speeds, the vehicle was idling rough, accelerated rough, and started rough. The check engine warning light was occasionally illuminated. The vehicle was taken to two different local independent mechanics where the vehicle was scanned for an emission valve failure. The local dealer was contacted. The vehicle was not repaired. The contact had spoken with the Manufacturer recall service representative where it was diagnosed with a fuel injection failure, that would be repaired by the manufacturer; however, the vehicle would not be repaired for an emissions valve failure. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 65,000.
I had first took car to get first free Oil change from ABC Nissan and the service department couldn’t do it under 5000 miles and just topped of the oil. I had went back like few days later for an air filter replacement and they did not have to part and sent me over to ford right across the street. I had ford dealership run a code diagnostics on vehicle and found it needs computer updates and an expensive purge valve after having car for a couple days and hit me with a hefty price estimate I could not or NPP car warranty from ABC Nissan couldn’t cover for engine repairs since it wasn’t an engine issue but can affect the engine. I had went back into abc Nissan recently for a possible trade in and just got the run around from manager that help sold me the car and seem it was a waste of time putting almost 7500 for the car down payment plus 518 a month for car payments to be cheated when car start to have issues.
I have been notifying the ford dealership about a problem that i feel is due to faulty fuel injectors since I bought the vehicle back in 2021, all of the repairs that have been done and that they have told me to do have not resolved the issue I keep getting the runaround, the vehicle sometimes while on the highway will automatically enter safe mode and i get a notice of an issue with the high pressure fuel system which immediately forces the vehicle to lower the speed to am unsafe speed.
There is a courtesy replacement on the main fuel injector. I just recently had to replace my turbo. No my car bogs down won't go and smells like eggs which is the catalytic converter. The injection brakes the converter which brakes the turbo and Ford is not interested in helping very much. How can
The contact owns a 2020 Ford Escape. The contact stated while driving at an undisclosed speed, the vehicle stalled. The contact later discovered that there was smoke coming from the engine compartment and the A/C unit. The contact stated that after several minutes the vehicle returned to normal operation. The check engine warning light was illuminated. The contact was notified that the VIN was included in the federal safety agency Campaign Number: 22V859000 (Fuel System, Gasoline). The vehicle was taken to a dealer to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.
I was driving for uber and I smelled something biting along with my passengers, we had just gone through an area with a lot of smoke, so we figured it was that. After I dropped them off I noticed smoke billowing from my engine. The next day I had noticed my car was low on coolant, so I drove to Ace Hardware to grab some. After I put the coolant in the car I went to Publix to get some groceries and when I got back I smelled the smoke again. I did some research and there was a class action lawsuit against for Ford for the Escape with 1.5L engines and the fuel injectors cracking which caused coolant intrusion damaging the engine and causing them to over heat. I had my car towed to the dealership and the ECT light came on along with a parking brake warning.. This car has been nothing but a headache, nothing but repairs since I’ve had it. There is also a CSP, Customer Satisfaction Protocol for The fuel injectors cracking and I was never told about it all the times I’ve been to the dealership. I’m thinking that’s what caused the overheating..
with awd module. tested power ground to the module. isolated to faulty module No hill start, AWD faulty module, new purge valve
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history