The contact owns a 2021 Ford Escape. The contact stated that the vehicle was taken to a dealer, where it was serviced under Customer Satisfaction Program 23B-56; however, the replacement welding caused the front driver's side door to fail. Additionally, the contact stated that while attempting to enter the vehicle, the vehicle failed to start, and multiple warning lights illuminated. The vehicle required a jump-start to start. The vehicle was taken to an independent mechanic, where it was diagnosed that the battery had failed and needed to be replaced. The battery was replaced, and the contact was informed that the previously installed battery was incorrect for the vehicle. The contact was referred to a second dealer for further assistance. The vehicle was towed to the second dealer, where it was diagnosed that a water leak at the C-105 connector on the front driver's side door had caused an electrical system failure. The dealer determined that the wiring harness had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 76,000.
2021 Ford Escape body problems
92 complaints (26% of all complaints for this car). Typical mileage when it fails: 41,000.
- owner complaints
- 92
- of this car's complaints
- 26%
- typical mileage
- 41,000
- crashes
- 0
- recalls
- 2
Which part fails
- Body65
- Body: door12
- Body: door: hinge and attachments5
At what mileage
Complaints by mileage at the time of the problem.
Ford Escape body problems in other years
Related recalls
Structure: body: hatchback/liftgate: hinge and attachments
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.
- Risk
- A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.
- Remedy
- Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on on December 3, 2025.
Recall number 25V829000 · Recall details
Structure: body: bumpers: active shutters/grill
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
- Risk
- An engine compartment fire increases the risk of injury.
- Remedy
- Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 22S47.
Recall number 22V484000 · Recall details
Related investigations
Failed Door Check Arm Attachment Point
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupantsâ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Fordâs testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Fordâs customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
PE23013
What 2021 Ford Escape owners say
Most recent owner complaints, unedited.
When I lock my car, whether from my phone, keys, or lock button inside car, the car will lock except the passenger side door which remains unlocked. So when the car is supposed to be locked and secured, anyone who wants can gain access in my car whenever they want. The car alarm will go off. But the door still opens. I believe this is a safety concern for my family and I while being in the vehicle and also a threat to valuables in my car. I haven’t had it looked at yet. But I want to report it.
The sunroof cover has come off its tracks and has lost tension. It requires a full sunroof cover replacement. Upon searching this issue online, I found it was a common issue in Escapes around 2020-2022.
On XXX I was driving my 2021 Ford Escape for 10 minutes before I stopped at Sheetz gas station on [XXX]. I ran into the building to withdraw cash from the ATM leaving my fiance and dog in the car while it sat idle. Upon exiting the building about 30 seconds to a minute later, I witnessed smoke coming up from the hood of my car. My fiance and Dog quickly evacuated the car as we saw flames emerging. I ran inside to get assistance from the workers and they brought out fire extinguishers. The attempt to extinguish the flames was unsuccessful and the front of the car quickly went up. Police and fire department were called and they showed up about 10 minutes later to handle the situation. Reports from the officer, fire department and the Sheetz assistant were taken. I do not have access to those. My car insurance is covering the cost of the vehicle and a 7 day car rental. They are not covering the loss of both mine and my fiance's cell phones. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Nothing malfunctioned. All I was asking for was a fender to hood adjustment and the dealership kept telling me they don't do that and that I would need to go to a bodyshop. The fender to hood alignment issue didn't put others at risk. What the problem is is the door is not aligned based on OEM requirements and the recall repair was completed but not done correctly. The problem has been identified by the dealer. The vehicle has been inspected by the manufacturer. No warning lights or anything. Simply dealership refusing to get my door realigned. After taking it to body shop 3 times and still this problem has not been fixed. This is unacceptable especially since it was a recall through the manufacturer. Also when I asked dealership for proof in writing that they don't do their own bodywork the service advisor told me no. That is also unacceptable. I should be given my proper recall documentation whenever I ask for it.
The contact owns a 2021 Ford Escape. The contact stated that while reversing out of the driveway, the vehicle suddenly shut off and failed to start. The vehicle was towed to the dealer, who diagnosed that the fuel injector had failed. The vehicle was repaired. After having the vehicle repaired, the contact received notifications of the federal safety agency Campaign Numbers: 25V467000 (Fuel System, Gasoline), 25V829000 (Structure), 26V123000 (Back Over Prevention), and 26V117000 (Visibility); however, the parts for the repairs were unavailable. The contact stated that when idle and attempting to acclerate the vehicle would jerk forward. The vehicle would jolt forward and shake when transitioning from 2nd to 3rd gear at various speeds. Whistle noises were coming from near the liftgate. The contact was experiencing hard shifting. There were no warning lights illuminated. The contact stated the manufacturer had exceeded a reasonable amount of time for the remedy to be available. The vehicle was taken to the dealer to change the transmission fluid, but they were told that the transmission was damaged and needed to be rebuilt. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 79,845.
The contact owns a 2021 Ford Escape. The contact received notifications of the federal safety agency Campaign Numbers: 25V789000 (Electrical System), 25V829000 (Structure), 26V123000 (Back Over Prevention) and 26V117000 (Visibility); however, the parts to do the recall repairs were unavailable. The dealer was contacted, and the contact was informed that the parts were not yet available. The manufacturer was contacted and confirmed that the parts were not yet available. The contact had not experienced a failure.
The front driver door check arm attachment point is compromised. My service representative has over a dozen of these problems. This means there are many more of these issues than you indicate in your NHSTA action number PE23013, July 7, 2023-January 24, 2024 report. My window might or might not go down or up. This is a problem with my allergies and my daughter's asthma when triggers are present outside. My door might or might not shut. Also a problem. I might get stranded someplace. I travel frequently. My car door issue was identified August 2025. I am still waiting for a new door. The contractors recently delivered passenger doors which do not fix the problem. Please investigate this issue further.
The contact owns a 2021 Ford Escape. The contact received notifications of the federal safety agency Campaign Numbers: 26V123000 (Back Over Prevention), 26V117000 (Visibility), and 25V829000 (Structure); however, the parts to do the recall repairs were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available for the recall repairs. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact had not experienced a failure.
the sunshade panotramic panel cover that sperates the two roofs seems to be falling off due to cheap two side tape which caused the whole sunshade assembly and motor to break. I took my car to the dealer yeasterday Anderson Ford based in Lincoln NE, and they cahrged $119 to diagnis and qouted me over $2000 to fix it. This is manufacturere fault that caused this to happed by using cheap, unreliable two side tape to attach panel cover!. Please address this as alot of Ford Escape owners suffer from this issue
Questions about the 2021 Ford Escape body
Does the 2021 Ford Escape have body problems?
Owners have filed 92 complaints about the body of the 2021 Ford Escape, 26% of all its complaints, more than any other problem.
At what mileage do 2021 Ford Escape body problems start?
The typical (median) mileage in owner complaints is 41,000 miles.
Was there a recall on the 2021 Ford Escape body?
Yes, 2 recalls: 25V829000, 22V484000. Check your VIN to see if your car still needs the free repair.
What year does the Ford Escape have the most body problems?
The Ford Escape model years with the most body complaints are 2020 (671 complaints), 2005 (434 complaints) and 2004 (138 complaints).
Other 2021 Ford Escape problems
Fuel system 75Brakes 50Engine 49Transmission 46Electrical 34Visibility 28Driver assistance 18Seat belts 8Suspension 7Acceleration 5Lights 5Steering 4Airbags 2Locks 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history