2001 Ford Expedition brakes problems

Filed Sep 2, 2026 · Acceleration, Brakes · CA · fire

THe component was the speed control deactivation switch Manufacturer Recall Number 05S28 the federal safety agency Recall Number05V017000 Recall Status Recall Incomplete. It is unknown if the part is available for inspection but the vehicle is. The fire occurred while driving and left me stranded on the side of the road with five dogs, 2 hours away from home with no way of getting back. I had to find a hotel that allowed pets which was expensive and have been in said hotel starting August 25 through today, September 2. We are paid until tomorrow and I have exhausted all funds and resources. We will be without food, shelter, or teransportation. Yes the problemhas been confirmed by Santa Monica Lincoln Ford Dealership. The mechanic liason is Art Albrandt and can be reached at [XXX]. The vehicle has not been inspected by anyone other than the mechanics at thew Ford Dealership No there was no warning prior to the incident. The vehicle was running just fine. ZThe vehicle caught fire en route to Los Angeles frim San Bernardino County. AAA came and towed the vehicle to a friend's house because it was very late, and towed to the dealership the following morning. I found the nearest pet friendly hotel because I had no way to transport my animals any distance. I waited two days before being told that a part that was needed was discontinuerd, and they would have to find it at a pick a part over the weekend. At this point I had exhaiusted all of my financial resources and had to borrow funds to keep us housed. That following monday I was toild that the problem, specifically the part, that was related to the recall had been fixed however the vehicle still did not run and because it was so old they did not have the equipment to further diagnose it and referred us to a nearby mechanic who could help us. So far we have been referred to 4 mechanics and none are willing to even look at it. I filed a complaint with Ford, case number [XXX]. I explained that the recg INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FO

Filed Apr 30, 2024 · Brakes · CA

Front brake hose metal crimp completely rusted causing brake hose separation and failure. Design has rubber boot over crimp which actually retains moisture over many years. Boot may be intended to reduce stress at joint of metal to hose but actually enhanced failure mode. Drivers side came apart after minor bump during service, have photos of passenger side still intact but clearly fragile.

Filed Jan 9, 2020 · Brakes · 125,000 miles · NJ

Fyi my 2001 ford expedition is experiencing the same soft brake problem that warranted them to issue recall #19s54. I have changed the brakes and the problem persists . Ford needs to include the 2001 expeditions in this recall. It is very dangerous to stop this heavy vehicle with a soft brake pedal pushed all the way down !

Filed Aug 24, 2017 · Brakes · 170,000 miles · CA · crash · 1 injury

Tl* the contact owned a 2001 ford expedition. While driving approximately 25 MPH, the vehicle came to a stop. The brake pedal was depressed, but the vehicle failed to stop. As a result, the contact crashed into the rear of another vehicle. The contact sustained a back injury, which did not require medical attention. A police report was not filed. The vehicle was towed to an independent mechanic, but was not diagnosed or repaired. The vehicle was destroyed. The manufacturer was not notified of the failure. The approximate failure mileage was 170,000.

Filed Feb 13, 2015 · Brakes, Electrical · 125,000 miles · OR

This has been an issue since acquiring this vehicle. The brakes are very soft, they will pump up but when a quicker slow down or stop is needed an individual doesn't have a lot of time to remember that. There have been no injuries or crashes as of this date. Master cylinder was replaced on mechanic's advice however this did not improve this issue. As well the vehicle seems to need the lower ball joints wear out quickly. Also please note that each time it rains there is water coming in from somewhere on the top driver's side of the windshield and post. It drips from that hand grip down to light switch and into vent on driver's side as well. There have been times where there is an electrical smell which causes concern of a vehicle fire possibility.

Filed Jan 27, 2014 · Acceleration, Brakes · 110,000 miles · OH · crash

Tl* the contact owns a 2001 ford expedition. The contact stated that while driving approximately 10 MPH and applying the brakes, the vehicle suddenly accelerated and crashed into the rear of another vehicle. The contact stated that no injuries were reported and a police report was not field. The vehicle was neither diagnosed nor repaired. The manufacturer was not notified. The failure mileage was 110,000.

Filed Jul 11, 2013 · Brakes · 125,818 miles · MA

I have so much going on with rust, I forgot about my brakes lines bursting and having no brakes after having the front brakes repaired. They burst due to rust!!!!!!

Filed Jul 6, 2013 · Brakes, Suspension · 110,000 miles · PA

Ford expedition 5.4l 2001 - sudden brake failure while traveling 25 MPH in parking lot. Brake lines rusted through caused sudden brake failure. Car had undercarriage cleaning frequently during winter months and there was no indication of any problems. When replacing the brake lines, owner was informed that the upper and lower rear control arms were rusted through as well and that immediate replacement was necessary to avoid the rear track arm failure which results in dropping the rear axle and complete loss of vehicle control. Vehicle was purchased new in june 2001 and maintained continuously.owner has possession of corroded control arms after repair for evidence in the federal safety agency investigation. The federal safety agency is encouraged to contact the owner of vehicle for inspection of failed parts for investigative support.. This is a manufacturers defect and vehicles need to be recalled and parts replaced to avoid loss of vehicle control, accidents, injury and fatalities due to ford motor company negligence.

Filed Jan 2, 2010 · Acceleration, Brakes · OK · fire

Parked vehicle at store and turned it off got out and went inside. Then someone came inside and said that a black SUV was on fire. Returned to car and hurried and opened the hood. Had a drink in the truck so got it and threw it on the fire got it put out and looked it had started at the master cylinder and cruise control sensor.

Filed Aug 6, 2008 · Brakes · 82,208 miles · CA

Tl*the contact owns a 2001 ford expedition. While the contact was backing up the vehicle at an unknown speed, the brake pedal simply fell off. The brake pedal was reattached by a mechanic. The contact feels that this is a safety issue because the failure could have occurred while she was driving, resulting in a serious crash. The current and failure mileages were 82,208. Updated 10/03/08 *bf updated 10/06/08.