2017 Ford Escape: ball joint or control arm failure

Filed Jan 25, 2026 · Suspension, Transmission · PA

Vehicle was purchased [XXX], the very next day multiple lights came on on the dash and it started bucking while driving. I took it back to the dealership for repairs.The right rear wheel speed sensor was bad. While the vehicle was being repaired a bolt that was seized up was broken requiring the Rr wheel knuckle to be replaced. July, the vehicle was treated for a water leak into the spare tire compartment.In September, more repairs were needed. I took it to my mechanic.The L axle shaft, wheel bearing, control arm w/ball joint, speed sensor and Rt.knuckle needed replaced. At this point, I was informed of the extensive rust under the vehicle and only being 8 years old, is a great concern. When it was taken in for an alignment, it was discovered there was a bolt broken off the Rr control arm, and it was repaired. October, it was treated again for the water leak. Water was still getting in with the spare tire when it rained. Also in October, I noticed a lag in shifting when accelerating. One incident that happened when merging onto a highway, the shifting lagged, delaying my acceleration and caused my vehicle to be traveling at a much slower rate than traffic. I took it to the dealership for repairs for the lag and a grinding noise. The transmission and torque converter were replaced. The grinding noise continued even after the repairs. January 2026, the vehicle was again taken in for the grinding noise and water leak. It now requires a transfer case, drive shaft, rear differential and the sub frame is cracked. I am greatly concerned about the structural integrity of this vehicle. Dealership claims the rust of the frame is from PA winters however the steering shaft INSIDE the car also has rust on it. For comparison, I also have a 2003 Jeep and it has minimal rust and is kept outside daily. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 27, 2025 · Steering · 92,000 miles · CA · crash

The contact owns a 2017 Ford Escape. The contact stated that while the daughter was driving at an undisclosed speed and turning away from the curb, there was a snap, and the steering wheel became horizontal regardless of the efforts to manually center it in its normal position. The vehicle continued veering to the right. The vehicle crashed into the rear of another parked unoccupied vehicle, where it came to a stop. No warning lights illuminated prior or after the crash. The air bags did not deploy. No injuries or medical attention were sought. A police report was not filed. An appointment with the dealer was scheduled to inspect the vehicle. The vehicle was not repaired. The contact stated that the vehicle was diagnosed by an independent mechanic for a front passenger side tie rod failure and was towed back to the contact's residence. The manufacturer was made aware of the failure. The failure mileage was approximately 92,000.Â

Filed Jan 23, 2025 · Engine, Suspension · 152,000 miles · AL

The contact owns a 2017 Ford Escape. The contact stated that while her daughter was driving approximately 40-50 MPH, the vehicle lost motive power. The contact stated that there was a misfire coming from the vehicle. The driver was able to pull over safely. The check engine warning light was illuminated. The vehicle was taken to a parking lot. The vehicle was taken to an independent mechanic who determined that the control arm had fractured in half. The contact was informed that the spark plug, head gasket, turbo, and engine needed to be replaced. Additionally, there was freon inside the engine and the turbo was leaking. The contact called the local dealer and was informed that there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the federal safety agency Hotline. The approximate failure mileage was 152,000.

Filed Jun 16, 2023 · Engine, Steering · MA

Engine began smoking and had to be replaced 2 days after purchase (in 2020- covered under warranty.) Failed inspection for front end suspension problems which was covered under warranty at first but a year later needed struts and tie rods replaced.. In 2021 the transmission suddenly failed, cost $5,000 to repair out of pocket. The other day the power steering assist suddenly stopped working and I was told it would be $150-3,000 to fix.

Filed Jan 23, 2023 · Engine, Steering · AR

I am reporting coolant leaking into my engine causing my engine to lock up at around 75k to 80k miles. Torque converter needing to be replaced at around 80k miles. Torque converter clutch solenoid needing replacement at 80k miles. Rear CV joint axel needing replacement at 85k miles. Control arm replacement at 100k miles. The only recall is the transmission bushing, in which I haven’t fixed because I can’t move my vehicle out of my driveway. I have spend almost the same amount on this vehicle repairing it that I owe. The vehicle in a whole needs to be recalled. They are not safe and very costly in the long run. I am not happy with only 2 recalls being reported on this vehicle because I’ve read over 600 reviews with the same known problems and nothing has been done about it! If ford isn’t going to fix the known issues then the federal safety agency needs to help the consumers and report these issues!