Ford Escape ball joint problems

Filed Jun 1, 2026 · Suspension · MI

I was heading west on XXX with my [XXX] granddaughter and about a mile before the XXX exit we heard a loud bang and the car was, like a shot, propelled across the center line into the left lane and heading for the ditch. I immediately hit the brakes and pulled a hard right to keep the car on the highway. After three or four hard rights and lefts I was able to pull the car onto the left shoulder. I thought it was a blown tire but upon inspection they were all ok. The passenger right rear wheel though was on an angle. I called [XXX] and they sent a state police officer to assist. We were very lucky as about 10 seconds earlier I pack of cars passed us and a straggler of the pack passed us about 4 seconds before the incident. It could have been a five or six car pile up. I had it towed and after the mechanics inspection found the broken (as the picture shows) rear upper control arm. The broken parts are available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 8, 2026 · Suspension · 50,000 miles · TX

The contact stated that while driving at approximately 20 mph, the ball joint detached from the vehicle without any prior signs or issues. This caused an issue with the break line, with brake fluid leaking, the vehicle tilting and messed up the front of the vehicle had caved in on one side. The vehicle was towed to an independent mechanic where it was diagnosed with a ball joint failure. The vehicle had not been repaired. The approximate failure mileage was 50,000.

Filed Jan 25, 2026 · Suspension, Transmission · PA

Vehicle was purchased [XXX], the very next day multiple lights came on on the dash and it started bucking while driving. I took it back to the dealership for repairs.The right rear wheel speed sensor was bad. While the vehicle was being repaired a bolt that was seized up was broken requiring the Rr wheel knuckle to be replaced. July, the vehicle was treated for a water leak into the spare tire compartment.In September, more repairs were needed. I took it to my mechanic.The L axle shaft, wheel bearing, control arm w/ball joint, speed sensor and Rt.knuckle needed replaced. At this point, I was informed of the extensive rust under the vehicle and only being 8 years old, is a great concern. When it was taken in for an alignment, it was discovered there was a bolt broken off the Rr control arm, and it was repaired. October, it was treated again for the water leak. Water was still getting in with the spare tire when it rained. Also in October, I noticed a lag in shifting when accelerating. One incident that happened when merging onto a highway, the shifting lagged, delaying my acceleration and caused my vehicle to be traveling at a much slower rate than traffic. I took it to the dealership for repairs for the lag and a grinding noise. The transmission and torque converter were replaced. The grinding noise continued even after the repairs. January 2026, the vehicle was again taken in for the grinding noise and water leak. It now requires a transfer case, drive shaft, rear differential and the sub frame is cracked. I am greatly concerned about the structural integrity of this vehicle. Dealership claims the rust of the frame is from PA winters however the steering shaft INSIDE the car also has rust on it. For comparison, I also have a 2003 Jeep and it has minimal rust and is kept outside daily. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 26, 2025 · Suspension · 54,000 miles · MI

The contact owns a 2019 Ford Escape. While the contact’s daughter was driving 65 MPH, the driver's side rear control arm fractured and detached. The contact stated that the failure occurred when the vehicle drove over a mild bump on the road, causing the entire driver's side rear wheel to detach from the vehicle. In addition, the contact stated that his 1-year-old grandchild was an occupant of the vehicle and was seated in the rear seat when the failure occurred. The contact stated that the daughter was able to safely drive the vehicle to a nearby Midas, where the technician stated that they did not know how the contact's daughter was able to drive the vehicle in the defective condition. The technician informed the contact that when the vehicle arrived at the shop, the driver's side rear wheel was dangling and flopping, and the rear of the vehicle was fishtailing. The contact was informed that the driver's side rear control arm had fractured in half and detached from the vehicle. The contact was informed that the driver's side rear control arm needed to be replaced. The vehicle was repaired. In addition, the contact was given the detached rear driver's control arm. The contact stated that the driver's rear control arm had a crack, which indicated a previous failure. The contact stated that the failure could have caused injuries and needed to be addressed. The manufacturer was not made aware of the failure. The failure mileage was approximately 54,000. The VIN was unavailable.

Filed Oct 22, 2025 · Steering · 125,365 miles · NY

The contact owns a 2010 Ford Escape. The contact stated that upon starting the vehicle, the steering wheel violently drifted to the left, and the contact lost control of the vehicle. There was no warning light illuminated. Due to the failure, the contact used excessive force to steer the vehicle. Prior to the failure, the independent mechanic informed the contact that the same failure had occurred after the tie rod ends were replaced. The vehicle was taken back to the independent mechanic, who then had the vehicle towed to the dealer. The vehicle was diagnosed with a defective steering column. The vehicle was included in the federal safety agency Campaign Number: 14V284000 (Steering); however, the recall was not related to the steering column failure. The vehicle was not repaired. The failure mileage was 125,365

Filed Oct 16, 2025 · Suspension · KY

Took my mothers car to the Ford dealership for inspection. Upon inspection the mechanic told us that the subframe is rotted out and that it is not safe to drive which is why there was issues with steering and tire leaning due to control arm coming off subframe. This vehicle has been taken care of through out the years. My 70 year old mother could have been seriously injured if not dead. Never have i seen a sub frame rot like that on a car unless it was sitting for many years. Now the dealership wants 3,000 dollars to replace sub frame.

Filed Jul 30, 2025 · Suspension · TN

I have had a multitude of issues regarding the steering and suspension of my 2012 ford escape limited. I have replaced the same parts multiple times over a short period of time. And the parts normally would not be replaced but once in a car lifetime such as control arms 4x 3x on passenger 1x on driver. But anyway this led to me finding out that my front passenger subframe is rotted. Which led me to a community chat about this vehicle where I found people that have had accidents been hurt and this is a common thing to happen with this vehicle. The subframe should not rot especially on one side I’m particularly without a reason. There is a recall for some 2012 ford escapes for this part but for some reason my car is not on that recall. My car is now a danger to drive. The recall should include all vehicles that have the issue with that part. My vehicle is unsafe to drive now. Idk how long it’s been like that. I’ve had part after part replaced because of this but no one had figured it out until my most recent mechanic. I have had my wheel fall off my vehicle while driving when my first control arm broke because the rot in the subframe is causing the rubber inside the control arm to wear fast. So when my control arm broke when I was driving luckily I was on a street rd not a highway I was not hurt but had to get it towed. My wheel dropped a second time while I was driving because of the same issue where the rot on the subframe is, is at the connection to the control arm where the rubber is. So there’s 2 times I could’ve been seriously hurt. I drive on the highway a lot. I have been very lucky. There is cases of people being hurt and having accidents because of this. I’m on a chat about this vehicle where an overwhelming amount of owners have the same exact issue with this part.

Filed Jul 7, 2025 · Wheels · WI

While driving approximately 70 MPH on the highway, the rear passenger-side wheel rim suddenly failed and blew out, causing the tire to also blow out. The incident caused a sudden jolt and I nearly lost control of the vehicle. Thankfully, I was able to steer safely to the shoulder without crashing, but it was an extremely dangerous situation. The failure of the rim caused significant damage to the rear suspension. The vehicle required the following repairs: New rim Two new tires Right Rear Control Arm – Forward Right Rear Control Arm – Adjustable Right Rear Trailing Arm Lower Rear Lateral Link Rear Suspension Shock Absorber All of this stemmed from the catastrophic failure of the rim at highway speed, which I believe should never occur on a properly maintained vehicle with no prior wheel damage. The failure occurred without hitting debris or a known pothole and was not due to a slow leak or flat—it was a sudden rim failure. This presents a major safety hazard not only to drivers of Ford Escapes but to others on the road. I urge the federal safety agency to investigate whether other similar failures have occurred in 2018 Ford Escape models. A recall or formal review may be warranted.

Filed Jun 23, 2025 · Suspension · 83,000 miles · NY

The contact owns a 2013 Ford Escape. The contact stated that while driving at 55 MPH, the rear driver’s side control arm detached from the vehicle. The contact lost control of the vehicle momentarily. However, the contact was able to control the vehicle and pulled over to the side of the road. The vehicle was towed to an independent mechanic where it was diagnosed that the subframe had corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The manufacturer advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 83,000.

Filed May 27, 2025 · Steering · 92,000 miles · CA · crash

The contact owns a 2017 Ford Escape. The contact stated that while the daughter was driving at an undisclosed speed and turning away from the curb, there was a snap, and the steering wheel became horizontal regardless of the efforts to manually center it in its normal position. The vehicle continued veering to the right. The vehicle crashed into the rear of another parked unoccupied vehicle, where it came to a stop. No warning lights illuminated prior or after the crash. The air bags did not deploy. No injuries or medical attention were sought. A police report was not filed. An appointment with the dealer was scheduled to inspect the vehicle. The vehicle was not repaired. The contact stated that the vehicle was diagnosed by an independent mechanic for a front passenger side tie rod failure and was towed back to the contact's residence. The manufacturer was made aware of the failure. The failure mileage was approximately 92,000.Â