2005 Ford Expedition fuel system problems

Filed Dec 29, 2017 · Electrical, Fuel system · 133,000 miles · ME

Crank no start, after replaced new fuel pump, filter and other parts would not start and not getting fuel. Was in motion and died after making a right turn after filling fuel tank.

Filed Oct 20, 2017 · Fuel system, Visibility · 94,368 miles · NC

Tl* the contact owns a 2005 ford expedition. The contact stated that while driving at 65 MPH, the fuel cap and the tire sensor warning light illuminated. The vehicle was taken to the dealer (capital ford of charlotte located at 5411 n tryon st, charlotte, nc 28213) where it was diagnosed that the tire sensor, the fuel cap and the windshield wiper blade needed to be replaced. The vehicle was repaired. The contact stated that the fuel cap warning light, failure occurred even after replacing the part. The manufacturer was not contacted and was not made aware of the failure. The approximate failure mileage was 94,368.

Filed Jul 26, 2017 · Electrical, Fuel system · 218,000 miles · VA

Fuel pump driver module failed due to design flaw which caused galvanic corrosion. Aluminum body of component acts as the sacrificial anode for the frame which is steel. This caused my vehicle to stall at 65mph and lose power and thus caused the loss of power steering and hydraulic brake booster while traveling a high rate of speed. This could be especially dangerous on highways, congested areas, or areas with pedestrians such as schools. I have also notified ford of this problem.

Filed Nov 29, 2016 · Electrical, Engine · IL

This car just numerous of problem..... Who ever built this car did not have a good job of doing it

Filed Nov 7, 2016 · Fuel system · IL

My SUV was parked in parking lot of a store. Smoke started coming out from my vehicle. Then it started to catch on fire. Fire fighters said the fire started from the fuel injectors.

Filed Jun 13, 2016 · Engine, Fuel system · TX

For many time that my expedition has stalled because of the throttle body failing. The engine goes into safe mode and stalls and stops, thi is very danger situation

Filed May 3, 2016 · Body, Fuel system · IN

Transmission bad ,paint come out some areas, replace all the spark plugs

Filed Feb 5, 2015 · Engine, Fuel system · 129,000 miles · CA

While driving the vehicle went into a heavy vibration from the motor and the smell of raw fuel was present. After turning off the vehicle it would not start. The vehicle was towed to the ford dealer and the dealer stated that a fuel injector became stuck open. The injector filled the cylinder with fuel and caused the engine to blow up (severe damage). It was found that this occurred on ford expeditions numerous times and ford extended the warranty to 11 years, 120,000 miles and my scary experience occurred at 129,000. I previously replaced the motor at my own expense 2 years prior and ford did not replace the injectors or notify me of an injector issue. Ford is stating that they will not honor the warranty and the engine damage was caused by the injector that was not replaced. It was found that ford was aware of the injector issue since 2007. I'm not sure these issue are getting reported.

Filed Feb 5, 2015 · Electrical, Engine · 125,000 miles · NJ

While driving along at 55 MPH engine shut down. No power brakes, steering, etc. Indicator message on dashboard said "check electronic ignition". Repair cost $ 724.19.

Filed May 18, 2014 · Engine, Fuel system · 85,000 miles · TX

Electronic throttle control help, I have a 2005 expedition,. The thing has just started shutting down on me while driving. For no apparent reason, while driving along, it stops running, and after shutting it off, placing it in park, it will start back up. It was so scary , thanks god I didn't had any accident ,this is a big issue from ford